Professional Documents
Culture Documents
PRODUCT OVERVIEW
Premier SIPS screws are engineered and • 6 lobe drive head for less stripping
manufactured to give you control over • Sits tight to Premier SIPS surface
your project installation. • Heat treated steel for high strength
and durability
• Coated for superior corrosion resistance
• Superior wind up lift strength
Page 1 of 4
PREMIER SIPS WOOD SCREWS
Gimlet Point
0.189 Nominal Shank Dia.
All values provided below are average ultimate values. As determined by the project architect/engineer, appropriate safety factors must be used in design.
Tensile (lbs) Shear (lbs) Bending Yield Strength -Fyb(psi) Corrosion Resistance
AISI S904 AISI S904 ASTM F1575 ASTM D6294, ETAG 006
WITHDRAWAL: LUMBER & ENGINEERED WOOD (lbs/in.)1 HEAD PULL THRU (lbs)
1. Fastener penetrates 1” into the concrete or CMU block, including the tip. 1. 1-3/4” fastener embedment into edge grain, including tip.
2. Concrete masonry unit (CMU) conforming to ASTM C90.
Page 2 of 4
PREMIER SIPS LIGHT DUTY METAL SCREWS
0.189 Nominal Shank Dia. #2 (0.135” dia.)
T-30
6-Lobe Drive 2.750” Thread Length
0.625 Head Dia.
All values provided below are average ultimate values. As determined by the project architect/engineer, appropriate safety factors must be used in design.
Tensile (lbs) Shear (lbs) Bending Yield Strength -Fyb(psi) Corrosion Resistance
AISI S904 AISI S904 ASTM F1575 ASTM D6294, ETAG 006
Page 3 of 4
PREMIER SIPS HEAVY DUTY METAL SCREWS
#4 (0.195” dia.)
0.189 Nominal Shank Dia. Drill Point
All values provided below are average ultimate values. As determined by the project architect/engineer, appropriate safety factors must be used in design.
1. Minimum (3) threads of penetration of fastener through deck as measured from underside of steel
1/8” Structural
8-1/4” SIP 929
Steel1
1. Minimum (3) threads of penetration through steel as measured from underside of steel
Page 4 of 4