Total No. of Page 01 Roll Now...
‘THIRD SEMESTER Boch re
September-2018
MID SEMESTER EXAMINATION
PE205 Manufacturing Machines
Max. Marks: 30
Time: 1:30 Hours
Note:Answer all questions.
Assume suitable missing data, if any. :
5
la What do you mean by cutting tool nomenclature? Sketch three
views of a single point cutting tool and discuss the significance of
various angles.
1b How many ways taper turning is possible in a Centre lathe? 5
(i) Find out the amount of set-over of tail stock for turning a taper
on a job for 2/3 of its length from one end. Larger diameter is 100
mm and smaller diameter is 80 mm. Total length of job is 300
mm.
(ii) What should be the set over to tum a taper of 1 in 20 on ajob
of 160 mm. long such that it will have its larger diameter of 50
mm?
‘What are the various types of work holding devices generally used
ina lathe? Distinguish between face plate.and driving plate.
State with sketches and show the job- tool motion of the following §
lathe operations.
(i) Eccentric turning (ii) Spinning (iii) Knurling (iv) Parting-off
3 What is the need of a clapper box in a shaper? A surface plate of 7
dimensions Im x 1.2 m is to be’machined on a Planar. The
average citing speed is set at 24 m/min. The ratio of forward to
retum speed is 0.75, Determine the time of machining if
feed/stroke is 0.5 mm and time for reversing work table is 1.2 sec.
Also determine metal removal rate if depth of cut is 4mm.
END