Professional Documents
Culture Documents
Cessna 172R Sample Paper
Cessna 172R Sample Paper
37. In en-route climb, to improve engine cooling a short duration climb can be made at
a. The best angle of climb speed
b. The best rate of climb speed
c. Lower than the best rate of climb speed
d. Lower than the best angle of climb
38. Until engine has accumulated 50 hrs or engine
a. 70% power
b. 75% power
c. 80% power
d. 85%power
39. The recommended starter duty cycle is
a. 10 sec on,20 sec off ,max 3 time
b. 20 sec on ,10 sec off, max 2 time
c. As in (2)and repeat for max 2 time in the same cycle as (2) after a cooling 60 sec
d. As in (1) and repeat in the same cycle as (1) till engine starts
40. Max. weight of 2450 lbs ,the best rate of climb at sea level:
a. 71 KIAS
b. 79 KIAS
c. 65KIAS
d. 81KIAS
41. During engine starting , if engine floods
a. Turn on auxiliary fuel pump
b. Mixture in idle cut off
c. Close throttle full to ½ and crank engine
d. All are correct
42. Mark the correct statement in respect of compass
a. A knob on the lower left edge of the instrument is used to adjust the compass card
b. Compass card must be readjusted on extended flights
c. As in (2)and a knob on the lower right edge of the instrument for the heading bug.
d. All are correct
43. The transmitter of the bendix/kingXX 155 Anav/comm. System stops transmitting if the
microphone is keyed continuously for greater than
a. 30 sec
b. 33 sec
c. 36 sec
d. 39 sec
44. Flap switch lever mechanical stops and provided at
a. 10 degree Position
b. 20 degree Position
c. 30 degree position
d. all of the above
45. mark the incorrect statement
Innuctiator located above altimeter provides caution and warning messages for
a. fuel flow
b. oil pressure
c. low vacuum
d. low voltage situation
46. The red oil pressure illuminates when pressure is below.
a. 20 psi
b. 25 psi
c. 30 psi
d. None of the above
47. For extended flight, fill(dip stick indication)engine oil to
a. 5 quarts
b. 4 quarts
c. 6 quarts
d. None of the above
48. The alternator must be switched off manually if voltage indicates beyond
a. 30.5 v
b. 28.5 v
c. 31.5 v
d. 29.5 v
49. The max airspeed and altimeter variation over the normal operating range window(s)closed is
and alternator switched off is
a. 2 knots and 30 ft
b. 4 knots and 50 ft
c. 8 knots and 50 ft
d. 4 knots and 30 ft
50. In very cold weather condition after starting the engine, if oil pressure gauge does not being to
read pressure within ………..sec then stop the engine and investigate.
a. 30 sec
b. 45 sec
c. 60 sec
d. 75 sec
ANSWERS
1 C 11 C 21 A 31 C 41 B
2 A 12 B 22 D 32 B 42 D
3 A 13 A 23 B 33 B 43 B
4 B 14 A 24 A 34 C 44 D
5 B 15 C 25 A 35 B 45 A
6 C 16 D 26 D 36 C 46 A
7 B 17 B 27 A 37 B 47 D
8 C 18 C 28 C 38 C 48 C
9 C 19 D 29 C 39 A 49 D
10 b 20 C 30 C 40 B 50 C