Professional Documents
Culture Documents
Tes03ST Biomedik Gas 2324 Temperatur
Tes03ST Biomedik Gas 2324 Temperatur
TES 03 Temperatur
NRP digunakan untuk parameter soal.
(dikerjakan dengan tinta BIRU di kertas A4 dan
dikumpulkan tanggal 02 Nopember 2023 sebelum jam 12.00 WIB di MyClassroom)
NomeR Pokok : 0 7 3 1 5 0 2 3 T H 1 C B A
NomeR Pokok : 0 7 3 1 T H 4 0 0 0 0 C B A
Parameter soal yang harus dikerjakan.
Jika A=0 diganti 2 dan B=0 diganti 3
nrp-nama_T03.pdf
Problem No 1:
A temperature is measured with a J-type thermocouple and DVM as shown in Figure 3-80.
Ambient temperature is 28oC and the Voltmeter indicates 10.933 mVolt. What is the actual
temperature of the thermocouple?
Problem No 2:
A RTD is placed in a bridge just like the three-wire strain gage bridge of Figure 3-48b. The
three-bridge completion resistors are BA KOhm and the RTD is BA KOhm at 20oC.
a. What is the voltage across the bridge when the RTD is placed in a 200oC ?
b. How can you adjust the bridge to cause the output to go to 0 Volt at 0oC ? Give a
specific, number answer?
Problem No 3:
Suppose that the power supply for the circuit in Problem No 2 is 1.5 Volt dc.
a. Calculate the current through the RTD at 20oC.
b. Calculate the power dissipated by the RTD.
c. Assuming a typical value of self-heating error ½ oC per milliWatt, calculate absolute error
and % reading error introduced by self-heating at 20oC and at 220oC.