Professional Documents
Culture Documents
Exp. 7 Analysis of Milk For The Lipids Carbohydrates and Proteins
Exp. 7 Analysis of Milk For The Lipids Carbohydrates and Proteins
Exercise no. 7
ANALYSIS OF MILK FOR THE LIPIDS, CARBOHYDRATES AND PROTEINS
I. Introduction
1. ___________________________________________________
___________________________________________________
2. ___________________________________________________
___________________________________________________
III. MATERIALS
2-50ml beaker, triple beam balance, 1-100ml beaker, 3-10ml graduated
cylinder, 2 watch glass, test tube (big) with cork, 250ml beaker, Pasteur
pipette, 8-test tubes, test tube brush, test tube rack, test tube holder, Buchner
funnel, filter paper, water bath, electric stove, spatula, stirring rod, evaporating
dish, wire gauze
25ml methylene chloride, 1ml bromine solution, 1ml conc. Acetic acid, 1ml
Biuret test/reagent (0.01M CuSO4), 1 ml 6M NaOH, 6ml Benedict’s solution
(Fehlings), 1ml iodine solution
IV. PROCEDURE
PART I. Determining the Percent Fat in whole milk
1. Weigh a dry, clean, empty 100 mL beaker and record the mass.
3. Determine and record the mass of just milk. Then, add 20 mL of water into the
beaker.
4. Pour all of the milk into a large test tube. In the fume hood add 25 mL methylene
chloride to the milk and cork the tube. Methylene chloride is a nonpolar solvent
which with will not mix the water but will take the fat out of the water since fat is
also nonpolar.
5. Shake the test tube for 30 seconds trying not to get the cork wet: Let the content
of the test tube separate into layers.
6. Using a Pasteur pipet remove the milk layer leaving behind the methylene
chloride/ fat layer in a beaker and set aside the test tube with methylene
chloride/fat layer. Put the milk in the beaker and weight.
7. Weigh the beaker again with the milk and record your data and set aside.
8. To the test tube with the methylene chloride and removed fat, add 3 drops of bromine
solution.
9. Record the color of the solution in the test tube after the bromine has been added.
________________________________________________________________________
________________________________________________________________________
NOTE: Keep the milk in PART I in step 6 for the next part, pour the organic layer
with the fat, methylene chloride and bromine solution into the liquid waste
container.
Questions:
Is the fat content saturated or unsaturated? Explain.
__________________________________________________________________
__________________________________________________________________
Is there any other chemical test to determine the unsaturation of the structures? If
any, explain the test briefly.
__________________________________________________________________
__________________________________________________________________
__________________________________________________________________
__________________________________________________________________
17. Put 1ml of milk (PART 1 step 6) as test tube 1 and 1 gram of milk (PART III step
16) as test tube 2.
18. Add about 1 ml of Biuret Reagent (0.01M CuSO4) to both test tubes, #1 and #2.
19. Add 3 drops of 6M NaOH to each test tube and mix.
20. Record your observation.
Question:
Why Biuret test is used to determine the absence or presence of proteins? Explain
by giving your reasons and reactions if necessary.
__________________________________________________________________
__________________________________________________________________
__________________________________________________________________
__________________________________________________________________
21. Label 4 test tube as #1, #2, #3 and #4. Add 2mL of Benedict’s (Fehling’s)
Solution to test tubes #1 and #2. Place them in a water bath for about 4 minutes.
22. Put about 10 drops of the liquid you filtered (PART III step 14) in a test tube #1
and #3 and a few flakes of the solid in the other test tube #2 and #4. Leave tubes
#1 and #2 in the water bath but remove from the heat. Record your observation.
23. To test #3 and #4, add 10 drops of iodine solution and record your observation.
Questions:
What is the aim of performing Benedict’s test?
__________________________________________________________________
__________________________________________________________________
What is the aim of performing Iodine Test?
__________________________________________________________________
__________________________________________________________________
24. Weigh a clean dry evaporating dish and record the mass.
25. Add 5 mL of fresh milk to the evaporating dish and weigh again and record the
mass.
26. Set the evaporating dish with fresh milk on the top of the water bath and heat. Stir
the milk continuously to prevent burning.
27. Stop heating when the water is gone from the dish. You will no longer see steam
coming from the top of the dish. The dried milk from the stirring rod on the edge
of the evaporating dish.
28. Remove the evaporating dish and dry its bottom before you weigh it.
29. Weigh the dish with the dried milk and record.
HEATING %
Weight (g) of the Weight (g) of Weight (g) of Weight (g) of Weight (g) of Weight (g) COMPOSITION
evaporating dish evaporating dish milk the evaporating of milk
with milk evaporating dish with milk
dish
VI. CONCLUSION
__________________________________________________________________
__________________________________________________________________
__________________________________________________________________
__________________________________________________________________
__________________________________________________________________
__________________________________________________________________
__________________________________________________________________
__________________________________________________________________
__________________________________________________________________
__________________________________________________________________
__________________________________________________________________
__________________________________________________________________
__________________________________________________________________
__________________________________________________________________
__________________________________________________________________
__________________________________________________________________
__________________________________________________________________
__________________________________________________________________