Nominal size range
= ‘Over | Over] Over) Oven] Quer Over| Over] Over] Oved] Over Qvesl Over] Over] Over| Over Over] Over Over] Over] Over
Se ee ee eee ee
Pe? | ato | upto apt uptal up te up| upro| uel woe wp] upto] up| upe|upte| up el w elune| ue e| wee
Ba | Ba°| ‘Sa HB | wos | 306 [See Ba] SBE 15S] BS S05] 0S 9 Pa|ws ao
aan la ps be paspe [awh pat ete aia
crei8 ereslee p7siee jest p10/222
GIei7 pia [22 [s2ifeza[e25|-27[-2.9 6 sess? |- | —
GTB 16 [ett fe 12 fe 13s 142 1.8 [e 1.8): 1.82 1.9 =l=|=(=l=[=4
G18 15 |= 0.85) 095|e 1 [eu tet.2fe vals vals 15) 1 i =fst= me]
) respecte ofthe valuesgien inthis table, the actual Govation of tholinear cimensions ofa casting shallinno case be greater than
1125 Sof the nominal sige, rounded te ene decimal place. This restriction is 0! Bi
the boxee enclosed by thick lines.
Table 2: Limit devi
dicular relevance when applying the Gavistions in
ns for thicknesses (wall, web and rib thicknesses)*).
Nominal size range
Over | Over | Over | Over | Qver | Over | Over
Tolerance grade upwe | 8 70 18 30 50 80 120
P upto | upto | upto | upto | upto | upto | upto
10 18 30 50 Ea 120 | 180
GTB 20 a = fs [ 275 [sn [212 [23 [2
i GBTi9 = = J2a5 | 275 [+e Js ast+s | +10
GTB 18 = [226 ] 245 | =47 [5 |+55|+6 | 65
GTB 17 215 | 225 [+29 [23 |[232[234[+37[ -
- “GTBI6 16 | +19 [22 [+ 21 [= 23 =
GTB 15 211 | siz [eis[+ ia] — =
*) Irrespective of the values giver
this table, the actual deviation of the linear dimensions of a casting shall
no case be greater than £25 % of the nominal size, rounded to one decimal place. This restriction is of
particular relevance when applying the deviations in the boxes enclosed by thick lines.
~*)The values specified here are taken from the deviations specified for one full grade coarser in table 1
Position of
surface in mo
ul
Table 3: Machining allowances
Nominal size range
(based on the largest
overall dimen:
casting)
Bottom, side
Machining
allowance, BZ