Professional Documents
Culture Documents
The objective of this training is to enable new PolyWorks users to perform the
inspection of parts using the tools found in PolyWorks|Inspector™. The training covers
basic probing applications. More specifically, it covers the key concepts of a typical
inspection workflow for portable metrology. Once the training is successfully
completed, newly trained users can apply these concepts to perform inspections of
their own parts.
Outline
Content
PolyWorks basics
• Use the PolyWorks Workspace Manager interface
• Set Workspace Manager Options
• Units and plug-in selection
• Create and save a PolyWorks|Inspector project
• Use the PolyWorks|Inspector interface
• Define the steps of a typical inspection workflow
TRM-0020-2017-EN-0.0 1
Reference and Data objects
• Reference objects and nominals
• Import a CAD model
• Define nominals when no CAD model is available
• Data objects
• Connect to a device
• Acquire data in different device positions
Align
• Align using Surface Points
• Align using features
• Perpendicular Planes
• Plane, Axis, Center Point
• Best-fit measurement objects
• Align using Datum Reference Frames
• Create coordinate systems
Measure
• Create and probe measurement objects
• Features
• Comparison points
• Cross-sections
• Set dimensional and GD&T controls and tolerances
• Build/Inspect
TRM-0020-2017-EN-0.0 2
Inspect multiple pieces
• Prepare an inspection project using the Offline Simulation mode
• Perform an inspection using the Play Inspection autogenerated measurement
sequence
• Set probing and point acquisition parameters; add guiding instructions
• Review multipiece inspections using Object Control SPC
TRM-0020-2017-EN-0.0 3