Professional Documents
Culture Documents
20107-040-000-SPC-0058 Rev A1
20107-040-000-SPC-0058 Rev A1
20107-040-000-SPC-0058
Contract Title:
Document Title:
Contents
1. Introduction
2. Amendments
1. INTRODUCTION
This addendum shall be read in conjunction with the National Oil Corporation General
Engineering Specification GES V.01 Coded Pressure Vessels (ASME VIII) Rev0, 1999.
2. AMENDMENTS
The NOC Specification GES V.01 shall be modified as detailed below. The following
paragraph numbers in Bold are NOC Specification GES V.01 references.
1.1 Introduction
1.1.4
The technical data supplied by the owner for the equipment is given on the Data Sheets.
The Vendor/ Contractor shall complete the Data Sheets with any remaining information.
3.0 Design
Amend all references to ANSI standards throughout the document to read: ASME
Amend all references to ASTM material standards throughout the document to read: ASME
3.2.2 (f)
The stress concentrating effect of the nozzle shall be taken into account at the edge of the
nozzle in accordance with PD 5500 paragraphs G.2.3 for cylindrical shell and G.2.5 for
spherical shells (this is not covered by ASME Code).
3.2.8 (d)
3.2.8 (e)
3.2.8 (f)
Flanges machined from plate or formed from bar will not be permitted except for internal
non pressure retaining parts.
3.2.8 (g)
Where vessel wall thickness is 40 mm or over, reinforced or backing pads shall not be
used.
Nozzle neck thickness for process and instrument connections shall be suitable for the
design conditions (including any corrosion allowances) but shall not be less than the
following pipe schedules: