Professional Documents
Culture Documents
䢳䢰䢵 E012-1080
n Cause
There are some reported instances from the field where E012-0180 occurred because the
primary transfer roller was omitted to pressurize at the time of installation. This caused
insufficient tension to be applied to the ITB belt and a rotational failure of the belt.
䢳䢰䢶 E014-0100
n Description
There are some cases where E014-0100 occurred because the transmission shaft, which is
used in the transmission drive unit in the first fixing assembly lower, was chipped.
- E014-0100 indicates an error of the fixing drive motor (M300) in the first fixing assembly.
Timing Belt
Belt Tension Roller
Transmission Shaft
19T Gear
20分 Pulley
Ball Bearing
Transmission Shaft
FC6-0361
n Field Remedy
When a similar symptom occurs, inspect the shaft and replace it with a new one if chipping is
confirmed.
Note: Do NOT loosen 2 screws (which fix the transmission drive unit, red circle in the picture)
because the shaft and the gears can be replaced without removing the screws. Be aware of red
marking on them.
FC6-0361-000 Separation Drive Shaft FC6-0314-000 Belt Tension Roller
FU5-3197-000 20T Pulley XF2-1305-280 Timing Belt
XG9-0286-000 Ball Bearing FU6-0343-000 19T Gear