Professional Documents
Culture Documents
Article Content
Symptoms
This article provides information on removing components from a OptiPlex 7010 (USFF)
Table of Contents:
1. Wireless Module Removal
2. Internal Antenna Removal
3. System Fan Removal
4. Memory Removal
5. Heatsink Removal
During installation or removal of any hardware always ensure all data is backed up properly
Disconnect any telephone, network, or USB cables from the computer
Disconnect the computer and all attached devices from their electrical outlets
Remove the system cover, front bezel and drive cage
2. Establishing image.
3. Disconnect the two cables from the WLAN card.
4. Push the two securing levers away from the WLAN card.
Back to Top
During installation or removal of any hardware always ensure all data is backed up properly
Disconnect any telephone, network, or USB cables from the computer
Disconnect the computer and all attached devices from their electrical outlets
Remove the system cover, front bezel and drive cage
2. Establishing image.
Back to Top
During installation or removal of any hardware always ensure all data is backed up properly
Disconnect any telephone, network, or USB cables from the computer
Disconnect the computer and all attached devices from their electrical outlets
Remove system cover, front bezel and drive cage
2. Establishing image.
Back to Top
4. Memory Removal
1. Pre-Removal Instructions Before removing the Memory Removal:
During installation or removal of any hardware always ensure all data is backed up properly
Disconnect any telephone, network, or USB cables from the computer
Disconnect the computer and all attached devices from their electrical outlets
Remove the system cover, front bezel and drive cage
2. Establishing image.
3. Press out on the release tabs located on each side of the memory module.
4. Lift the memory module out of the connector on the system board and remove.
5. Complete.
Back to Top
5. Heatsink Removal
1. Pre-Removal Instructions Before removing the Heatsink Removal:
During installation or removal of any hardware always ensure all data is backed up properly
Disconnect any telephone, network, or USB cables from the computer
Disconnect the computer and all attached devices from their electrical outlets
Remove the system cover, front bezel and drive cage
2. Establishing image.
3. Disconnect the heat sink/fan assembly cable from the system board.
4. Press the release lever down and then move it outward to release the Fan retention hook that secures it.
5. Raise the heat sink/fan assembly.
6. Use a Phillips head screwdriver to loosen the four captive screws securing the heat sink/fan assembly to the system board.
7. Lift the heat sink/fan assembly upward gently, and remove it from the computer. Lay the assembly with the fan facing downward,
and with the thermal grease facing upward.
8. Complete.
Back to Top
Article Properties
Affected Product
OptiPlex 7010
Version
4
Article Type
Solution