Professional Documents
Culture Documents
For Double Bend tracks, as illustrated in the Manual, the bends are to be subdivided into the different radius
sectors such that measurements for both radii are taken where the radii coincide.
The record of control measurement and calculation of length should be adapted for other double bend
configurations by dividing the arcs into a different number of segments so that the length of each bend arc is
approximately equal, but the number of measurements per segment should not be less than four.
Example of the control measurement of 400m Double Bend Track (based on 1.2.3b)
L D L D L D L D L D L D L D L D L D
gon m mm m mm m mm m mm m mm m mm m mm m mm m mm
1 0.000 34.001 1 35.222 2 36.442 2 37.659 -1 38.883 3 40.100 0 41.321 1 42.538 -2 43.760 0
Averaged 1-4 34.001 0 35.222 2 36.442 2 37.661 1 38.881 1 40.100 0 41.320 0 42.541 1 43.760 0
Averaged 5-8 51.542 -1 52.765 2 53.983 0 55.204 1 56.424 1 57.643 0 58.865 2 60.083 0 61.305 2
12 200.000 33.999 -1 35.222 2 36.441 1 37.661 1 38.882 2 40.101 1 41.323 3 42.541 1 43.761 1
Averaged 9-12 34.000 0 35.222 2 36.440 0 37.660 0 38.881 1 40.101 1 41.321 1 42.541 1 43.761 1
Averaged 14-17 33.999 1 35.222 1 36.441 1 37.661 1 38.882 2 40.100 0 41.319 -1 42.542 2 43.762 2
Averaged 18-21 51.543 0 52.763 -2 53.983 0 55.201 -2 56.425 2 57.640 -3 58.862 -1 60.082 -1 61.303 0
Averaged 22-25 35.220 0 36.440 1 37.660 0 38.879 -2 40.101 0 41.320 -1 42.544 4 43.761 1
×π
13 S
27 A
28 A
Length
The bend lengths and length deviations shall be calculated to three decimal places using bend average radii
and differences to four decimal places.
Lane 1 Distance Angle Length
Average radius curve A - H m gon m (+)
Average radius curve H - G m gon m (+)
Average radius curve G - D m gon m (+)
Average radius curve C - F m gon m (+)
Average radius curve F - E m gon m (+)
Average radius curve E - B m gon m (+)
Straight C – D (13) n/a n/a m (+)
Straight A – B (26) n/a n/a m (+)
Length of the inside border n/a n/a m (=)