Professional Documents
Culture Documents
S40 Radio and Dashboard Related
S40 Radio and Dashboard Related
Preparations
Remove:
- the rear centre console according to Rear
centre console
- the front centre console according to Front
centre console
- the side panels on the centre console
according to Centre console panels
- the soundproofing panel on the driver's side
according to Driver's side soundproofing
- the soundproofing panel on the passenger
side according to Passenger side
soundproofing
- the combined instrument panel according to
Driver information module (DIM),
installation/removal, component replacement
- the radio panel according to The radio panel
- the dashboard environment panel according
to Dashboard environment panel
- the A-post panel according to Upper A-post
panel .
Open the glove compartment.
Remove:
- the two screws
- the storage compartment using a twisting
movement.
file://C:\Info\vv132007\ie\en\24\vcc-128622.htm 1/31/2009
"VCC-128622 EN 2009-01-31" Page 2 of 13
Remove:
- the central electronic module (CEM)
according to Replacing central electronic
module (CEM)
- the cable. First unhook the cable from the
bonnet catch
- the screw (A) at the front of the dashboard
- the screw from the top of the bracket
- the bracket
- brown and blue connectors by the side of the
fusebox from the cable harness
- the connectors from the cable harness.
Press the grey marked 24–pin connector out
through the opening on the reverse of the
dashboard.
Remove the blue connector for VGLA.
Remove the clips from the cable harness.
file://C:\Info\vv132007\ie\en\24\vcc-128622.htm 1/31/2009
"VCC-128622 EN 2009-01-31" Page 3 of 13
Disconnecting airbags
file://C:\Info\vv132007\ie\en\24\vcc-128622.htm 1/31/2009
"VCC-128622 EN 2009-01-31" Page 4 of 13
Install:
- the connector in the loudspeaker
- the loudspeaker in the dashboard.
Note! See the illustration for the location.
Install the rear edge of the loudspeaker grille
and press the front edge into position.
Note! Start on the right-hand side.
Install:
- the two connectors from the cable harness
for the dashboard
- the blue and brown connectors from the
dashboard cable harness
- the bracket and install the upper screw by
hand
- the bonnet catch and the three screws.
Tighten to 10 Nm
- the cable from the bonnet catch
- the cable harness clips in the dashboard
- the screw for the dashboard in the bracket (A)
- The central electronic module (CEM)
according to Replacing central electronic
module (CEM) .
Installing the loudspeaker and loudspeaker grille
on the driver's side
Install:
- the connector in the loudspeaker
- the loudspeakers in the dashboard
the loudspeaker grille.
file://C:\Info\vv132007\ie\en\24\vcc-128622.htm 1/31/2009
"VCC-128622 EN 2009-01-31" Page 5 of 13
Installing components
Install:
- the combined instrument panel according to
Driver information module (DIM),
installation/removal, component replacement
- the comfort control module according to
Comfort module
- the radio panel according to The radio panel
- the front centre console according to Front
centre console
- the rear centre console according to Rear
centre console
- the soundproofing panel according to Driver's
side soundproofing and Passenger side
soundproofing
- the upper A-post panel according to Upper A-
post panel .
Final check
file://C:\Info\vv132007\ie\en\24\vcc-128622.htm 1/31/2009
"VCC-128622 EN 2009-01-31" Page 6 of 13
Remove:
- the dashboard environment panel according
to Dashboard environment panel
- the three screws for the bracket
- the centre console.
If required: Disconnect the connector.
Install:
- the centre console
- the three screws for the bracket
- the dashboard environment panel according
to Dashboard environment panel
- the radio.
file://C:\Info\vv132007\ie\en\24\vcc-128622.htm 1/31/2009
"VCC-128622 EN 2009-01-31" Page 7 of 13
1.
Carefully install weatherstrip tool 981 4071
between the dashboard and the bottom edge of
the panel.
Pull the bottom edge of the panel outwards.
2.
Press the panel up slightly.
Carefully pull the upper edge of the panel
outwards.
Remove the panel.
Installing the dashboard environment panel
Install the panel above the dashboard
environment panel.
Press the panel into place.
Check the alignment of the panel to the
dashboard environment panel.
Check the functions of the switch and the knob.
Comfort module
Special tools: 981 4071
Preparations
Prepare the car according toNote when
disconnecting and connecting the battery lead .
Removing the comfort module
Remove:
- the panel. See Dashboard environment panel
- the radio panel according toThe radio panel
the two screws.
file://C:\Info\vv132007\ie\en\24\vcc-128622.htm 1/31/2009
"VCC-128622 EN 2009-01-31" Page 8 of 13
Remove:
- the rubber underlay (1)
- the gear selector panel (2) by pressing in the
lugs.
Manual transmissions only:
Press in the clip and remove the gear selector
lever boot.
Apply the handbrake.
Remove the guard (3) and screw (4).
Pull the rear centre console upwards at the front
edge. Remove the gray connector.
Remove the rear centre console.
file://C:\Info\vv132007\ie\en\24\vcc-128622.htm 1/31/2009
"VCC-128622 EN 2009-01-31" Page 9 of 13
file://C:\Info\vv132007\ie\en\24\vcc-128622.htm 1/31/2009
"VCC-128622 EN 2009-01-31" Page 10 of 13
Remove:
- the rear centre console according to Rear
centre console
- the waste paper basket(A)
- the two screws
- the rear panel (B) carefully. Use weatherstrip
tool 981 4071
- the four screws
- the armrest assembly.
file://C:\Info\vv132007\ie\en\24\vcc-128622.htm 1/31/2009
"VCC-128622 EN 2009-01-31" Page 11 of 13
Remove:
- the rear centre console according to Rear
centre console
- the four screws
- the front centre console locker
- the front armrest according to Removing the
armrest
- the four screws
- the rear centre console locker.
If there is damage: replace the cover.
Installing the centre console locker for the rear
centre console
Install:
- the rear centre console locker
- the four screws
- the front armrest according to Installing the
armrest
- the front centre console locker
- the four screws
- the rear centre console according to Rear
centre console .
file://C:\Info\vv132007\ie\en\24\vcc-128622.htm 1/31/2009
"VCC-128622 EN 2009-01-31" Page 12 of 13
Install:
- the tie strap with clips on the panel
- the panel under the centre console
- the screw.
Check the alignment.
Remove:
- the three screws
- the lower panel.
Lower the steering column to its lowest
position.
Remove the upper panel.
file://C:\Info\vv132007\ie\en\24\vcc-128622.htm 1/31/2009
"VCC-128622 EN 2009-01-31" Page 13 of 13
file://C:\Info\vv132007\ie\en\24\vcc-128622.htm 1/31/2009