This document summarizes an experiment to measure the I-V curve of a diode using Multisim software. The experiment involves constructing a resistor-diode series circuit with a variable DC power source. Voltage is varied from 0-2V in increments and the corresponding voltage across and current through the diode is recorded. The resistance across the diode is then calculated from these measurements and recorded in a table. The goal is to observe the non-linear I-V relationship of a diode and calculate its resistance over a range of voltages.
This document summarizes an experiment to measure the I-V curve of a diode using Multisim software. The experiment involves constructing a resistor-diode series circuit with a variable DC power source. Voltage is varied from 0-2V in increments and the corresponding voltage across and current through the diode is recorded. The resistance across the diode is then calculated from these measurements and recorded in a table. The goal is to observe the non-linear I-V relationship of a diode and calculate its resistance over a range of voltages.
This document summarizes an experiment to measure the I-V curve of a diode using Multisim software. The experiment involves constructing a resistor-diode series circuit with a variable DC power source. Voltage is varied from 0-2V in increments and the corresponding voltage across and current through the diode is recorded. The resistance across the diode is then calculated from these measurements and recorded in a table. The goal is to observe the non-linear I-V relationship of a diode and calculate its resistance over a range of voltages.
KWAME NKRUMAH UNIVERSITY OF SCIENCE AND TECHNOLOGY (KNUST),
KUMASI COLLEGE OF SCIENCE FACULTY OF COMPUTATIONAL AND PHYSICAL SCIENCES DEPARTMENT OF PHYSICS
EXPERIMENT TITLE: I-V CURVE OF DIODE USING MULTISIM
Name: GILBERT BLAH QUARSHIE Index Number: 4280520 Date: 07/02/2023 1. Using Multisim environment, construct a resistor (1KΩ) – diode (1N3064) series network with a DC power source. 1. Set the internal voltmeter resistance to 1000MΩ and the internal resistance of the ammeter to 1nΩ, so that the meters are very nearly ideal. 2. Vary the supply voltage from 0.0V to 2.0V and record the observed voltage across the diode and the current through the diode in Table 1below. Voltage across battery Voltage across diode Current through diode (Supply Units) (Supply Units)
0.0 0.000v 0.0000mA
0.1 0.100v 0.0000mA 0.2 0.200v 0.0000mA 0.3 0.300v 0.0000mA 0.4 0.399v 0.0005mA 0.5 0.486v 0.0140mA 0.6 0.528v 0.0720mA 0.7 0.548v 0.1520mA 0.8 0.560v 0.2400mA 0.9 0.568v 0.3320mA 1.0 0.575v 0.4250mA 1.1 0.581v 0.5190mA 1.2 0.585v 0.6150mA 1.3 0.590v 0.7100mA 1.4 0.593v 0.8070mA 1.5 0.597v 0.9030mA 1.6 0.600v 1.0000mA 1.7 0.602v 1.0980mA 1.8 0.605v 1.1950mA 1.9 0.607v 1.2930mA 2.0 0.610v 1.3900mA 3. Compute and fill in the obtained resistances in the resistance column in Table 2. Voltage across the Voltage across diode Current through diode Resistance across power source (Supply Units!) (Supply Units!) diode (Supply Units!)