Professional Documents
Culture Documents
for the
Development of International Standards, Guides and Recommendations issued by the World Trade Organization Technical Barriers to Trade (TBT) Committee.
Designation: D2216 − 19
3
For referenced ASTM standards, visit the ASTM website, www.astm.org, or 4
contact ASTM Customer Service at service@astm.org. For Annual Book of ASTM The last approved version of this historical standard is referenced on
Standards volume information, refer to the standard’s Document Summary page on www.astm.org.
the ASTM website.
TABLE 1 Minimum Requirements for Mass of Test Specimens, and Balance ReadabilityA
Method A Method B
Maximum Particle Size (100 % Passing)
Water Content Recorded to ±1 % Water Content Recorded to ±0.1 %
Minimum Minimum
Alternative Sieve Balance Balance
Sieve Size Specimen Specimen
Size Readability (g) Readability (g)
Mass Mass (g)
75.0 mm 3 in. 5 kg 10 50 kg 10
37.5 mm 1-1⁄2 in. 1 kg 10 10 kg 10
19.0 mm 3⁄4 in. 250 g 0.1 2.5 kg 0.1
9.5 mm 3⁄8 in. 50 g 0.1 500 g 0.1
4.75 mm No. 4 100 g 0.01
2.00 mm No. 10 20 g 0.01
A
See 1.10.2.
APPENDIX
(Nonmandatory Information)
X Method A
Test Method:
Method B
Remarks:
SUMMARY OF CHANGES
Committee D18 has identified the location of selected changes to these test methods since the last issue,
D2216–10, that may impact the use of these test methods. (March 1, 2019)
(1) Added a more detailed description of water content in the (3) Eliminated the reference to E145.
Scope. (4) Revised oven requirements in Apparatus Section.
(2) Included statement for use of water content when used in (5) Revised Report Section to conform to D18 SPM.
conjunction with other soil relationships. (6) Incorporated grammatical and spelling revisions.
This standard is subject to revision at any time by the responsible technical committee and must be reviewed every five years and
if not revised, either reapproved or withdrawn. Your comments are invited either for revision of this standard or for additional standards
and should be addressed to ASTM International Headquarters. Your comments will receive careful consideration at a meeting of the
responsible technical committee, which you may attend. If you feel that your comments have not received a fair hearing you should
make your views known to the ASTM Committee on Standards, at the address shown below.
This standard is copyrighted by ASTM International, 100 Barr Harbor Drive, PO Box C700, West Conshohocken, PA 19428-2959,
United States. Individual reprints (single or multiple copies) of this standard may be obtained by contacting ASTM at the above
address or at 610-832-9585 (phone), 610-832-9555 (fax), or service@astm.org (e-mail); or through the ASTM website
(www.astm.org). Permission rights to photocopy the standard may also be secured from the Copyright Clearance Center, 222
Rosewood Drive, Danvers, MA 01923, Tel: (978) 646-2600; http://www.copyright.com/