Professional Documents
Culture Documents
com/)
Drinker availability
Drinker position and design
Water flow
Water quality
Transitioning to a new barn at weaning can cause dehydration in piglets due to stress and an
unfamiliar environment. It has been shown that it can take about 35 hours for 85% of pigs to
consistently find water. The 15% that are unable to find water by that time will likely become your
day 2 and 3 pulls.
Water dripping slowly from cups or nipples can help pigs locate the water source and begin drinking. A swinging water nipple can be added in
Consider adjusting drinkers to allow a slow drip for 6 hours. high stocking density situations to ensure
proper drinker availability.
Adding extra water sources the first few days after placement can also encourage pig water intake.
Try placing water in gruel pans upon entry or even placing some water in feeder pans if it does not
affect feed flow or access.
In high-stocking-density situations, consider adding extra water sources, such as swinging nipples, gate-mounted nipples or water bars.
Drinkers with nipples at a 60-degree angle should be set 2-3 inches above shoulder height of the
smallest pig in the pen. If using bowl waterers, the lip of the bowl should be 40% of the height of the
smallest pig. Bowl drinkers should be placed near feeders, and nipple drinkers should be placed in a
wet area of the pen. For both styles of drinkers, allow ample space for pigs to access them.
Regardless of drinker type, be sure to adjust water source height regularly to maximize water intake.
Bowl water sources placed too low are more likely to get littered with fecal material. Proper drinker position for a pig.
Between groups, ensure all nipples and bowls are flowing properly. Audit water flow rate in 10% of drinkers on a
weekly basis. Rotate the drinkers being checked to ensure all get checked periodically. Closely monitor flow rate
during the nursery stage; if pressure is too high (>1 L/min), it might limit pig water intake, increase water waste
or increase humidity in the barn.
If cool cells, misters or sprinklers are used in warmer months, be sure to maintain proper flow rate during peak
usage. This also applies during pig pen washing times.
Water quality to support pig performance The cap from a can of spray
paint is a handy tool to measure
Water quality can vary based on regions, water source and pH. Pigs have been shown to be reasonably resilient water flow rate.
if the water quality is consistent from the sow farm to the nursery and on to the finisher. The table below shows
(https://www.pic.com/)
the recommended maximum levels of different elements and minerals in water. Pig performance might be
affected if concentration levels are exceeded.
For more information regarding PIC’s recommendations on water quality, listen to (https://www.pic.com/resources/the-squeal-0019/) The Squeal episode
0019: Nutrient Access and Availability.
Dirty water lines or biofilm build-up can have a negative impact on water quality and flow rate. Check and clean water lines two times per year to remove the
presence of any buildup or biofilm. Usually, a peroxide or citric acid-based product works best, but this depends on the water parameters in your barn. Not
only do you need to flush the main line, but you might also need to remove water nipples if they become clogged. Dirty water lines can reduce water flow by
up to 30%.
All the information above can be found in PIC’s Wean-to-Finish Guidelines (https://www.pic.com/resources/wean-to-finish-manual-english/) or
the GrowQuest tool (https://www.pic.com/resources/growquest/). For more information, contact your PIC Technical Services representative.
(https://www.pic.com)