Professional Documents
Culture Documents
Product Information
To:
Note: 1. Please contact IiforVision Company. before designing your product based on this product.
2. The information contained herein is presented merely to indicate the characteristics and
performance of our products. No responsibility is assumed by IVO for any intellectual property
claims or other problems that may result from application based on the module described herein.
FQ-7-30-0-009-02C
________________________________________________________________________
NO.1 Long Teng Road, KunShan City, JiangSu, China Tel:0512-57278888
InfoVision Optoelectronics (Kunshan) Co., LTD Fax:0512-57278900
Page 1 of 29
昆山龙腾光电有限公司
InfoVision Optoelectronics ( Kunshan ) Co.,LTD.
Document Title M101NWT2 R2 Product Information Page No. 2/29
________________________________________________________________________
NO.1 Long Teng Road, KunShan City, JiangSu, China Tel:0512-57278888
InfoVision Optoelectronics (Kunshan) Co., LTD Fax:0512-57278900
Page 2 of 29
昆山龙腾光电有限公司
InfoVision Optoelectronics ( Kunshan ) Co.,LTD.
Document Title M101NWT2 R2 Product Information Page No. 3/29
Contents
1 General Descriptions ....................................................................................................................4
4 Optical Characteristics..................................................................................................................8
5 Backlight Characteristics............................................................................................................ 11
6 Electrical Characteristics............................................................................................................12
10 Mechanical Characteristics........................................................................................................19
________________________________________________________________________
NO.1 Long Teng Road, KunShan City, JiangSu, China Tel:0512-57278888
InfoVision Optoelectronics (Kunshan) Co., LTD Fax:0512-57278900
Page 3 of 29
昆山龙腾光电有限公司
InfoVision Optoelectronics ( Kunshan ) Co.,LTD.
Document Title M101NWT2 R2 Product Information Page No. 4/29
1 General Descriptions
1.1 Introduction
The M101NWT2 R2 is a color active matrix thin film transistor (TFT) TN liquid crystal
display (LCD) that uses amorphous silicon TFT as a switching device. It is composed of a
TFT LCD panel, a timing controller, voltage reference, common voltage, column driver,
and row driver circuit. This TFT LCD has a 10.1-inch diagonally measured active display
area with WSVGA resolution (1,024vertical by 600 horizontal pixel array).
1.2 Features
■ 10.1” TFT LCD Panel
■ LED Light-bar Backlight System
■ Supported WSVGA (V:1024 lines, H:600 pixels) Resolution
■ Compatible with RoHS Standard
■ Dual Gate (2 Source + 2 Gate)
1.3 Product Summary
Items Specifications Unit
Screen Diagonal 10.1 Inch
Active Area 222.72(H) x 125.28(V) mm
Pixels H x V 1,024 (x3) x 600 -
Pixel Pitch 0.2175(H)x0.2088(V) mm
Pixel Arrangement R.G.B. Vertical Stripe -
Display Mode Normally White (TN) -
2
White Luminance 200 (Typ.) 5 points average cd/ m (20mA of per LED)
Contrast Ratio 500 (Typ.) -
Response Time ( )
8 Typ. ms
View Angle(L/R/U/D) 45/45/15/35(Typ.) -
Input Voltage +3.3 (Typ.) V
Power Consumption (2.4) (Max) Watt
Module Weight 190(Max.) g
Outline Dimension (MAX) 235.5 x 143.5 x5.2 mm
Electrical Interface (Logic) LVDS -
Support Color 262 K -
Color Gamut 45%(Typ.) -
Optimum Viewing Direction 6 o’clock -
Surface Treatment Anti-Glare + HC -
________________________________________________________________________
NO.1 Long Teng Road, KunShan City, JiangSu, China Tel:0512-57278888
InfoVision Optoelectronics (Kunshan) Co., LTD Fax:0512-57278900
Page 4 of 29
昆山龙腾光电有限公司
InfoVision Optoelectronics ( Kunshan ) Co.,LTD.
Document Title M101NWT2 R2 Product Information Page No. 5/29
________________________________________________________________________
NO.1 Long Teng Road, KunShan City, JiangSu, China Tel:0512-57278888
InfoVision Optoelectronics (Kunshan) Co., LTD Fax:0512-57278900
Page 5 of 29
昆山龙腾光电有限公司
InfoVision Optoelectronics ( Kunshan ) Co.,LTD.
Document Title M101NWT2 R2 Product Information Page No. 6/29
1.5G G
Vibration - 30min for X, Y, Z axis
~
10 500Hz Hz
220 G
Shock - Half sign wave
2 ms
Note
(1) Maximum Wet-Bulb should be 39 degree C. No condensation.
℃
(2) When you apply the LCD module for OA system. Please make sure to keep the
temperature of LCD module is less than 60 .
(3) Storage /Operating temperature.
________________________________________________________________________
NO.1 Long Teng Road, KunShan City, JiangSu, China Tel:0512-57278888
InfoVision Optoelectronics (Kunshan) Co., LTD Fax:0512-57278900
Page 6 of 29
昆山龙腾光电有限公司
InfoVision Optoelectronics ( Kunshan ) Co.,LTD.
Document Title M101NWT2 R2 Product Information Page No. 7/29
Figure 2 shows the relationship of the input signals and LCD pixel format image.
________________________________________________________________________
NO.1 Long Teng Road, KunShan City, JiangSu, China Tel:0512-57278888
InfoVision Optoelectronics (Kunshan) Co., LTD Fax:0512-57278900
Page 7 of 29
昆山龙腾光电有限公司
InfoVision Optoelectronics ( Kunshan ) Co.,LTD.
Document Title M101NWT2 R2 Product Information Page No. 8/29
4 Optical Characteristics
The optical characteristics are measured under stable conditions as following notes.
Table 2 Optical Characteristics
Specification
Item Conditions
Min Typ. Max Note
Left 40 45 -
Horizontal
Viewing Angle [degrees] Right 40 45 -
A, B
K=Contrast Ratio>10 Up 10 15 -
Vertical
Down 30 35 -
Contrast ratio Center 350 500 - A, C
Response Time [ms] Rising + Falling - 3+5 16 A, D
Red x 0.579 A,
Red y 0.346 A,
Typ.
Green x Typ. 0.336 A,
+0.03
Color Chromaticity Green y -0.03 0.560 A,
(CIE1931) Blue x 0.156 A,
Blue y 0.123 A,
White x 0.283 0.313 0.343 A,
White y 0.299 0.329 0.359 A,
White Luminance [cd/m^2] I-LED=20.0mA 180 200 - 5point A, E
I-LED =20mA, 13points 62.5 - -
Luminance Uniformity [%] A, F
I-LED =20mA, 5points 80.0 - -
________________________________________________________________________
NO.1 Long Teng Road, KunShan City, JiangSu, China Tel:0512-57278888
InfoVision Optoelectronics (Kunshan) Co., LTD Fax:0512-57278900
Page 8 of 29
昆山龙腾光电有限公司
InfoVision Optoelectronics ( Kunshan ) Co.,LTD.
Document Title M101NWT2 R2 Product Information Page No. 9/29
LCD Module
LCD Panel
Photo meter (DMS 1140)
Center of the Screen
Normal
θx = θy = 0°
θy- θy+
12 o'clock direction
θx- = 90°
x- y+ θy+ = 90°
θx-
θx+
6 o'clock y-
θy- = 90° x+
θx+ = 90°
________________________________________________________________________
NO.1 Long Teng Road, KunShan City, JiangSu, China Tel:0512-57278888
InfoVision Optoelectronics (Kunshan) Co., LTD Fax:0512-57278900
Page 9 of 29
昆山龙腾光电有限公司
InfoVision Optoelectronics ( Kunshan ) Co.,LTD.
Document Title M101NWT2 R2 Product Information Page No. 10/29
10mm 10mm
1/4 H 1/2 H 3/4 H
10mm Y7
Y6 Y8
Y2
1/4 V
Y1 Y9
Y13 1/2 V
Y4 Y5 3/4 V
Y10
Y12 Y11
10mm
________________________________________________________________________
NO.1 Long Teng Road, KunShan City, JiangSu, China Tel:0512-57278888
InfoVision Optoelectronics (Kunshan) Co., LTD Fax:0512-57278900
Page 10 of 29
昆山龙腾光电有限公司
InfoVision Optoelectronics ( Kunshan ) Co.,LTD.
Document Title M101NWT2 R2 Product Information Page No. 11/29
5 Backlight Characteristics
5.1 Parameter Guideline of LED Backlight
Table 3 Parameter Guideline for LED Backlight
Symbol Parameter Min. Typ. Max. Units Condition
A: The LED life time define as the estimated time to 50% degradation of initial luminous.
B: Strong propose to set LED Input Voltage 12V, it would be best power efficiency.
________________________________________________________________________
NO.1 Long Teng Road, KunShan City, JiangSu, China Tel:0512-57278888
InfoVision Optoelectronics (Kunshan) Co., LTD Fax:0512-57278900
Page 11 of 29
昆山龙腾光电有限公司
InfoVision Optoelectronics ( Kunshan ) Co.,LTD.
Document Title M101NWT2 R2 Product Information Page No. 12/29
6 Electrical Characteristics
6.1 Interface Connector
Table 4 Connector Name / Designation
1 GND Ground
2 VDD Power supply 3.3V(Typ.)
3 VDD Power supply 3.3V(Typ.)
4 VEDID EDID +3.3V Power
5 NC Not connected(Reserve) LCD panel self test
6 CLK_EDID EDID Clock Input
7 DAT_EDID EDID Data Input
8 RXin0- -LVDS differential data input(R0-R5,G0)
9 RXin0+ +LVDS differential data input(R0-R5,G0)
10 GND Ground
11 RXin1- -LVDS differential data input(G1-G5,B0-B1)
12 RXin1+ +LVDS differential data input(G1-G5,B0-B1)
13 GND Ground
14 Rin2- -LVDS differential data input(B2-B5,HS,VS,DE)
15 Rin2+ +LVDS differential data input(B2-B5,HS,VS,DE)
16 GND Ground
17 CLKN- -LVDS differential clock input
18 CLKN+ +LVDS differential clock input
19 NC Not connected(Reserve) Reserve for Color_EN
20 NC Not connected(Reserve)
21 NC Not connected(Reserve)
22 GND Ground-Shield
23 NC Not connected(Reserve)
24 NC Not connected(Reserve)
25 GND Ground-Shield
26 NC Not connected(Reserve)
27 NC Not connected(Reserve)
________________________________________________________________________
NO.1 Long Teng Road, KunShan City, JiangSu, China Tel:0512-57278888
InfoVision Optoelectronics (Kunshan) Co., LTD Fax:0512-57278900
Page 12 of 29
昆山龙腾光电有限公司
InfoVision Optoelectronics ( Kunshan ) Co.,LTD.
Document Title M101NWT2 R2 Product Information Page No. 13/29
28 GND Ground-Shield
29 NC Not connected(Reserve)
30 NC Not connected(Reserve)
31 VLED_GND LED Ground
32 VLED_GND LED Ground
33 VLED_GND LED Ground
34 NC Not connected(Reserve)
35 VPWM_EN System PWM Logic Input Level
36 VLED_EN LED enable Input Level(+3.3V)
37 NC Not connected(Reserve) Reserve for DBC
38 VLED LED Power Supply
39 VLED LED Power Supply
40 VLED LED Power Supply
Note:All input signals shall be low or Hi-Z state when VDD is off.
Note:
A. Input signals shall be low or Hi-Z state when VDD is off.
B. All electrical characteristics for LVDS signal are defined and shall be measured at
the interface connector of LCD.
Note: All values are at VDD=3.3V, Ta=25 degree C.
________________________________________________________________________
NO.1 Long Teng Road, KunShan City, JiangSu, China Tel:0512-57278888
InfoVision Optoelectronics (Kunshan) Co., LTD Fax:0512-57278900
Page 13 of 29
昆山龙腾光电有限公司
InfoVision Optoelectronics ( Kunshan ) Co.,LTD.
Document Title M101NWT2 R2 Product Information Page No. 14/29
________________________________________________________________________
NO.1 Long Teng Road, KunShan City, JiangSu, China Tel:0512-57278888
InfoVision Optoelectronics (Kunshan) Co., LTD Fax:0512-57278900
Page 14 of 29
昆山龙腾光电有限公司
InfoVision Optoelectronics ( Kunshan ) Co.,LTD.
Document Title M101NWT2 R2 Product Information Page No. 15/29
Figure 10 LVDS Receiver Internal Circuit shows the internal block diagram of the LVDS
receiver. This LCD module equips termination resistors for LVDS link.
________________________________________________________________________
NO.1 Long Teng Road, KunShan City, JiangSu, China Tel:0512-57278888
InfoVision Optoelectronics (Kunshan) Co., LTD Fax:0512-57278900
Page 15 of 29
昆山龙腾光电有限公司
InfoVision Optoelectronics ( Kunshan ) Co.,LTD.
Document Title M101NWT2 R2 Product Information Page No. 16/29
7. Interface Timings
7.1 Timing Characteristics
Table 7 Interface Timings
Parameter Symbol Unit min Typ. Max
LVDS Clock Frequency(single) Fdck MHz 44.4 50.4 65.2
H Total Time Htotal clocks 1320 1344 1362
H Active Time Hac clocks 1024 1024 1024
V Total Time Vtotal lines 612 625 638
V Active Time Vac lines 600 600 600
Frame Rate Vsync Hz 55 60 65
Figure 11 Timing Characteristics
________________________________________________________________________
NO.1 Long Teng Road, KunShan City, JiangSu, China Tel:0512-57278888
InfoVision Optoelectronics (Kunshan) Co., LTD Fax:0512-57278900
Page 16 of 29
昆山龙腾光电有限公司
InfoVision Optoelectronics ( Kunshan ) Co.,LTD.
Document Title M101NWT2 R2 Product Information Page No. 17/29
8 Power Consumption
Input power specifications are as follows.
Table 8 Power Consumption
If VTH <V ≤Vmin,then t ≤10ms;when the voltage return to normal our panel must revive
DD d
automatically.
________________________________________________________________________
NO.1 Long Teng Road, KunShan City, JiangSu, China Tel:0512-57278888
InfoVision Optoelectronics (Kunshan) Co., LTD Fax:0512-57278900
Page 17 of 29
昆山龙腾光电有限公司
InfoVision Optoelectronics ( Kunshan ) Co.,LTD.
Document Title M101NWT2 R2 Product Information Page No. 18/29
T6
________________________________________________________________________
NO.1 Long Teng Road, KunShan City, JiangSu, China Tel:0512-57278888
InfoVision Optoelectronics (Kunshan) Co., LTD Fax:0512-57278900
Page 18 of 29
昆山龙腾光电有限公司
InfoVision Optoelectronics ( Kunshan ) Co.,LTD.
Document Title M101NWT2 R2 Product Information Page No. 19/29
10 Mechanical Characteristics
Figure 13 Reference Outline Drawing (Front Side)
________________________________________________________________________
NO.1 Long Teng Road, KunShan City, JiangSu, China Tel:0512-57278888
InfoVision Optoelectronics (Kunshan) Co., LTD Fax:0512-57278900
Page 19 of 29
昆山龙腾光电有限公司
InfoVision Optoelectronics ( Kunshan ) Co.,LTD.
Document Title M101NWT2 R2 Product Information Page No. 20/29
________________________________________________________________________
NO.1 Long Teng Road, KunShan City, JiangSu, China Tel:0512-57278888
InfoVision Optoelectronics (Kunshan) Co., LTD Fax:0512-57278900
Page 20 of 29
昆山龙腾光电有限公司
InfoVision Optoelectronics ( Kunshan ) Co.,LTD.
Document Title M101NWT2 R2 Product Information Page No. 21/29
a b
Bezel opening
Active area
________________________________________________________________________
NO.1 Long Teng Road, KunShan City, JiangSu, China Tel:0512-57278888
InfoVision Optoelectronics (Kunshan) Co., LTD Fax:0512-57278900
Page 21 of 29
昆山龙腾光电有限公司
InfoVision Optoelectronics ( Kunshan ) Co.,LTD.
Document Title M101NWT2 R2 Product Information Page No. 22/29
11 Package Specification
________________________________________________________________________
NO.1 Long Teng Road, KunShan City, JiangSu, China Tel:0512-57278888
InfoVision Optoelectronics (Kunshan) Co., LTD Fax:0512-57278900
Page 22 of 29
昆山龙腾光电有限公司
InfoVision Optoelectronics ( Kunshan ) Co.,LTD.
Document Title M101NWT2 R2 Product Information Page No. 23/29
12 Lot Mark
Module Name
Development Product
Name
23 product code
________________________________________________________________________
NO.1 Long Teng Road, KunShan City, JiangSu, China Tel:0512-57278888
InfoVision Optoelectronics (Kunshan) Co., LTD Fax:0512-57278900
Page 24 of 29
昆山龙腾光电有限公司
InfoVision Optoelectronics ( Kunshan ) Co.,LTD.
Document Title M101NWT2 R2 Product Information Page No. 25/29
13 General Precaution
a) Use Restriction
This product is not authorized for use in life supporting systems, aircraft navigation control
systems, military systems and any other application where performance failure could be
life-threatening or otherwise catastrophic.
b) Handling Precaution
1) Please mount LCD module by using mounting holes arranged in four corners tightly.
2) Do not disassemble or modify the module. It may damage sensitive parts inside LCD
module, and may cause scratches or dust on the display. MTD does not warrant the
module, if customers disassemble or modify the module.
3) If LCD panel is broken and liquid crystal spills out, do not ingest or inhale liquid Crystal,
and do not contact liquid crystal with skin. If liquid crystal contacts mouth or eyes, rinse
out with water immediately. If liquid crystal contacts skin or cloths, wash it off immediately
with alcohol and Rinse thoroughly with water.
4) Disconnect power supply before handling LCD module.
5) Refrain from strong mechanical shock and /or any force to the module.
6) Do not exceed the absolute maximum rating values, such as the supply voltage variation,
input voltage variation, variation in parts’ parameters, environmental temperature; etc
otherwise LCD module may be damaged. It’s recommended employing protection circuit
for power supply.
7) Do not touch, push or rub the polarizer with anything harder than HB pencil lead. Use
fingerstalls of soft gloves in order to keep clean display quality, when Persons handle the
LCD module for incoming inspection or assembly.
8) When the surface is dusty, please wipe gently with absorbent cotton or other soft Material.
When cleaning the adhesives, please use absorbent cotton wetted with a little Petroleum
benzene or other adequate solvent.
9) Wipe off saliva or water drops as soon as possible. If saliva or water drops Contact with
polarizer for a long time, they may causes deformation or color Fading.
10) Protection film must remove very slowly from the surface of LCD module to
Prevent from electrostatic occurrence.
11) Because LCD module uses CMOS-IC on circuit board and TFT-LCD panel, it is Very
weak to electrostatic discharge, Please be careful with electrostatic Discharge .Persons
who handle the module should be grounded through adequate methods.
12) Do not adjust the variable resistor located on the module.
c) Storage Precaution
1) Please do not leave LCD module in the environment of high humidity and high
temperature for a long time.
2) The module shall not be exposed under strong light such as direct sunlight. Otherwise,
Display characteristics may be changed.
3) The module should be stored in a dark place. It is prohibited to apply sunlight or
fluorescent light in storage.
d) Operation Precaution
1) Do not connect or disconnect the module in the "Power On” condition.
2) Power supply should always be turned on/off by 9.0 "Power on/off sequence".
3) Module has high frequency circuits. Sufficient suppression to the electromagnetic
________________________________________________________________________
NO.1 Long Teng Road, KunShan City, JiangSu, China Tel:0512-57278888
InfoVision Optoelectronics (Kunshan) Co., LTD Fax:0512-57278900
Page 25 of 29
昆山龙腾光电有限公司
InfoVision Optoelectronics ( Kunshan ) Co.,LTD.
Document Title M101NWT2 R2 Product Information Page No. 26/29
________________________________________________________________________
NO.1 Long Teng Road, KunShan City, JiangSu, China Tel:0512-57278888
InfoVision Optoelectronics (Kunshan) Co., LTD Fax:0512-57278900
Page 26 of 29
昆山龙腾光电有限公司
InfoVision Optoelectronics ( Kunshan ) Co.,LTD.
Document Title M101NWT2 R2 Product Information Page No. 27/29
________________________________________________________________________
NO.1 Long Teng Road, KunShan City, JiangSu, China Tel:0512-57278888
InfoVision Optoelectronics (Kunshan) Co., LTD Fax:0512-57278900
Page 27 of 29
昆山龙腾光电有限公司
InfoVision Optoelectronics ( Kunshan ) Co.,LTD.
Document Title M101NWT2 R2 Product Information Page No. 28/29
________________________________________________________________________
NO.1 Long Teng Road, KunShan City, JiangSu, China Tel:0512-57278888
InfoVision Optoelectronics (Kunshan) Co., LTD Fax:0512-57278900
Page 28 of 29
昆山龙腾光电有限公司
InfoVision Optoelectronics ( Kunshan ) Co.,LTD.
Document Title M101NWT2 R2 Product Information Page No. 29/29
91 5B Flag 00 00000000 0
92 5C Flag 00 00000000 0
93 5D FE (hex) defines ASCII string FE 11111110 254
94 5E Flag 00 00000000 0
95 5F Manufacture I 49 01001001 73
96 60 Manufacture n 6E 01101110 110
97 61 Manufacture f 66 01100110 102
98 62 Manufacture o 6F 01101111 111
99 63 Manufacture V 56 01010110 86
100 64 Manufacture i 69 01101001 105
101 65 Manufacture s 73 01110011 115
102 66 Manufacture i 69 01101001 105
103 67 Manufacture o 6F 01101111 111
104 68 Manufacture n 6E 01101110 110
105 69 New line character indicates end of ASCII string 0A 00001010 10
106 6A 20 00100000 32
107 6B 20 00100000 32
108 6C Detailed timing/monitor descriptor #4 00 00000000 0
109 6D 00 00000000 0
110 6E 00 00000000 0
111 6F FE (hex) defines ASCII string FE 11111110 254
112 70 Flag 00 00000000 0
113 71 Manufacture P/N 4D 01001101 77
114 72 Manufacture P/N 31 00110001 49
115 73 Manufacture P/N 30 00110000 48
116 74 Manufacture P/N 31 00110001 49
117 75 Manufacture P/N 4E 01001110 78
118 76 Manufacture P/N 57 01010111 87
119 77 Manufacture P/N 54 01010100 84
120 78 Manufacture P/N 32 00110010 50
121 79 Manufacture P/N 20 00100000 32
122 7A Manufacture P/N 52 01010010 82
123 7B Manufacture P/N 32 00110010 50
124 7C New line character indicates end of ASCII string 20 00100000 32
125 7D 0A 00001010 10
126 7E Extension Flag = 00 00 00000000 0
127 7F Checksum 11 00010001 17
________________________________________________________________________
NO.1 Long Teng Road, KunShan City, JiangSu, China Tel:0512-57278888
InfoVision Optoelectronics (Kunshan) Co., LTD Fax:0512-57278900
Page 29 of 29