The document provides instructions for 12 geometric constructions to be completed:
1) Bisect a 100mm line segment.
2) Bisect arcs from circles with center O and radius 50mm. Bisect the arcs until the bisectors meet.
3) Draw line segments AB and BC at 30 degrees and bisect the angle between them.
4) Divide a 100mm line into seven equal parts.
5) Draw a circle with diameter 50mm centered at O and divide it into 12 equal parts.
The document provides instructions for 12 geometric constructions to be completed:
1) Bisect a 100mm line segment.
2) Bisect arcs from circles with center O and radius 50mm. Bisect the arcs until the bisectors meet.
3) Draw line segments AB and BC at 30 degrees and bisect the angle between them.
4) Divide a 100mm line into seven equal parts.
5) Draw a circle with diameter 50mm centered at O and divide it into 12 equal parts.
The document provides instructions for 12 geometric constructions to be completed:
1) Bisect a 100mm line segment.
2) Bisect arcs from circles with center O and radius 50mm. Bisect the arcs until the bisectors meet.
3) Draw line segments AB and BC at 30 degrees and bisect the angle between them.
4) Divide a 100mm line into seven equal parts.
5) Draw a circle with diameter 50mm centered at O and divide it into 12 equal parts.
(AUTONOMOUS) DEPARTMENT OF MECHANICAL ENGINEERING Engineering Graphics S-2: Geometrical construction
1. Draw a line AB with length of 100 mm long and bisect it.
2. With center ‘O’ and radius equal to 50 mm, draw two arcs of any lengths on opposite sides of ‘O’. Bisect the two arcs and produce the bisectors till they meet. 3. Draw two-line segments AB and BC with an angle between them as 30° and bisect the angle between them. 4. Divide a given line of 100 mm into seven equal parts. 5. Draw a 50 mm diameter circle with center as ‘O’ and divide it into 12 equal parts 6. Draw two perpendicular lines AB and BC and trisect the angle between them. 7. Draw an equilateral triangle of side length 100 mm. 8. Construct a square with side length of 100 mm. 9. Draw a regular heptagon of side length 50 mm using general method. 10. Draw a circle with O as center and radius of 60 mm and draw a tangent to the circle through a point P on the circle OP makes 45o with horizontal. 11. Draw a circle with O as center and radius of 60 mm and draw a tangent to the circle through a point P, where OP is 100 mm makes 30o with horizontal. 12. Draw regular pentagon and hexagon with side of 50 mm.