Professional Documents
Culture Documents
by jiangqianqian
This article will tell you how to DIY 3D printer you can't miss it, so please read it carefully
First, assemble the Y-axis timing belt guide wheel. Two 605zz bearings, one M5-25mm screw, one M5 nut, and
one gasket are required.
Step 8: Install the Y-belt-holder Onto the Acrylic Base Plate and Use the Self-locking M3
Nut
Install the slide rail, assemble the X-axis synchronous belt guide wheel bearing, M5 screw front pad 4 M5 washers
Step 20: Apply a Thermistor to the Front of the Hot Bed and Fix the Hot Bed to the Y-axis
Install ex-base
Install the cooling fan, the fan wiring, and the extruder heater wire are connected together.
Switching power supply wiring, yellow blue and brown are 220V ground wire, 220V firewire, zero wire. The two
sets of red and black lines are the 12V output of the switching power supply.
Step 29: Complete All Line Connections Against the RAMPS Wiring Diagram