Professional Documents
Culture Documents
Fullour
Siteservices. By using our services, you agree to our use of cookies. Thank You. Learn more.
Navigation
I understand!
Visitar Sitio
Using the ignition switch, at no point do you actually start the Jeep: Start with the ignition in the OFF
position,
turn the key to ON, OFF, ON, OFF, ON ... stop .. leave the key in the ON position (Complete this
sequence in
under 5 seconds). Once you stop the key in the ON position, the check engine light will stay lit for a
moment.
When the light goes off, get ready to start counting the light flashings.
Once the Check Engine Light has turned off, it will pause in the off position for a second or two, and
then start
to flash, count the flashes. Each OBD code stored will be given to you in a 2 digit sequence. As an
example, code 12
would be FLASH ... <PAUSE>... FLASH FLASH followed by a <LONG PAUSE>, followed by the next
code. Code 55 signals the end of stored OBD codes. You can repeat the key sequence as many
Facebook®
times as needed if you wereTu
unsure of a code. de
configuración VISITAR SITIO
seguridad
*= Check Engine light will not illuminate at all times if this Trouble Code it present.
**= Check Engine light will illuminate during engine operation if this Trouble Code is present.
11*: No crank reference signal detected during cranking. Timing belt skipped one or more teeth; or
intermittent loss of either camshaft or crankshaft position sensor
12*: Battery or computer recently disconnected within the last 50 start cycles). This is a very
common code. Will not trigger a "Check engine light".
Descubre las
nuevas funciones
Visitar sitio
13**: No change in Manifold Absolute Pressure sensor (MAP) from start to run.
17*: Engine stays cold too long. Bad thermostat or temp sensor.
21**: Oxygen sensor input voltage stayed above normal operating range.
23**: Intake air temperature sensor signal above or below acceptable voltage.
27*: One of the Injectors output drivers does not respond properly to control signal.
33*: Air conditioning clutch relay circuit open or shorted. If your Jeep doesn't have AC you will
always get this code. Will not trigger a "Check engine light".
34*: Speed control vacuum or vent solenoid circuits open or shorted. Switch is above or below
acceptable voltage.
37: Relationship between engine speed and vehicle speed indicates no torque converter clutch
engagement. An open or shorted condition detected in the torque converter part throttle unlock
solenoid control circuit. Incorrect input state detected for the Park/Neutral switch. Auto only.
42*: An open or shorted condition detected in the auto shutdown relay circuit. An open condition
detected in the ASD relay output circuit. An open or shorted condition detected in the fuel pump
relay control circuit. An open circuit between PCM and fuel gauge sending unit. Circuit shorted to
voltage between PCM and fuel gauge sending unit. No movement of fuel level sender detected.
43: Peak primary circuit current not achieved with maximum dwell time. Misfire detected in one or
more cylinders 1 thru 6. (4 and 6 cyls).
44*: Open or shorted condition in the engine coolant temp sensor circuit or a problem exists in the
PCMs battery temp voltage circuit.
47**: Battery voltage sense input below target charging during engine operation. Also, no significant
change detected in battery voltage during active test of generator output circuit.
51**: A rich air/fuel mixture has been indicated by an abnormally rich correction factor.
52**: A rich air/fuel mixture has been indicated by an abnormally rich correction factor.
****This information was gotten from the Chrysler FSM, Quadratec & various posts on
WranglerBoard forum.
So, I can’t and will not promise or guarantee it’s complete accuracy. Diagnosing trouble codes and
changing parts can still be like chasing a needle in a haystack. But, it’s always a good place to start.
Top of current page
JeepofYJ
Jeep and Jeep Wrangler are registered trademarks SoftGroup
Chrysler Top LLC. © Copyright Chrysler Group LLC. All rights reserved
Jeep YJ
FixJeeps.com, its owners and affiliates are in no way affiliated Fuel
with Chrysler Goup LLC. FixJeeps.com and Power Addicts YouTube are Amazon
partners. Any purchases made with Amazon through any of my links on FixJeeps or Power Addicts, I get a small affiliate commission to no extra
Jeep
cost YJThanks
to you. Electrical
for your support :-)
Jeep fixin'
Fiberglass Repair Article
Jeep Mods
Jeep rims swap
Tools and stuff
Free Printable goodies
Advertising Disclaimer
Fun Times
Printable Coupons
Printable Coupons
Fun trips in a Jeep
About the site & I
Jeep Pride
Social Media Links