Professional Documents
Culture Documents
Purpose To describe how to replace the shutter assembly in the ITM hood.
Scope HP Indigo 7000 Series Digital Presses, HP Indigo WS6000 Series Digital Presses,
HP Indigo W7200 Series Digital Presses.
Revision number 00
1 Overview ......................................................................................................................... 1
Prerequisites ............................................................................................................................ 1
Estimated installation time ......................................................................................................... 1
Special skills ............................................................................................................................ 1
Special jigs and tools ............................................................................................................... 1
Parts list .................................................................................................................................. 1
2 Procedures ....................................................................................................................... 2
Replacing the shutter in the ITM hood ......................................................................................... 2
CA393-07320 Rev 00 v
Replacing the shutter in the ITM hood
1 Overview
This document describes how to replace the shutter assembly in the ITM hood (external heating hood).
Prerequisites
N/A
Special skills
None
Parts list
Spare parts
CT345-43510 E/H Shutter assy
2 Procedures
NOTE: If the press has the dripping reduction kit installed, remove the heating hose from the ITM
hood before removing the hood assembly.
4. Place the ITM hood on a sturdy work surface, and remove the 2 M4 Allen screws from each side
of the end bracket of the hood.
6. Slide the shutter assembly out, push the 2 guide rollers back to allow the shutter to pass.
Figure 2-2 Guide wheel
1 Guide roller
8. Return the end bracket and secure it with the 4 M4 Allen screws that you removed earlier.
9. Check to see that the shutter opens and closes smoothly.
10. Return the ITM hood to the press. Reconnect the heating hose (if installed).
11. Return the external heating lamps to their place.
Revision history
Version/Revision Description
R&D Engineer
Confidentiality notice
The information contained in this document is accurate at the date of release. Check CE Suitcase for the most recent version of this document.
This document contains valuable trade secrets and confidential information of Hewlett-Packard Company. Nothing herein may be copied, reproduced or
distributed in any form or medium, or disclosed to any third party in any manner, without prior written authorization of Hewlett-Packard Company. The
copyright notice, which appears in this document, is purely precautionary and shall not be deemed to constitute publication or intent to publish, in whole or in
part.