Document No
POLITEKNIK PENERBANGAN
SURABAYA TTPMIFR-03
FORMS DOCUMENT
POLITEKNIK PENERBANGAN SURABAYA
AMTO 147D-10
TASK CARD
Course Title : Vb Te a
Practical Subject: | SS*
Trainee Name pM Res. Baaare
Trainee No. nN
[Using applicable reference data ifstruction, understand the mentioned of reference data.
@ Dipindai dengan CamScannerDocument No
POLITEKNIK PENERBANGAN
SURABAYA TTPM/FR-03
FORMS DOCUMENT
AMTO QC-18-1 (09-19)
Task Card Guidance :
The following Task card Standard Codes are found next to each task element and question on the Task Card
Checklist to indicate the mode of evaluation acceptable for that element:
P=Perform D=Discuss
'S=Simulate 0 = Observe
In order forthe trainee to successfully pass the Task Cand Checklist and be Task Qualified:
+ “Perform” items (P) must be performed.
+ “Simulate” items (S) must be simulated and may be performed if conditions permit.
+ “Discuss” items (D) must be discussed and may be simulated or performed if conditions permit. « “Observe”
items (0) must be observed and may be discussed, simulated, or performed if
conditions permit.
‘AMTO QC-18-1 (09-19)
TASK
POLITEKNIK PENERBANGAN SURABAYA CARD
@ Dipindai dengan CamScannerDocument No
POLITEKNIK PENERBANGAN
SURABAYA TTPMIFR-03
FORMS DOCUMENT
Task Name 7 RS Task No, : STPUC305-02 Laboratory = \aSeeomenw
Trainee Name: 4. KU. NIT 2 Boyrr013 Date Practical
‘Terminal Objective :
No. Enabling Objectives
1 | Using applicable reference data instruction, understand the mentioned of reference data.
2 | Using applicable reference data, understand appliance and tools are to open Airspeed Indicator
3° | Using applicable tools/equipment to open Airspeed Indicator
AMTO QC-18-1 (09-19)
TASK
- POLITEKNIK PENERBANGAN SURABAYA CARD
T jective
@ Dipindai dengan CamScannerDocument No
POLITEKNIK PENERBANGAN
SURABAYA TTPMIFR-03
FORMS DOCUMENT
Performance Guide:
| No. Leaning Step / Trainee Prompt ame aa
|
| First Time, check tools and prepared required tools
1 1. Screw Philips phi 1 Pp
2.¢ne
3.lamp
z Prepare the Airspeed indicator A G
3 Make sure get all screw from Airspeed Indicator cee A
Prepare Screw Philips phi
| 4 A
| Note : When you open that screw you must be carefully
; 5 ‘Open screw Airspeed Indicator from front display aA AL
t oF
6 Open 2 connector from pitot and static aA /.
| }
I
7 Open screw from airspeed Indicator 4
i i nf
8 Open this airspeed Indicator be carefully A
9 Cleaning aneroid and gear *
10 Install this airspeed Indicator be carefully 4 i
|
[oan Install screw from airspeed Indicator aA (
{a2 Install connector a /
| 23 Install Airspeed indicator from display A B
4 lean up al of tools * ir
@ Dipindai dengan CamScannerDocument No
POLITEKNIK PENERBANGAN
SURABAYA TTPMI/FR-03
FORMS DOCUMENT
AMTO QC-18-2 (09-19)
@ Dipindai dengan CamScanner