Professional Documents
Culture Documents
Eggbeater 1 & 2, Candy 1 & 2, Mallet 2 & 3, Stamp 2 & 3 (V1), Doubleshot 1 - 2010-current
Tools
Supplies
Lin t -f r ee S hop R a g
Dr y C ha in Oil
G r ea s e (M a r in e G r a de is Bes t )
pg 1
Technical Document Slotted Endcap pedal Maintenance (every 50-75 hours of ride time)
Eggbeater 1 & 2, Candy 1 & 2, Mallet 2 & 3, Stamp 2 & 3 (V1), Doubleshot 1 - 2010-current
4. Clean and inspect All Parts 5. Lubricate Wing Assembly (Clipless Pedals) 6. Work in Lubricant (Clipless Pedals)
Using a rag or paper towel, wipe away the old grease from the seal, spindle and from inside the pedal For flat pedals, skip to step #7. For clipless pedal, Place the pedal on a table and using the large flat
body. Check to make sure all parts are in ridable condition, including the internals (outer and inner add 1-2 drops of dry chain oil to the interface blade screwdriver, compress the wing assembly
bearings) between the spring arms and wings. several times to work the oil into the interface.
Wipe away any excess oil
pg 2
Technical Document Slotted Endcap pedal Maintenance (every 50-75 hours of ride time)
Eggbeater 1 & 2, Candy 1 & 2, Mallet 2 & 3, Stamp 2 & 3 (V1), Doubleshot 1 - 2010-current
7. Install outer Seal if removed 8. Grease Spindle 9. Grease Pedal Internals 10. Install Pedal Body
If outer seal was removed, reinstall (flat side facing Apply grease generously to the spindle bushing or Add fresh grease to the inside of the pedal body. Slide pedal body assembly back onto the spindle.
in) just past the polished bushing/bearing surface bearing surface and on all areas except the Be careful not to push the cartridge bearing out of
on the spindle. threaded end. the body.
11. Install Spindle Nut 12. Grease inside of Endcap and Install 13. Check Outer Seal Position
Install spindle nut with 8mm socket and tighten to Add a small amount of grease to the inside of the Check the outer seal and confirm it is flush with
4Nm. Pedal body may still feel loose on spindle endcap and install with the large flat screwdriver the pedal body. It may be necessary to press the
at this stage. (3/8” or 10mm tip). Tighten to 2.5Nm. inner seal in deeper using the end of a bent zip tie.
pg 3