Professional Documents
Culture Documents
Cameron Hang Off Capacity
Cameron Hang Off Capacity
Hang-off weights are estimated capacities with hardened top corners of the hang-off rams. This en-
ables the rams to dig into the tool joint and provide superior hang-off capacity while still meeting
NACE requirements.
For variable bore rams (VBR’s) and FLEXPACKER rams hang-off data, refer to Cameron Engineering
Bulletin 859D.
Hang-Off Weights
(See Cameron Engineering Bulletin 636)
The DS shearing blind ram can cut large diameter tubulars or multiple tubing strings regardless of
their orientation to the centerline of the ram. A blade seal between the upper and lower faces elimi-
nates the need for moving pipe after shearing.
• Large frontal area on the blade face seal reduces pressure on the rubber and increases service
life.
• Cameron SBRs can cut pipe numerous times without damage to the cutting edge.
• The single-piece body incorporates an integrated cutting edge.
• TM
CAMRAM top seals are standard for all U BOP shearing blind rams through 18-3/4”.
• For U and UII BOPs through 18-3/4”, part numbers beginning with 644XXX indicate the
CAMRAM lipped-plate design. Other part numbers may use standard elastomer material and
reinforced plates. Verify this with your Cameron representative.
• H2S SBRs are available for critical service applications and include a blade material of
hardened high alloy suitable for H2S service.
TC1001
Table of Contents 47 © 2002 Cooper Cameron, Cameron Division