Professional Documents
Culture Documents
Worldwide
Network
Sleveless
Patented design for tapered extension of
stuffing box.
Easy repair
Wear parts can be replaced without
removing the gland.
the World.
2
SEALTEK
2 PRE-ASSEMBLED HALVES
Style 688 has been designed with the goal of creating a split
WHY
A SLEEVELESS
mechanical seal that could represent an improvement over the
current state of technology, eliminating the typical issues of the
SEAL
split seals on the market.
A Sealtek patented design
The real innovation that Sealtek has representing a massive innovation
brought with Style 688 is the departure over the previous generation of
from the typical split seal design, which
cartridge mechanical seals.
usually involves very narrow dead ends
near the seal faces and a very complicated The seal chamber is empty: no bulky cartrirdge
replacement process for worn parts, in fa- will fill the stuffing box.
vor of an open conical seal chamber and a
Conical extension of the stuffing box, granting
hassle-free refurbishment procedure, typi-
the advantages of a tapered bore design
cal of Sealtek Sleeveless line.
in terms of self-cooling and self-cleaning
Due to its design features, Style 688 can be properties, resulting in a superior MTBF.
pressure-tested at factory and be shipped
No sleeve required to keep the cartridge
as fully assembled seal, which is eventually
elements together. The lack of sleeve
opened only for the seal installation. This
dramatically increases the misalignment
EASY prevents any dust or dirt from settling on
the seal faces, and completely eliminates
tolerance, and greatly reduces the final price.
Silicon carbide coated in amorphous Combines the lower cost and the higher
diamond features: reliability of a single piece gland with
the practicality of the split wear parts.
Considerably lower heat generation
and power absorption; Install like a standard seal, refurbish
like a split seal.
Virtually no wear, unmatched dry
Dead end design: no internal circulation, flush
running capacity and superior perfor- Easy installation and inexpensive
often necessary, solid particles build-up.
mances in low lubrication applications. repair kits, the best of the both worlds.
3
1
2
6
3
4
SEALTEK
SIZES - METRIC SYSTEM
5
SIZES - IMPERIAL UNITS
6
SEALTEK
INSTRUCTIONS OF USE 1
Open the seal by removing all the shoulder screws.
Lube the (A) shaft o-ring. BE CAREFUL NOT TO PUT ANY
LUBRICANT ON THE O-RING’S ENDS.
Place the two halves of the seal around the shaft and tighten
2 the (B) four gland screws alternately, in order to make the
halves come together parallel. Do not tighten over 10 Nm
(90 in-lbs).
7
5 Tighten the (C) two outer collar screws at a torque
of about 5,5 Nm (50 in-lbs).
Gradually untighten the (D) four centering clips
screws until the slots for the inner collar screws
are accessible.
DO NOT COMPLETELY REMOVE THE CENTERING
CLIPS
SEALTEK srl
35010 VIGONZA (PD) Italy - Via Germania, 31
Tel. +39 0498932178 - 8930536
Fax +39 0498931723
www.sealtek.com - e-mail: info@sealtek.com