Professional Documents
Culture Documents
174 15/02/2024
Chassis ID Path
JPCT 29755 364/Diagnostics//IECU-B15BD, Brake switch
Model Identity
UD-MDE 138283727
Copyright to this documentation belongs to the Volvo Group. No reproduction, copying, change, amendment or other similar disposal is entitled without prior written consent by
the Volvo Group
The information contained herein is current at the time of its original distribution, but is subject to change. The reader is advised that printed copies are uncontrolled.
1/4
IMPACT 4.07.174 15/02/2024
Basic check:
Connector check:
Check connector A149 Check that the connectors are properly connected and locked into Damaged connector
(PB), S48A, XC202. position may result in short
Disconnect and check the component connector. or open circuit.
Inspect pins and terminals for oxidations or corrosion.
Ensure that the pins and terminals are locked into the connectors
and that they are not pushed back out of the sockets.
Check the pins and terminal are not damaged (which can cause
poor connection).
Carefully insert the correct test pin from special tool 9990008 and
verify that pin connections are in good condition.
Resistance measurement
2/4
IMPACT 4.07.174 15/02/2024
Copyright to this documentation belongs to the Volvo Group. No reproduction, copying, change, amendment or other similar disposal is entitled without prior written consent by
the Volvo Group
The information contained herein is current at the time of its original distribution, but is subject to change. The reader is advised that printed copies are uncontrolled.
3/4
IMPACT 4.07.174 15/02/2024
Verification:
Purpose: Conditions: Evaluation:
Verification. Ignition key in OFF position. If the fault code is not set during the
Wait 5 seconds. verification the fault may be corrected.
Ignition key in ON position. The status of the diagnostic process in the
Wait 1 minute(s) and continue verification control unit can not be tested without
by reading out fault codes. communication with the vehicle.
The fault code may appear later when the
vehicle has been returned to service.
Copyright to this documentation belongs to the Volvo Group. No reproduction, copying, change, amendment or other similar disposal is entitled without prior written consent by
the Volvo Group
The information contained herein is current at the time of its original distribution, but is subject to change. The reader is advised that printed copies are uncontrolled.
4/4