Professional Documents
Culture Documents
Test 4
Test 4
This section describes how to install the CyberArk Digital Vault in a Primary-DR configuration.
1. Verify that you've implemented all the prerequisites for the Vault. See the following topics:
Primary-DR Vault installation requirements
Primary-DR pre-install Tasks
2. Install the Primary Vault To install the Primary Vault in a single-node site, see Install the Primary Vault
If you are setting up a cluster environment, see Install the Primary Vault Site in a
Cluster Environment.
3. Install the Disaster Recovery Vault To install the DR Vault in a single-node site, see Install the DR Vault.
If you are setting up a cluster environment, see Install the DR Vault Site in a
Cluster Environment.
6 Perform post-install tasks on the Vault servers After you install the Vault servers, there are several tasks that need to be done
before installing the components.
To perform the post-install tasks, see Primary-DR post-install tasks.
7. Install the components in the environment, which may include one Some components can be installed against the Primary Vault in the environment.
or more of the following: To install the system components, see:
PVWA Install PVWA
CPM Install CPM
PSM Install PSM
PSM for SSH Install PSM for SSH
other components
In this section: