Professional Documents
Culture Documents
:-
1 2 3 4 5 7 8 9 10 11 12 13 14 15
Permanent Population:-
Sethi
1 Sethi Dharkot 054612 NC 619 24 685 27 808 32 904 36 30
Dharkot
Institutional requirements :-
High School Sethi Dharkot @ 55 lpcd for 20% of
2 0 0 25 0 30 0 33
population 125 total strength
Primary School Sethi Dharkot @ 55 lpcd for 20% of
3 0 0 17 0 20 0 22
population 84 total strength
Junior School Sethi Dharkot @ 55 lpcd for 20% of
4 0 0 31 0 37 0 41
population 157 total strength
Cattle requirements :-
Sethi Dharkot Cattle @ 55 lpcd for 55% of
5 0 0 187 0 221 0 247
population 340 total strength
Zone I 619 24 945 27 1116 32 1247 36 30
Permanent Population:-
Sethi
1 Chandpur 054612 NC 30 24 33 27 39 32 44 36 10
Dharkot
Sethi
2 Udhina 054612 NC 61 24 67 27 79 32 88 36 17
Dharkot
Sethi
3 Khola 054612 NC 25 24 28 27 33 32 37 36 10
Dharkot
Cattle requirements :-
@ 55 lpcd for 55% of
4 Chandpur Cattle population 10 0 0 6 0 7 0 8
total strength
Page Nos. :-
Sethi
1 Lehra 054612 NC 60 24 66 27 78 32 87 36 10
Dharkot
Cattle requirements :-
@ 55 lpcd for 55% of
2 Lehra Cattle population 100 0 0 55 0 65 0 73
total strength
Zone III 60 24 121 27 143 32 160 36 10
Permanent Population:-
Sethi
1 Khadkia 054612 NC 42 24 46 27 54 32 61 36 7
Dharkot
Cattle requirements :-
@ 55 lpcd for 55% of
2 Khadkia Cattle population 100 0 0 55 0 65 0 73
total strength
Zone IV 42 24 101 27 119 32 134 36 7
Permanent Population:-
Sethi
1 Kota dhuria 054612 NC 61 24 67 27 79 32 88 36 25
Dharkot
Cattle requirements :-
Kota dhuria Cattle population @ 55 lpcd for 55% of
2 0 0 110 0 130 0 145
20 total strength
Zone V 61 24 177 27 209 32 233 36 25
Total (Zone I To V) 898 168 1478 189 1745 224 1951 252 109
In view of Government of india that house connection shall be provided to each and every rural house hold till March 2024,
the rate of water supply has been adopted as 55 lpcd as per JJM Guide Line circulated by Govt of India in February 2020 . In
additional to this, 15 % over rate of water supply has been taken for unaccounted of water as per latest design criteria.
2. DESIGN CRITERIA -
The design criteria adopted in this scheme is as per the circular of Chief Engineer, (PPRD), Uttar
Pradesh Jal Nigam Lucknow , vide his office letter No. 267/PPRD- Design Criteria Dated 25.07.2002 and circulated by Chief
Engineer (U), Uttarakhand Peyjal Nigam Dehradun vide his office letter No.37/ Design Criteria dated 14.02 2003. and also the
latest NRDWP as well as JJM Guide line and subsequent instructions issued by the departmental higher authorities time to time
have incorporated to fram this estimate.
4. WATER REQUIREMENT:-
Stage wise total water requirement of Scheme are calculated as tabulated below -
6 SOURCE OF WATER-
One Nos. of Old Source of water namely as Dharikot gadhera,Nigunia ,Masao, Niguni and Kota
Dhuria Gadhera are proposed as water sources of the water supply. As per local enquiry these water sources are
parranial and undi. sputed to be tapped at proposed tapping points . It is also inquired that no other water supply scheme
has been made or proposed upto two kms distance in down stream as well as up stream from the propoesd tapping point
of the sellected water sources for this water supply scheme. Lean period discharge of proposed water sources have
been recorded. Source wise recorded discharge, name of officials who measured the disharge and safe tapable quantity
of recorded discharge are given as tabulated below -
Source Discharge
measurement
Adopted
Required
Tapable
discharge
1 2 3 4 5 6 7 8 9 10
Dharikot Gadhera Gadhera Rajeev Kumar (J.E) 150
1 I Dharikot Gadhera Gadhera Rajeev Kumar (J.E) 54.78
Dharikot Gadhera Gadhera Rajeev Kumar (J.E)
Nigunia Gadhera Spring Rajeev Kumar (J.E) 15
2 II 7.78
Page Nos. :-
It is proposed to disinfect the water before supplying in the distribution system by chlorinating. Bucket type gravity feed
bleaching powder solution doser of 25 liters capacity is proposed to be installed for chlorinating. It is proposed to
administer a dose of 0.5 ppm of chlorine so that 0.20 ppm residual chlorine is available at the farthest end of the
distribution system. The requirement of bleaching powder is calculated below, assuming that 25%chlorine will be
available in the bleaching powder. Annual average production of water has been taken as 75% of annual requirement.
For "Q" KL per day requirement of water (as shown in water demand para ) bleaching powder requirement will be
= (Q*365*0.75*0.5*100) /(1000*25 )
= (0.5475*Q ) Kg. Per year.
The total quantity of bleaching powder has been tabulated below.
Daily Yearly Quantity of
requireme average bleaching
Quantity of bleaching powder Say
S.I Year Population nt of water requireme powder per
per year (Kg. /year) (Kg. /year)
Q in nt of water day (Kg.
KL./day Q in KL. /day)
1 2 3 4 5 6 7 8
2023 1478 93.48 25608.64 0.19 51.18 52.0
1
2053 1951 123.41 33804.09 0.25 67.57 68.0