Professional Documents
Culture Documents
OK
OK
Lubricating oil temperature is below Install an oil pan heater, or drain the oil and
specification fill the system with warm oil.
OK
Change the oil and filters. Refer to Procedure
007-013 in Section 7 (/qs3/pubsys2/xml/en
Lubricating oil does not meet specifications
/procedures/57/57-007-013-tr.html) . Use the
for operating conditions
oil type recommended in Section V of the
operation and maintenance manual.
OK
Check the crankshaft for ease of rotation.
Refer to Procedure 001-016 in Section 1
Crankshaft rotation is impaired
(/qs3/pubsys2/xml/en/procedures
/57/57-001-016-tr.html) .
OK
1 of 2 29/05/2023, 14:00
Engine Will Not Crank or Cranks Slowly (Air Starter) https://quickserve.cummins.com/qs3/pubsys2/xml/en/manual/4021539/...
OK
Remove the starting motor and inspect the
gear. Refer to Procedure 013-020 in Section
Starting motor pinion or ring gear is damaged 13 (/qs3/pubsys2/xml/en/procedures
/57/57-013-020.html) and the equipment
manufacturer service information.
OK
Remove the injectors and rotate the
crankshaft. Look for the source of fluid in the
cylinder. Refer to Procedure 006-026 in
Hydraulic lock in a cylinder Section 6 (/qs3/pubsys2/xml/en/procedures
/57/57-006-026-tr.html) and Procedure
001-016 in Section 1 (/qs3/pubsys2/xml/en
/procedures/57/57-001-016-tr.html) .
OK
Analyze the oil and inspect the filters to
locate an area of probable damage. Refer to
Internal engine damage Procedure 007-083 in Section 7
(/qs3/pubsys2/xml/en/procedures
/99/99-007-083.html) .
2 of 2 29/05/2023, 14:00