Professional Documents
Culture Documents
our SE chargers do not come with a garage door opener including the wiring harnesses to
activate it, and my Martin garage door opener clip has made some grooves in my sun visor, and
that irritates me!!!
This im age has be e n re size d. C lick this bar to vie w the full im age . The original im age is size d 1189x 793.
1- First of all, you have to buy the overhead console that comes with a Garage Door opener,
reading lights and WITHOUT sunroof controls
This im age has be e n re size d. C lick this bar to vie w the full im age . The original im age is size d 1177x 888.
(Mopar Part#1RG01DX9AG)
2- Disconnect your car battery first to prevent any short during installation, Remove the old
overhead console by a trimming tool ( it may require a little force to pull it down by your
fingers)
This im age has be e n re size d. C lick this bar to vie w the full im age . The original im age is size d 1111x 825.
3- disconnect the plug and replace the old overhead console with the new one, clip it back
This im age has be e n re size d. C lick this bar to vie w the full im age . The original im age is size d 1175x 888.
This im age has be e n re size d. C lick this bar to vie w the full im age . The original im age is size d 1187x 872.
4- Do not rush pressing the buttons, it wont work ..... yet
This im age has be e n re size d. C lick this bar to vie w the full im age . The original im age is size d 1141x 864.
5- remove the passenger side Pillar to reveal the wiring harness of the overhead
This im age has be e n re size d. C lick this bar to vie w the full im age . The original im age is size d 1184x 892.
6- Mind a RED colored clip securing the push-pin ..... pull it out gently ( mind that it doesnt
come out, just un-secure it), then disconnect the plug
This im age has be e n re size d. C lick this bar to vie w the full im age . The original im age is size d 1177x 688.
7- The wires we are looking for are #8 (Power) & #11 (Ground)
This im age has be e n re size d. C lick this bar to vie w the full im age . The original im age is size d 1180x 880.
8- Since they do not have any connection to the main PCM, we will have to feed them some
power from an alternative source
This im age has be e n re size d. C lick this bar to vie w the full im age . The original im age is size d 1141x 821.
9- and that will be the Reading lights feeders which provide constant power to the overhead
(Yellow/Blue = Power) (Black/Green = Ground), so cut the UGDO wires from the plug
This im age has be e n re size d. C lick this bar to vie w the full im age . The original im age is size d 1068x 801.
10- strip the Reading Lights wires to connect the UGDO wires to them
This im age has be e n re size d. C lick this bar to vie w the full im age . The original im age is size d 980x 848.
11- Connect the ( Black + Black/Green) and ( Grey + Yellow/Blue )
This im age has be e n re size d. C lick this bar to vie w the full im age . The original im age is size d 1000x 889.
12- tape the wires well with an electrical tape and plug the harness and secure it , then install
the passenger pillar
connect your battery and follow the procedure in the Video here
This im age has be e n re size d. C lick this bar to vie w the full im age . The original im age is size d 1128x 883.
Note:
this procedure will allow you to obtain an OEM Universal Garage Door Opener as a stand alone
device, it will not synchronize with the EVIC in your vehicle like the ones which come equipped
already by the manufacturer
Cheers