You are on page 1of 16

Adding OEM Hands Free Bluetooth - SE Trim Successful

Greetings everyone

Ok. So I had the SE trim which came without a Bluetooth, I went to the accessory add-on which is
offered by mopar for about 300$ ( Mopar Part#82213152 )

Installed it, but really hated it immediately after installing….

it has an external microphone that you have to stick on the overhead console, external VR button
that you have to place somewhere beside the A/C panel, It disables your Aux input jack; there is no
integration with your screen, so you control everything from pairing your phone to dial numbers by
using only the limited voice commands, it looked totally unrelated to my car, removed it 2 days later

I wanted to go to full OEM upgrade….

So I searched about the connections and parts and I found out that I need these items ….

1- Steering wheel switches with Voice command:


(Mopar Part#56046255AD)

2- Then the rearview Mirror with Microphone:


(Mopar Part#57010495AB)

This im age has be e n re size d. C lick this bar to vie w the full im age . The original im age is size d 1172x 857.
3- Wiring Jumper to connect the Mirror to the Bluetooth module and electricity
(Mopar Part#68084162AC)

4- the last item is the Bluetooth Module:


(Mopar part#68158126AC (RSQ)

This im age has be e n re size d. C lick this bar to vie w the full im age . The original im age is size d 1169x 887.
or
(Mopar part#05091072AK (RSP)

5- The dealer has to add this sales code (RSQ or RSP) programming to your PCM
RSP : United States Voice Commands (Includes Navigation Instruction and traffic Info)
or
RSQ : International Voice Commands (Just Phone Dialing and radio channels Commands)
and
GN5 : To enable the rear view mirror auto dimming functions

I had a visit and discussion with a Chrysler dealer technician who was very cooperative and added
the codes for me in advance ....

So I bought the items, and installed them following these steps


1- Disconnect your battery (-) first then (+)

2- The driving wheel switches needs torx driver#25 , you will find a tiny screw behind the wheel,
untighten it then pull the switch panel out, in the inside you will find that the switch is fixed with 3
torx screws#15, change your switches

This im age has be e n re size d. C lick this bar to vie w the full im age . The original im age is size d 1600x 1200.
3- The Bluetooth module is located behind the driver’s knee blocker, you have to have a trim tool to
remove the left panel against the driver’s door so you can reach 2 Philips screws

This im age has be e n re size d. C lick this bar to vie w the full im age . The original im age is size d 2048x 1536.
This im age has be e n re size d. C lick this bar to vie w the full im age . The original im age is size d 1188x 888.
4- Remove them, then use the trim tool to remove the knee blocker forward towards the seat

This im age has be e n re size d. C lick this bar to vie w the full im age . The original im age is size d 1192x 853.
5- The module connection and place is above the parking brake to the left side

This im age has be e n re size d. C lick this bar to vie w the full im age . The original im age is size d 1191x 888.
6- Connect your module and fix it against the plate with 2 screws (they didn't come with any, so I
had to match the screw hole with some from my inventory)

This im age has be e n re size d. C lick this bar to vie w the full im age . The original im age is size d 1183x 888.
7- The third part is the mirror, when removing the mirror, grab the mirror base and rotate anti-clock
wise to remove it, (PLEASE MIND THAT YOUR ROTATION SHALL BE 90* degrees against the
windshield glass to prevent damaging the glass) I almost cracked my glass because i was twisting
with slant angle, so be careful

8- The 4th Part is the microphone wiring harness, remove the driver’s side dash which you will find a
stand-by wiring connection that your harness will be connected to
This im age has be e n re size d. C lick this bar to vie w the full im age . The original im age is size d 1196x 796.

9- Then follow the windshield glass border going up, loosen your sun shade bolts so you can insert
the wire above the roof until you reach the mirror
10- Connect your battery (+) first then (-)

The screen started without the phone icon the first time with the blue theme,

This im age has be e n re size d. C lick this bar to vie w the full im age . The original im age is size d 1168x 868.

the second time I started the car the red theme was back again and the phone icon appeared, and
when i touched it, it requested me to pair a phone

This im age has be e n re size d. C lick this bar to vie w the full im age . The original im age is size d 1048x 795.
This im age has be e n re size d. C lick this bar to vie w the full im age . The original im age is size d 1127x 869.
This im age has be e n re size d. C lick this bar to vie w the full im age . The original im age is size d 1112x 848.
This im age has be e n re size d. C lick this bar to vie w the full im age . The original im age is size d 1132x 849.
tested everything and it worked fine, the VR button tells me to say the FM channel I want to hear,
the phone button tells me the phone commands, music streaming is AMAZING and very clear

This im age has be e n re size d. C lick this bar to vie w the full im age . The original im age is size d 1096x 872.
I loved it, it defiantly worth every penny

Big Note: ( My Radio was originally an upgrade from 4.3" without Auto climate, I still have issues
with the Temp Indicators (Follow my work here), This upgrade is applicable even for those who still
have the 4.3", the only drawback is the tiny screen but streaming music and phone dialing is fully
functional - as per the Chrysler Dealer technician)

Good Luck

You might also like