You are on page 1of 2

Models EAH, EC, E 3 Door

Quick Setup
MODEL “E” REAR VIEW

Instructions POWER SWITCH

DELIMER SWITCH
WARNING: Electrical and plumbing connections
need to be made by a licensed service person
and comply with all Federal, State and Local HARD WIRE
POWER SUPPLY
Health, Electrical, Plumbing and Safety codes.

2 1/2" WATER
INLET

AUTO START
SWITCH

TUBE
3 STIFFENER
STEP

1 3 CHEMICAL
TUBING

8"
WALL
DRAIN FLOOR DRAIN

Connect a 2" drain pipe (not supplied)


from scrap accumulator to floor or

WHITE

BLUE
RED
wall drain.

STEP

2 1 2" DRAIN
OUTLET

STEP

3 RED WHITE BLUE

Connect dishmachine to hot water source


( m i n i mum 1 2 0 - 1 4 0 t emp e r a t u r e
required).
NOTE: The water inlet assembly
ships inside the machine. Installer Insert tube stiffener with chemical tubing
must attach the assembly before into each corresponding chemical
connecting water source. dispensers.
PN: 10130.23 07-2021
MODEL "E" FRONT VIEW
Models EAH, EC,
E 3 Door
Quick Setup
SANI/DETERGENT
SWITCH

Instructions
000000

RINSE SWITCH

WARNING: Electrical and CYCLE LIGHT


plumbing connections need to
be made by a licensed service
PERISTALTIC
person and comply with all FILL/START
Federal, State and Local
PUMP
SWITCH 5
Health, Electrical, Plumbing
and Safety codes.

DOOR HANDLE 6
THERMOMETER NEEDS TO
BE INSTALLED:
The Models E-AH and C are
Shipped from CMA without
thermometer being installed. To
prevent leaking, the installation
Team will need to install it on the
dishwasher using TEFLON TAPE.
So the thermometer for this unit is
not misplaced during shipment,
please find thermometer shipped
inside the dishwasher, zip-tied
to the dishrack.
POLY PRO SCRAP
TM

ACCUMULATOR

LEVELING
4 LEGS

STEP STEP STEP


START 000000

4 5 000000
6
FILL

Level dishmachine by adjusting leveling Press and hold the Fill/Start Switch until Open dishmachine doors completely.
legs. Dishmachine must be level front and the water level is approximately 1/2" to 3/4" Closing the doors will automatically activate
back to ensure proper performance. below the overflow hole in the PVC the machine.
standpipe.
an Ali Group Company
07-2021

The Spirit of Excellence

You might also like