Professional Documents
Culture Documents
MECHANICAL
12 Flywheel (MTX), Drive plate (ATX) (See 01–10–10
Drive Plate (ATX), Flywheel (MTX) Disassembly
Note)
13 End plate (MTX)
14 Rear oil seal
B3E0110E051
CYLINDER BLOCK (II) DISASSEMBLY
B3E011002000207
Caution
• Placing the crankshaft on a disassembly bench will cause the drive gear to contact the
disassembly bench because the crankshaft drive gear is larger than the counterweight. This could
result in the drive gear being scratched or damaged which could become a source of noise.
Therefore, set wood blocks or similar object on the both sides of the crankshaft or place a thick
clean rag under the drive gear so that the drive gear does not contact the disassembly bench
directly.
1. Disassemble in the order indicated in the table.
12
6
11 10
4 9
L3,L3 (with variable valve
3 timing mechanism)
2 8
13
7
B3E0110E066