You are on page 1of 94

Field Pro II

1000
OPERATOR’S MANUAL

A DIVISION OF RHS, INC.

2005 West Oregon Street • P.O. Box 394


Hiawatha, Kansas 66434 USA
Phone (785) 742-2949 • FAX (785) 742-7174
Call Toll Free 1-800-247-3808
www.rhs-inc.com

Effective June 2004


Last Edit June 2004 DOM-BW010 Revision F
GENERAL INFORMATION
Congratulations on your purchase of a BESTWAY sprayer. We at RHS wish to thank you for

your patronage and appreciate your confidence in BESTWAY equipment. Your BESTWAY Field-

Pro II 1000 sprayer has been carefully designed and ruggedly built to provide many years of

dependable service in return for your investment.

This manual has been prepared to assist you in the operation and maintenance of your Field-

Pro II 1000 sprayer and to provide the necessary part numbers to keep it in near original condition.

Sprayer Serial Number___________________________

Boom Serial Number____________________________

Foam Marker Serial Number______________________

A1
TABLE OF CONTENTS
Introduction . . . . . . . . . . . . . . . . . . . . . . . . . A3 Maintenance . . . . . . . . . . . . . . . . . . . . . . . . . E1
Serial Number . . . . . . . . . . . . . . . . . . . . . . A3 Cleaning . . . . . . . . . . . . . . . . . . . . . . . . . . . E1
Definitions of Safety and Lubrication . . . . . . . . . . . . . . . . . . . . . . . . . E2
Service Statements. . . . . . . . . . . . . . . . . A4 Grease Fittings . . . . . . . . . . . . . . . . . . . . E2
Warranty. . . . . . . . . . . . . . . . . . . . . . . . . . . A6 Wheel Bearings . . . . . . . . . . . . . . . . . . . E2
Specifications . . . . . . . . . . . . . . . . . . . . . . . A8 Line Strainer Maintenance . . . . . . . . . . . . . E5
Safety Sign Locations . . . . . . . . . . . . . . . A10 Sprayer Nozzle Maintenance . . . . . . . . . . . E5
Safety Sign Care . . . . . . . . . . . . . . . . . . . A12 Spray Tip Care . . . . . . . . . . . . . . . . . . . . E5
Tip Replacement. . . . . . . . . . . . . . . . . . . E6
Safety Information . . . . . . . . . . . . . . . . . . . . B1 Tire Pressure . . . . . . . . . . . . . . . . . . . . . . . E7
Chemical Safety . . . . . . . . . . . . . . . . . . . . . B1 Wheel Bearing Replacement . . . . . . . . . . . E7
Equipment Safety. . . . . . . . . . . . . . . . . . . . B3 Tread Width Adjustment. . . . . . . . . . . . . . . E8
Lighting and Marking . . . . . . . . . . . . . . . . . B4 Preparation for Storage . . . . . . . . . . . . . . . E9
During Operation . . . . . . . . . . . . . . . . . . . . B4
Following Operation . . . . . . . . . . . . . . . . . . B4 Troubleshooting . . . . . . . . . . . . . . . . . . . . . . F1
Highway and Transport Operations . . . . . . B5 Field-Pro II Operation . . . . . . . . . . . . . . . . . F1
Remember . . . . . . . . . . . . . . . . . . . . . . . . . B5
Parts Listing. . . . . . . . . . . . . . . . . . . . . . . . . G1
Initial Preparation And Setup . . . . . . . . . . . C1 1,000 Gallon Frame and Tank Assembly. . G1
Tractor Preparation and Hookup . . . . . . . . C1 Base Plumbing details . . . . . . . . . . . . . . . . G5
Initial Preparation of the Sprayer . . . . . . . . C6 X-Fold Boom Center Section. . . . . . . . . . . G7
Controller Installation . . . . . . . . . . . . . . . . . C8 X-Fold Boom Inner Wing Detail . . . . . . . . . G9
Raven 440 Controller . . . . . . . . . . . . . . . . . C9 X-Fold Boom Outer Wing Detail . . . . . . . G11
Spraying Systems 744 Controller . . . . . . C12 X-Fold Boom Hydraulic Detail . . . . . . . . . G13
Raven Radar Mount. . . . . . . . . . . . . . . . . C16 X-Fold Boom Plumbing Schematic . . . . . G15
Quick Fill Meter Kit . . . . . . . . . . . . . . . . . G17
Operation . . . . . . . . . . . . . . . . . . . . . . . . . . . D1 Wheel / Hub Assembly . . . . . . . . . . . . . . G18
Filling the Tank . . . . . . . . . . . . . . . . . . . . . . D1 Outback Foam Guidance System,
Using the Optional Flow Max 110 Model 6 or 10 . . . . . . . . . . . . . . . . . . . . G19
Fill Meter. . . . . . . . . . . . . . . . . . . . . . . . . D2 9303C-HM1C Pump Kit . . . . . . . . . . . . . . G21
Adding and Mixing Chemicals . . . . . . . . . . D4 Inductor Kit. . . . . . . . . . . . . . . . . . . . . . . . G23
Boom Operation. . . . . . . . . . . . . . . . . . . . . D5 Rinse System Assembly . . . . . . . . . . . . . G25
Boom Control with John Deere 8000 Deluxe Plumbing Plate w/ 3-Valve
Series & Case IH MX Magnum Series Stack Assembly . . . . . . . . . . . . . . . . . . G27
Tractors . . . . . . . . . . . . . . . . . . . . . . . . . D6
Extending the Boom Wings . . . . . . . . . . D7 Electrical Wiring Details . . . . . . . . . . . . . . . H1
Retracting the Boom Wings . . . . . . . . . . D7 Field Pro II Wiring Diagram . . . . . . . . . . . . H1
Sprayer Operation . . . . . . . . . . . . . . . . . . . D7 Field Pro II Wiring Diagram for 3
Foam Marker Operation . . . . . . . . . . . . . D9 Section Ball Valve Plumbing . . . . . . . . . H3
Controlling Drift. . . . . . . . . . . . . . . . . . . . D9
Types of Drift . . . . . . . . . . . . . . . . . . . . D10
Factors Affecting Drift . . . . . . . . . . . . . . D10
Managing Drift . . . . . . . . . . . . . . . . . . . D11
Spray Nozzle Selection . . . . . . . . . . . . . . D12
Rinsing the Sprayer . . . . . . . . . . . . . . . . . D13

A2
INTRODUCTION
Serial Number
The serial number provides important information about your BESTWAY sprayer and may be

required to obtain the correct replacement part(s).

The serial number plate for the sprayer is located on the right side of the mainframe near the

front. The boom has its own serial number, which is located on the rear side of the center section.

It is suggested that the serial numbers also be recorded in the space provided in the front of this

manual. Always provide the serial numbers and model numbers when ordering parts from your

BESTWAY dealer or anytime correspondence is made with RHS Manufacturing.

Definitions of Safety and Service Statements

Boom Serial Number


Frame Serial Number

A3
TAKE NOTE! THIS SAFETY ALERT SYMBOL FOUND THROUGHOUT

THIS MANUAL IS USED TO CALL YOUR ATTENTION TO INSTRUC-

TIONS INVOLVING YOUR PERSONAL SAFETY AND THE SAFETY OF

OTHERS. FAILURE TO FOLLOW THESE INSTRUCTIONS CAN

RESULT IN INJURY OR DEATH.

THIS SYMBOL MEANS !


- ATTENTION!

- BECOME ALERT!

- YOUR SAFETY IS INVOLVED!

If you have questions not answered in this manual, require additional copies or the manual is

damaged, please contact your dealer or RHS, Inc., 2005 West Oregon Street, Hiawatha, KS 66434.

TELEPHONE: (785) 742-2949, FAX: (785) 742-7174.

All safety statements in this manual, as well as those found on safety decals, are preceded by

A4
the following warning symbols. Carefully read and follow the instructions provided.

Indicates and imminently hazardous situation that, if not

! DANGER: avoided, will result in death or serious injury. This signal

word is to be limited to the most extreme situations typically for machine components

which, for functional purposes, cannot be guarded.

Indicates a potentially hazardous situation that, if not avoided,

! WARNING: could result in death or serious injury, and includes hazards that

are exposed when guards are removed. It may also be used to alert against unsafe practices.

Indicates a potentially hazardous situation that, if not avoided,

! CAUTION: may result in minor or moderate injury. It may also be used to

alert against unsafe practices.

The IMPORTANT notice gives important instructions to prevent


IMPORTANT: damage to the machine or systems.

A Note will give general information about the correct operation


NOTE:
and maintenance of the machine and systems.

A5
Warranty
RHS, Inc. ("RHS") warrants each new Bestway product to be free from defects in RHS manu-

factured components and workmanship. This warranty is applicable only for the normal service

life expectancy of the product or components, not to exceed twenty-four (24) consecutive months

from the date of delivery of the new Bestway product to the original purchaser.

Purchased components installed by RHS (pumps, controls, tanks, wheels, valves, cylinders, fit-

tings, etc.) shall be warranted by their respective manufacturer for a period of twelve (12)

consecutive months from the date of delivery of the new Bestway product to the original purchaser.

All warranty work is to be performed at the dealer’s location unless authorized by RHS.

A completed Owner Registration Form from the original purchaser must have been received by

RHS to activate warranty coverage.

Genuine Bestway replacement parts and components will be warranted for ninety (90) days

from date of purchase, or the remainder of the original equipment warranty period, whichever is

longer.

Under no circumstances will it cover any merchandise or components thereof, which, in the

opinion of RHS, has been subjected to misuse, unauthorized modifications, alteration, an accident

or if repairs have been made with parts other than those obtainable through RHS.

Our obligation under this warranty shall be limited to repairing or replacing, free of charge to

the original purchaser, any part that, in our judgement, shall show evidence of such defect, provid-

ed further that such part shall be returned within thirty (30) days from the date of failure to RHS

through the dealer or distributor from whom the product was purchased, transportation charges pre-

paid.

This warranty shall not be interpreted to render RHS liable for injury or damages of any kind

or nature to person or property. This warranty does not extend to the loss of crops, loss because of

delay in harvesting, or any expense or loss incurred for labor, substitute machinery, rental or for

any other reason.

A6
Except as set forth above, RHS shall have no obligation or liability of any kind on account

of its equipment and shall not be liable for special or consequential damages. RHS makes no

other warranty, expressed or implied, and, specifically, RHS disclaims any implied warranty

or merchantability or fitness for a particular purpose. Some states or provinces do not per-

mit limitations or exclusions of implied warranties or incidental or consequential damages, so

the limitations or exclusion in this warranty may not apply.

This warranty is subject to any existing conditions of supply, which may directly affect our

ability to obtain materials or manufacture replacement parts.

RHS reserves the right to make improvements in design or changes in specifications at any

time, without incurring any obligation to owners of units previously sold.

No one is authorized to alter, modify or enlarge neither this warranty nor the exclusions, limi-

tations and reservations.

A7
SPECIFICATIONS

A8
Overall Dimensions Capacities
(A) Total length 220 in. (5488 mm) Sprayer tank 1,000 gal. (3785.5L)
Rinse system tank 50 gal. (189.3 L)
Chemical induction tank 15 gal. (57 L)
(B) Hitch to axle length 136 in. (3455 mm)
Fresh water tank 5 gal. (18.9 L)
Foam marker
(C) Crop clearance
OBK-6 6 gpm (22.7 L/min.)
12.4-38 Tire 27.5 in. (699 mm)
w/50 gal. (189.3 L)
OBK-10 10 gpm (37.8 L/min.)
(D) Hitch clearance 39.5 in. (1003 mm)
w/50 gal. (189.3 L)
(E) Hitch height
12.4-38 Tire 17.5-19 in. (445-483 mm)
Suspension
Axle 4 x 6 x 3/8 in. (102 x 152 x 10 mm)
(F) Height to top of tank Spindle 2.75 in. ( 70 mm)
12.4-38 Tire 92 in. (2337 mm) Hub 8 bolt @ 6,000 lbs.(2722 kg)
Tire size 12.4-38 bias 8-ply
(G) Transport height (booms folded)
60’ X-Fold Boom & 12.4-38 Tires 97-127 in.
(2464-3226mm) Tractor Requirements (Minimum)
Horsepower Rating 110 hp with cab
(H) Boom working height Hydraulic Capacity 10 to 19 gpm(38-72.2L/min.)
12.4-38 Tire 18 in. (457mm) to
48 in. (1219 mm)

(J) Boom width (folded) 146 in. (3709 mm)

(K) Treadwidth
Narrow axle 80-92 in. (2032-2337 mm)
Wide axle 120-144 in. (3048 to 3658 mm)

Weights (1,000 Gal. Tank w/60’ Boom)


Empty weight 4580 lbs. (2078 kg)
Tongue weight 120 lbs. (55 kg)) empty
Payload 12000 lbs. (5443 kg) max.
Boom weight 1350 lbs. (613 kg)

A9
! Safety Sign Locations

A C E B D F

P/N 67657 A P/N DEC-HAZ01 A

A10
P/N 67673 B

P/N SW001 C P/N/ 67671 C P/N 67672 C

P/N DEC-HAZ02 D P/N SW900 E P/N 60962 F

A11
! Safety Sign Care

• Keep safety signs clean and legible at all times.


• Replace safety signs that are missing or have become illegible.
• Replaced parts that displayed a safety sign should also display the current sign.
• Safety signs are available from your Distributor or Dealer Parts Department or RHS, Inc.
How to Install Safety Signs:

• Be sure that the installation area is clean and dry.


• Decide on the exact position before you remove the backing paper.
• Remove the smallest portion of the split backing paper.
• Align the decal over the specified area and carefully press the small portion with the
exposed sticky backing in place.

• Slowly peel back the remaining paper and carefully smooth the remaining portion of the
decal in place.

• Small air pockets can be pierced with a pin and smoothed out using the piece of decal
backing paper.

A12
! SAFETY INFORMATION
As the manufacturer of your BESTWAY Field-Pro II sprayer, we care about your safety. In

fact, this machine and its systems have been designed to provide maximum safety. Unfortunately,

no machine design can prevent operator error or carelessness.

This operator’s manual provides instructions for the safe operation and maintenance of the

Field-Pro II. Please read and understand this and all other manuals included in your owner’s packet

before operating the machine.

! Chemical Safety

• Handle all agricultural chemicals with care as required by the chemical manufacturer’s
recommendations. This includes, but is not limited to, the following safety precautions.

• Do not spray chemicals when the wind is in Keep personal wash tank
full of clean water for
excess of the label recommendations. emergencies and rinse
purposes.
• Never allow chemical to contact the skin or eyes.
• Wear approved protective equipment and cloth-
ing. This equipment includes, but is not

limited to, a protective hat, goggles or face shield,

chemical resistant gloves, long sleeved shirt, long

pants, and a chemical resistant apron.

• Keep in mind that the cab filter may not filter out
dangerous chemicals. Follow instructions provid-

ed by the chemical manufacturer.

• Before leaving the tractor cab, wear personal protective equipment as required by the

B1
pesticide use instructions. When re-entering the cab, remove protective equipment and

store either outside the cab in a closed box or some other type of sealable container, or

inside the cab in a pesticide resistant container, such as a plastic bag.

• Clean your shoes or boots to remove soil or other contaminated pesticides prior to entering
the tractor cab.

• Select an area to fill, flush, calibrate and decontaminate the sprayer where chemicals will
not drift or run off to contaminate people, animals, vegetation, water sources, etc.

• Never place nozzle tips or other parts to the lips to blow out trash or residue. Have spare
tips available for replacement.

• Know the phone number and location of your nearest poison control center. Maintain a list
of all chemicals being used and the MSDS for each one.

• Keep personal wash tank full of clean water for rinsing face and hands, as well as for
cleaning safety equipment and spray nozzles. This water is not intended for human or ani-

It is possible for certain agricultural chemicals to

! WARNING:
penetrate into the polyethylene tank wall and/or the

walls of connecting hoses. There is a possibility that certain chemicals subsequently

introduced into the tank may cause some leaching of a previously used chemical from

the tank wall. As a result, personal injury, as well as crop, soil or other damage could

occur, depending on the properties of the chemicals involved. Before making any

decision regarding the later use of different chemical solutions, the operator should

consider this leaching trait and consult the chemical suppliers regarding any potential

effects. Prior use of certain chemicals may prevent the appropriate and safe use of

some chemicals at a later date. Repeated flushing between appropriate chemical

changes is required.

B2
mal consumption.

! Equipment Safety

• Make sure no person or object is in the path of the sprayer booms, especially when retract-
ing or extending the wings.

• Always retract and lock booms in the storage position, except during application.
• Stay clear of overhead power lines when folding or extending the boom wings. Serious
injury or death from electrocution could Be particularly careful
when folding and unfolding
occur if the wings come in contact with the spray booms.

power lines.

• Always maintain correct tire pressure. Do


not inflate above the recommended pressure.

• Check wheels and tires regularly for low


pressure, cuts, bubbles, damaged rims, loose

or missing lug bolts and nuts.

• Restrict towing speed to 25 MPH empty, 10


MPH loaded.

• Do not remove safety devices or shields.


Never service, clean or repair any part of the

sprayer while the machine or the tractor is

operating.

• Replace any CAUTION, WARNING, DAN-

GER or instruction safety decal that is not readable or is missing. Location of such decals is

indicated in this booklet.

• Do not attempt to operate this equipment under the influence of drugs or alcohol.

B3
! Lighting and Marking

• It is the responsibility of the customer to know the lighting and marking requirements of

the local highway authorities.

• REMEMBER: If Safety Signs have been damaged, removed, become illegible or parts

are replaced without decals, new decals must be applied. New decals are available from RHS,

Inc at 1-800-247-3808.

! During Operation

• NO PASSENGERS ALLOWED - Do not carry passengers anywhere on, or in, the tractor

or equipment, except as required for operation.

• Be especially observant of the operating area and terrain - watch for holes, rocks or other

hidden hazzards. Always inspect the area prior to operation. DO NOT operate near the edge

of drop-offs or banks. DO NOT operate on steep slopes as overturn may result. Operate up

and down (not across) intermediate slopes. Avoid sudden starts and stops.

• Maneuver the tractor or towing vehicle at safe speeds.

• Do not walk or work under raised components or attachments unless securely positioned

and blocked.

! Following Operation

• Store the unit in an area away from human activity.

• Do not permit children to play on or around the stored unit.

B4
! Highway and Transport Operations

• Comply with state and local laws governing highway safety and movement of farm

machinery on public roads.

• Always operate equipment in a position to provide maximum visibility at all times. Make

allowances for increased length and weight of the equipment when making turns, stopping

the unit, etc...

! Remember

• Your best assurance against accidents is a careful and responsible operator. If there is

any portion of this manual or function you do not understand, contact your local authorized

dealer or RHS, Inc at 1-800-247-3808.

B5
B6
INITIAL PREPARATION
AND SETUP

Tractor Preparation and Hookup


1. Check and adjust tractor drawbar as shown so that it is located 13 to 17 inches above the

ground. Then adjust the drawbar to a stationary position so that the hitch pin is directly below the

center line of the PTO shaft.

2. Adjust sprayer hitch position, if necessary, to a setting that allows the trailer to tow in a level

position when hitched to the tractor. A total of three holes in the hitch mounting bracket permit the

choice of two different mounting positions.

3. Securely attach to towing unit. Connect sprayer to the tractor using a high strength, 1-1/4” -

1-1/2” hitch pin with a locking hairpin or hammer strap latch and attach safety chains. Install the

safety chain by crossing the chains under the tongue and secure to the draw bar cage or hitch or

C1
bumper frame.

4. Attach quick disconnect fittings to ends of hydraulic hoses to match tractor ports. Then con-

nect hydraulic hoses to tractor ports in a sequence that is both familiar and comfortable to the

operator. It is suggested that the hydraulic hoses for the hydraulic pump be connected to the num-

ber one outlet, while the boom control hoses are connected to the number two outlet or to the outlet

that corresponds to the outermost control lever on the tractor’s hydraulic control console. A low

pressure return port for the hydraulic pump is recommended.

Before applying pressure to the hydraulic system, make

! WARNING: sure all connections are tight and that hoses and fittings

have not been damaged. Hydraulic fluid escaping under pressure can have sufficient

force to penetrate skin, causing injury and/or infection.

Always clean hose ends to remove any dirt before


IMPORTANT: connecting couplers to tractor ports.

5. Install the Raven or Spraying Systems spray controller unit in the tractor cab, following the

instructions provided with the controller unit. If the tractor is not equipped with a radar system, be

sure to also install the wheel drive speed sensor as instructed.

6. Extend the controller power cable from the tractor cab to the battery and connect the battery

terminal rings directly to the battery posts, making sure the positive (red) and negative (black)

wires correspond with the polarity of the battery terminals.

C2
Some tractors use two 6-volt batteries as a power
NOTE: source. Make sure there is a total of 12 volts delivered

to the controller by connecting to the Positive (+) terminal of one battery and the

Negative (-) terminal of the other battery. Reliable operation of the controller

depends on a clean power supply. Ensure this by connecting the power cables directly

to the battery and not to another power source.

Batteries can hurt you. They can be dangerous. They

! CAUTION:
contain acid that can burn you, gas that can explode

or ignite, and enough electricity to burn you.

7. Install the foam marker control box in a convenient location in the tractor cab. Connect the

power leads to an adequate source of 12-volt power. If the power leads are not directly connected to

the battery, make sure the wires feeding the hookup location are at least 12 gauge in diameter.

C3
Make certain the red wire is connected to the positive
IMPORTANT:
side and the black wire to negative while attaching the

power leads. Damage to the unit can occur if the leads are reversed.

8. Install the joystick boom control on

the #2, or outer hydraulic remote control

lever as described and illustrated on the fol-

lowing page (Except John Deere 8000 Series

and Case IH MX Magnum Series tractors).

Once attached, the joystick is designed to be

used as the hydraulic lever handle while

C4
choosing the appropriate function. Each button on the joystick represents a different function (Refer

to Boom Control Section under Operation).

To install the joystick boom control:

a. Remove handle grip or ball from

appropriate hydraulic lever.

b. For round lever, use round U-bolts,

washer plate, lock washers and

nuts to connect joystick to lever.

c. For rectangular lever, use square

U-bolts, washer plate, lock wash- round rectangular flat or odd


lever lever shaped lever
ers and nuts to connect joystick to

lever.

d. For flat or odd shaped lever, mark hole centers on lever and drill two 5/16" holes.

Attach joystick to handle using two 1/4" bolts, lock washers and nuts.

e. Tighten all nuts to secure joystick to lever.

9. Connect the wiring harnesses leading into the tractor to the appropriate controls, including

the electric controller for the boom valve block (controlled by the hydraulic joystick), and the spray

controller unit.

10. If the Field-Pro II sprayer is to be operated by a John Deere 8000 Series or Case IH MX

Magnum Series tractor, a special footpad control must be installed in place of the joystick boom

control, due to use of fingertip hydraulic control levers.

C5
To install the footpad:

a. Plug the footpad control

into the power accessory outlet

on the tractor’s control console.

b. Connect the footpad con-

trol to the main wiring harness

from the sprayer.

Footpad control for John Deere 8000 Series and


Case IH MX Magnum Series.

Initial Preparation of the Sprayer


1. Lubricate the boom pivot points per the lubrication information in this manual prior to initial

operation and at prescribed intervals thereafter. Also, make sure all tires have been properly inflated

prior to each use.

2. Read all other manuals provided with the Field-Pro II sprayer, including those that pertain to

the controller and pump.

3. If the control valve plumbing has not been pre-installed on the sprayer, follow the directions

provided in this section for installation procedure.

4. Refer to the pump operating instructions (provided with the sprayer) to make sure the pump

or tractor hydraulic system has been adjusted to match pressure and flow requirements. In general,

there are three types of hydraulic systems used on agricultural tractors: Load Sensing, also known

as pressure-flow compensating closed center (LS); Pressure Compensating Closed Center (PC), and

Open Center (OPEN). The flow of hydraulic oil is regulated in a different manner for each type of

system. If you are in doubt about the type of system used on the tractor that will be used to operate

the Field-Pro II, consult the tractor’s operator’s manual or your tractor dealer.

C6
Failure to regulate oil flow to the pump will cause
IMPORTANT: motor damage.

5. Follow the directions in the sprayer control operating manual to calibrate and set the controller.

6. Fill the sprayer half full of water using the quick fill port (see filling the sprayer in the

“Operation” section). Also, fill the rinse tank and the personal wash tank. Check for leaks around

all tanks and valves. Ensure that the agitation valve is at least 1/2 open.

7. Make sure the tank suction valve is turned on, allowing water to flood the pump inlet. Start

the tractor engine, engage the pump by actuating the appropriate hydraulic remote valve and adjust

the tractor rpm to the speed that will be used when spraying. Do not continue to operate the pump

if pressure is not indicated immediately.

8. Unfold boom slowly and carefully (See boom operation in the “Operation” section).

Position boom so the nozzles can all be observed easily.

Make sure no person or object is in the path of the


! DANGER:
wings, especially when folding or unfolding. Be aware

of the boom location at all times. Stay away from power lines when folding or unfolding

wings. Always retract and lock wings except during application.

Make sure when unfolding boom, sprayer is attached to

! WARNING:
a towing vehicle.

9. With pressure showing on the pressure gauge, set the controller to its manual mode and turn

on the valves for each section of the spray boom. Ensure that the spray tips being used match those

C7
preprogrammed in the controller.

10. Turn on the master switch to direct water to the spray nozzles. At this point, the sprayer

will be activated and spray tip performance can be visually checked. However, it is recommended

that you also use a calibrated container and a stop watch to manually check and calibrate each

spray nozzle prior to initial operation.

11. Check the operation of the sparge system and the tank rinse system to make sure they are

operating properly.

Controller Installation
In most cases, the Field-Pro II will come from the factory with either the Raven 440 sprayer

control or the Spraying Systems 744 sprayer control pre-installed. However, the Field-Pro II can

3-valve stack assembly


with Raven controller.

also be ordered with the base deluxe plumbing plate and 3 valve plates as well, which permits the

owner to install any compatible control system desired. Keep in mind that the deluxe ball valves

require 12 volts at all times so the valves can close when the control wires drop voltage. This is

C8
different than a solenoid-type valve that closes with spring action.

To install a Raven 440 control or the

Spraying Systems 744 control on


Figure 1.
a unit that is not already

equipped with the unit, refer to

the specific instructions that fol-

low.

Raven 440 Controller


Overview

The control valve used with

the Raven 440 Control system

is placed in an in-line location.

In addition, the Raven control

may be equipped with either a

wheel drive or a radar speed

sensor.

Installation
The Raven installation manual should

provide most of the installation information

required. However, the following instructions are


Figure 2.
intended to help when mounting the Raven flow

meter into the existing plumbing on the Field-Pro II sprayer.

C9
1. Dissassemble the plumbing as illustrated in Figure 1.

2. Re-Locate gauge tee next to valve stack inlet as illustrated in Figure 2.

3. Install the remaining plumbing using the flow meter and butterfly valve from the Raven

controller kit as illustrated in Figure 2.

4. Refer to the sprayer control owner’s manual for installation of remaining controller compo-

nents.

5. Connect wiring as shown in diagram on page C11.

Raven 440 Spray Control Kit


REF P/N DESCRIPTION QTY

1 RE063-0172-125 Butterfly Valve, 1" 1

2 RE063-0171-793 Flow Meter, RFM-60P 1

3 150-G Gasket, 2" Manifold Fitting 2

FC200 Clamp, 2” Flanged Fitting (not shown) 2

C10
Raven 440 Spray Wiring Diagram

C11
Spraying Systems 744 Controller

Overview

The Spraying Systems 744 controller allows the operator to adjust the spray pressure from the

console. The control valve is placed in a bypass location which dumps unwanted pressure back to

the inlet of the pump. Hence, it is important that you do not use an in-line configuration for the

control valve. The bypass configuration increases control range and provides a more even response

throughout the travel of the valve.

Plumbing Installation
Installation of the Spraying Systems controller will require building a bypass line from the

control plate to the inlet side of the sprayer pump plumbing, as well as installation of the controller

valve. All fittings and hose required for this operation are supplied with the controller kit from RHS.

1. Remove the hose and appropriate fittings from the standard plumbing system as illustrated

in figure 6.

3. Install “T” fitting, hoses, and flow meter as illustrated in Figure 6, using the hardware and

fittings supplied.

4. Locate the metering valve supplied with the controller, as well as all the plumbing parts

shown in Figure 6. Using these parts, build the bypass as illustrated, starting at the “T” fitting

installed in step 3 and ending at the “T” fitting located in the pump inlet plumbing. Be

careful not to over tighten or break any fittings.

5. If desired, the existing gauge can be removed and replaced with fittings (5) & (6) in

Figure 6. This will provide a location to connect the gauge tubing that feeds the gauge on the 744

controller.

6. Refer to sprayer control owner’s manual for installation of the remaining controller components.

7. Connect wiring as shown in Figure 7.

C12
Spraying Systems 744 Spray Control Kit - 3 section plumbing
REF P/N DESCRIPTION QTY
1 150-G GASKET, 2" MANIFOLD FITTING 2
FC200 CLAMP, 2" MANIFOLD (NOT SHOWN) 2
2 M200100TEE TEE, 2" x 1" MANIFOLD, POLY 2
3 M100G GASKET, 1" MANIFOLD FITTING 2
FC100 CLAMP, 1" MANIFOLD (NOT SHOWN) 2
4 M100075MPT FTG, 1" MANIFOLD x 3/4"MPT 1
5 1181 LINE FITTING, 1/8”MPT x 1/8”TUBING 1
6 RB-1418PP REDUCER BUSHING, 1/4”MPT x 1/8”FPT 1
7 EL-3410PP ELBOW, 3/4”MPT x 1”HB 1
8 HC-10 HOSE CLAMP, 1" WORM GEAR 2
9 EPDM10 HOSE, 1" EPDM x 60"LG 1
10 M100BRB FITTING, 1"MANIFOLD x 1"HB 1
11 METERING VALVE (INCLUDED WITH CONTROLLER) 1

C13
Figure 6.

C14
Spraying Systems 744 Wiring Diagram
3 Section Plumbing

Figure 7.

C15
Raven Radar Mount

Raven Radar Mount


REF P/N DESCRIPTION QTY
1 SU12.6.312 U-bolt, Sq. 1/2NC x 3-1/2 x 6 1
2 LW12 Lock Washer, 1/2” ZP 2
3 N12 Nut, 1/2”NC ZP 2
4 74231 Wment, Radar Mount - FP Trailers 1
5 B38.1 Bolt, 3/8NC x 1 3
6 FW38 Flat Washer, 3/8” 3
7 LW38 Lock Washer, 3/8” ZP 3
8 N38 Nut, 3/8NC 3
9 74232 Wment, Radar Mount-Raven Adapter 3
10 -------- Bolt (included with Radar) 4
11 -------- Lock Washer (included with Radar) 4
12 -------- Flat Washer (included with Radar) 4
13 RE063-0159-836 Radar 1
RE117-0159-822 Radar (new style, mid 2002 model year) 1
RE115-0159-032 12’ Speed Sensor Extension 1

C16
Main tank
Quick-Fill,
“off” position

OPERATION
Filling The Tank
The 1,000 gallon tank on the Field-Pro II sprayer can be filled in one of two ways – through

the top hatch using auxiliary equipment, or through the Quick-Fill valve auxiliary equipment.

To fill the tank through the Quick-Fill valve:

1. Shut off engine on towing tractor and engage parking brake.

2. Make sure Quick-Fill valve is closed.

3. Remove cap on Quick-Fill valve and connect hose from nurse tank.

4. Program the Flow Max 110 fill meter (if so equipped) to record or count

down desired quantity of liquid being added to main tank.

5. Start pump on auxiliary equipment to pressurize fill hose.

6. If applicable, open valve on fill hose or nurse tank.

D1
7. Open Quick-Fill valve to begin filling.

8. When fill meter registers desired amount, or tank is full, close Quick-Fill valve and reverse

the previous steps.

Using the Optional Flow Max 110 Fill Meter


The Flow Max 110 Fill Meter, available as optional equipment on the Field-Pro II sprayer, can

be used to monitor a variety of functions including:

Function Display Title


Sub-total Volume (Volume increments) SUb
Total Volume (Volume increments) vol
Batch Volume (Volume decrements from pre-
entered number) bCh
Flow Rate (vol/min.) FLo
Meter Calibration CAL

The console is equipped with a Power


NOTE:
Down feature that turns OFF the

console if no flow is sensed and no key is depressed for 2 minutes.

D2
Entering Data

1. Turn on console by depressing ON.

2. Toggle to the desired function category by depressing the key labeled .

3. Depress ENTER key. Display will flash "E".

4. Enter data one digit at a time, starting with the left digit. To increment through the numbers,

depress the key labeled until the correct number is reached.

5. Then depress the key labeled to shift the digit one place to the left.

6. Continue this sequence until all digits have been entered.

7. Depress ENTER key to complete the sequence.

8. The display will stop flashing.

EXAMPLE: To enter the number "123", the operator should:

1. Depress the ENTER key. Display will flash "E".

2. Depress the key labeled one time to display the number "1".

3. Depress the key labeled one time to shift the digit over one space.

4. Depress the key labeled two times to increment the display to the number "2".

5. Depress the key labeled again to shift both the numbers "1" and "2" over one position.

6. Depress the key three times to increment the display to the number "3"

7. The display will now read "123".

8. Depress the ENTER key.

D3
Sparge valve, Inductor
“on” position

Induction valve,
Inductor rinse valve,
“off” position
“off” position

Pump inlet Inductor discharge


selector valve, valve,
“off” position

Adding and Mixing Chemicals


Although chemicals can be added directly to the main tank through the hinged tank lid, the

sprayer has been equipped with a chemical induction system for quick loading and thorough mix-

ing. To add and mix chemicals in the tank:

1. Fill main sprayer tank with desired amount of clean water.

2. Remove stow lock pin from inductor mount bracket and lower inductor tank to load posi-
tion. Pull outward and downward on inductor handle to unlock scissors lift mounting bracket.

3. Set pump inlet selector valve to draw from main tank. Close inductor discharge valve, and
open the sparge and induction valves.

4. Activate tractor remote valve to engage pump and close down the sparge valve to achieve 60-
80 psi manifold pressure.

5. Remove inductor lid. Measure out and add appropriate amount of chemical as prescribed by
the product label.

Always handle agricultural chemicals with care, using the


! CAUTION: proper safety equipment as prescribed by the product label.

D4
6. Open inductor discharge valve to transfer chemical to main tank.

7. Rinse chemical container and inductor tank using handgun provided. Close inductor dis-

charge valve when inductor tank is empty.

8. Close induction valve and raise inductor tank to transport position. Pull outward and

upward on inductor handle to unlock scissors lift mounting bracket. Secure inductor with stow

lock pin.

9. Allow pump to operate for a sufficient amount of time to mix all chemicals. Refer to chemi-

cal label for suggested mixing duration.

Boom Operation
All hydraulic boom functions are controlled with the boom control joystick (except John Deere

8000 Series and Case IH MX Magnum Series tractors, see special instructions on page D6) in

combination with the hydraulic remote valve lever.

To raise or lower the center section of the boom, which in turn controls the overall boom height,

depress the green button on the lower portion of the handle and move the lever forward to lower the

D5
boom or rearward to raise the boom. Reversing the hydraulic hoses will reverse the control operation.

Smoothest operation is attained by first depressing the


NOTE:
button and then moving the remote control lever. When

only a small amount of movement is desired, hold the button and feather the

hydraulic lever in the appropriate direction.

The wing height adjustment cylinders are actuated by pushing the appropriate button of the

joystick while moving the hydraulic remote lever. The blue button controls the left and the white

button controls the right wing height (tilt) cylinder.

Boom Control With John Deere 8000 Series Tractors & Case IH MX

Magnum Series Tractors

Due to the use of fingertip hydraulic control levers on some of the

newer tractors, it is necessary to actuate the various hydraulic functions

through a footpad control rather than the standard joystick control. To

operate a specific boom function, depress the corresponding foot pedal

on the control pad and then operate the hydraulic control. The left wing

is extended by the left foot pedal, the right wing is extended by the
Footpad control for John Deere 8000 Series and
Case IH MX Magnum Series. right foot pedal and using both pedals simultaneously extends both

wings together. To operate the center section (X-Fold only), release both foot pedals and operate

the hydraulic control.

D6
Extending Boom Wings.

1. Remove transport pin from center section to let boom pivot freely (X-Fold only).

2. Unfold wings until boom cylinders are fully extended

3. Lower center section to desired spray height (X-Fold only).

Make sure no person or object is in the path of the

! DANGER:
wings, especially when folding or unfolding. Be aware of

the boom location at all times. Stay away from power lines when folding or unfolding

wings. Always retract and lock wings except during application.

Make sure when unfolding boom, sprayer is attached to a


! WARNING:
towing vehicle.

Never fold or unfold the booms while the tractor and

! CAUTION: sprayer are moving. Always make sure the sprayer is on

a flat, level surface.

Retracting Boom Wings.

To retract boom wings, follow the above steps in reverse.

Sprayer Operation
Once you have filled the sprayer tank and thoroughly mixed the chemical(s), you are prepared

to begin the spraying operation. At this point, you should have also determined the application rate

and programmed that information into the rate controller computer, along with information on the

spray tips, boom width, etc. To begin sprayer operation:

1. Switch rate controller computer on.

D7
2. Activate tractor hydraulic valve to start sprayer pump.

3. Toggle boom switches to their "on" position for each of the boom sections.

4. If controller is equipped with an Auto/Manual function, make sure it is switched to "Auto."

5. As you enter the field to the point where you will begin spraying, turn Master boom switch

to the "on" position.

6. Maintain your usual tractor speed for spraying. Moderate changes in tractor speed will not

affect the application rate, since such changes are compensated for by automatic pressure increases

or decreases.

7. If for any reason you need to stop, or when turn-

ing around at the ends of the field, turn Master boom

switch to "off".

Throttling valve Sparge Valve Function

The sparge valve is used to adjust tank sparge dur-

ing operation. Open the valve to increase sparging.


Sparge valve
Close the valve to reduce sparging or to increase capac-

Pump valve ity available to the boom.

Throttling Valve Function

In most cases, the rate controller will maintain the correct flow and pressure settings for the

desired application. However, in cases where the pressure within the systems is beyond the bounds

of the controller, you may wish to manually reduce the pressure to the regulating valve and boom

valves by partially closing the throttling valve. In most cases, it is best to start with the throttling

valve closed as far as possible, while still providing enough pressure to operate the boom satisfac-

torily.

Pump Valve

While operating the sprayer, the pump valve must be positioned to draw from the main sprayer

tank. While rinsing (described on page D13), the valve must be turned to draw from the rinse tank.

D8
Foam Marker Operation
Refer to the Operator’s Manual of your Foam Guidance System for operating instruc-
tion.

30 gallon foam
solution tank

Foam Guidance
Pump Unit

Controlling Drift

Drift can be defined as the movement of spray droplets outside the intended target. It is one of

the biggest environmental concerns chemical applicators face.

D9
Although some products have a greater tendency to drift than others, due to their volatility, the

potential for drift exists with any chemical. Unfortunately, with the advent of genetically altered

crops like Roundup Ready soybeans, and Liberty Link corn, the potential damage that can occur as

a result of chemical drift is greater than ever before.

In order to make informed decisions about nozzle selection and operation, an applicator must

first be knowledgeable about droplet size and the causes of drift.

Types Of Drift

• Particle drift - Particle drift is due to off-target movement of spray particles during
application. This can happen with any chemical.

• Volatilization drift - Volatilization drift is due to a chemical’s ability to volatilize after an


application has been made. Therefore, it has more to do with the chemical’s characteristics

than the sprayer or spray pattern.

Factors Affecting Drift

• Wind speed and direction - Since chemical particles can be carried by the wind, stronger
winds are obviously more likely to cause drift. A doubling of wind speed generally doubles the

horizontal distance droplets will travel.

• Relative humidity - In general, the lower the humidity, the greater the drift potential.
• Air temperature - In general, higher temperatures mean increased drift potential.
• Droplet size - With most chemicals, controlling spray droplet size is a key factor in
controlling drift. The smaller the droplet, the slower it will fall, the faster it will evaporate

and the further it will drift horizontally, particularly if winds are also a factor. Droplet size is

primarily determined by nozzle orifice size, spray angle and spray pressure. Therefore, an

increase in nozzle orifice size and/or a decrease in pressure is one way to increase droplet size

and decrease the potential for drift.

• Boom height - Boom height is an important factor in controlling drift. A boom that is set

D10
too high obviously favors drift, since droplets have farther to fall, thus having more time

and opportunity to drift off course. Doubling the boom height, in effect, doubles the

length of time required for droplets to reach the target canopy. That, in turn, doubles the

horizontal distance droplets can travel during their fall.

Managing Drift

To manage drift while spraying chemicals with the Field-Pro II:

• Spray when wind velocity and direction doesn't favor drift. Do not spray when winds are
gusty or under any condition which will allow drift to move to an off-target area. That

includes spraying when wind is blowing toward a crop that doesn't have a resistant gene,

such as Roundup Ready crops.

• Use a combination of nozzles and spray pressures that minimizes fine droplets. Keep spray
pressure within the range suggested by the nozzle manufacturer and use a larger nozzle –

one that delivers 10 to 20 gpm – if necessary.

• Keep boom height at the lowest possible effective height while spraying.

D11
Spray Nozzle Selection
Nozzle, or spray tip, selection is

often based upon droplet size, which

refers to the diameter of an individ-

ual spray droplet. In addition to its

importance in controlling drift,

droplet size from a nozzle becomes

important when the efficacy of a

particular crop chemical is dependent

on coverage. Always refer to the

chemical label for recommendations

on spray tip size and type.

• The majority of nozzles used in agriculture can be classified as producing either fine,
medium, coarse or very coarse droplets.

• Nozzles which produce fine droplets are usually recommended for post-emergence
applications, which require excellent coverage on leaf surfaces.

• The most common nozzles used in agriculture are those which produce medium sized
droplets. These can be used for contact and systemic herbicides, preemergence surface

applied herbicides, insecticides and fungicides.

• Remember that a spray nozzle in any droplet size category can produce different size
droplets at different spray pressures. A nozzle might produce medium droplets at low

pressures, while producing fine droplets as pressure is increased.

D12
Rinsing The Sprayer
It's important that you rinse the sprayer after each use, and every time you

change chemical solutions in the tank. In most cases, it's best to rinse and flush

the sprayer in the field, to minimize handling issues, with rinse water. In some

cases, you may also want to add a commercial tank cleaner to the rinse water to

help dissolve or neutralize certain chemicals. When doing so, be sure to read and

follow the tank cleaner manufacturer's directions for use of the tank cleaner.

Wear proper protective clothing, including gloves and eye protection.

1. Make sure the 50-gallon rinse tank has been filled with clean water.

2. With the pump off, turn pump valve to the “rinse” position (page D8).

3. Open tank rinse valve (Shown above.) Tank rinse valve,


“on” position
4. With sparge valve closed, turn on pump and operate long enough to pull about half the water

out of rinse tank through the system.

5. Switch pump valve back to main tank, open sparge valve for agitation, and close tank rinse

valve. This allows rinse water to circulate through plumbing and valves, while further rinsing main

tank.

6. Discharge rinse through boom valves and spray nozzles, preferably in the field where you

have been spraying.

7. Shut off pump and close sparge valve.

8. Switch pump valve back to rinse tank.

9. With rinse valve and the boom valves open, start pump to circulate remaining rinse water

through valves and plumbing system and out boom spray nozzles.

D13
D14
MAINTENANCE

Cleaning
Taking the time to clean the sprayer after each use is the most important thing you can do to

improve the performance and longevity of your BESTWAY Field-Pro II sprayer. This is particularly

important after the use of suspension type chemicals, which can crystalize and plug the flowmeter,

lines and/or spray tips. The potential benefits include less down time, an improved spray pattern

and an extended sprayer life.

1. Always end the day with an empty tank. If that is not possible, close the main shutoff valve

under the tank.

2. Rinse the interior of the tank and flush all the plumbing with clean water at the end of each

day and between each chemical change using the built-in Rinse System. If a film is detected on the

interior of the tank, add 2 to 3 pounds of detergent to 50 gallons of water. Refer to the “Rinse

System” section of this manual for more information on this step.

3. If possible, apply all rinse water from the tank on a field that has been previously sprayed.

Most pesticides are very safe unless they are used in a highly concentrated form. Take special

precautions, however, to avoid high concentrations in one spot.

4. Wash off the exterior of the sprayer, including the valve block and all manual valves. Make

sure chemical and fertilizer residue is removed from all metal areas. Use a bristle brush and deter-

gent if necessary.

5. Remove and check all nozzle screens, clean caps and tips in a bucket filled with clean

water and detergent. Use a tip brush if necessary. Rinse with clean water and reinstall.

E1
Lubrication

Grease Fittings

Proper lubrication will help insure efficient operation of your BESTWAY sprayer and prolong

the life of friction producing parts. Those parts equipped with grease fittings should be lubricated at

the frequency indicated with an SAE multi-purpose type grease. Be sure to clean the fitting thor-

oughly before using any grease gun.

The Field-Pro II is equipped with nine grease fittings. All are located on the boom pivot points

as shown in the photos on pages E3 and E4.

Wheel Bearings

Wheel bearings should be repacked with clean heavy duty axle grease approximately once a year

or at the beginning of each season. Follow the procedure outlined for wheel bearing replacement with

the exception that bearings and bearing cups are reused when the wheel bearings are being repacked.

E2
12 Hours

12 Hours

E3
12 Hours
(both sides of boom
center section)

12 Hours

E4
Line Strainer Maintenance
The Field-Pro II is equipped with a

line strainer which has been plumbed into

the pressure line from the pump. It is

important that the strainer be inspected at

regular intervals and washed in soapy

water, followed by a rinse in clean water,

to remove any sediment or foreign parti-

cles that may obstruct the flow.

To remove the filter screen, simply

unscrew the bowl from the strainer head

and remove the steel screen cartridge. In

the event a replacement screen is required,

or you have a need for a screen with larger

or smaller mesh openings, contact your

Bestway dealer or RHS, Inc.

Sprayer Nozzle Maintenance


Spray Tip Care

Careful cleaning of clogged spray tips can mean the difference between a clean field and one

with weed streaks. Keep in mind, however, that some spray tips, particularly flat spray tips, have

finely crafted thin edges around the orifice to control the spray. Even the slightest damage from

improper cleaning can cause both an increased flow rate and poor spray distribution.

That is one reason all spray nozzles on the Field-Pro II boom have been equipped with a

strainer, which helps minimize clogging, and lessens the risk of tip damage. Strainer screens should

E5
be removed and washed in clean water and

detergent each time the sprayer is cleaned,

or as needed. To remove the tip and screen,

simply twist the collar which holds the

screen in place and remove the tip from the

nozzle.

If a tip is clogged and does need clean-

ing, only use a soft bristled brush or

toothpick to clean it. Never use a metal

object or wire brush. Use extreme care with

soft tip materials such as plastic. Even a

wooden toothpick can distort the orifice.

Tip Replacement

Spray tips are often the most neglected

component on modern sprayers; yet they are

among the most critical items for proper chemical application. Remember, tips don’t last forever.

Unfortunately, tip wear may not be detected by visually inspecting a nozzle. The best way to deter-

mine if a spray tip is excessively worn is to compare the flow rate of the old tip to that of a new

one using an accurate graduated collection container and a timing device. Spray tips are considered

excessively worn and should be replaced when their flow exceeds the flow of a new tip by 10 per-

cent.

When replacing tips, you will find that certain types of tips are available in more than one type

of material. When considering the appropriate replacement tip, consider the following characteristics

before basing your decision on price alone.

E6
• Ceramic - Superior wear life and is highly resistant to abrasive and corrosive chemicals.
• Hardened stainless steel - Very good wear life, good durability and chemical resistance.
• Stainless steel - Good wear live, excellent chemical resistance and a durable orifice.
• Polymer - Good wear life and good chemical resistance, but orifice is susceptible to
damage when cleaned improperly.

• Brass - Poor wear life and is susceptible to corrosion, especially with fertilizers.
Tire Pressure
Tire pressure should be checked prior to each use of the sprayer and maintained as follows:

12.4 X 38 Bar Tread Tires 25-28 PSI

Keep in mind, that these pressure levels are intended as starting points only. The required

amount of tire pressure may be varied to achieve a 20" footprint when loaded, depending upon the

tank solution (i.e. liquid fertilizer) and field conditions.

Wheel Bearing Replacement


1. Jack tire clear of the ground, block axle securely and See parts listing on
page G18
remove wheel.

2. Remove hub cap from wheel hub.

3. Remove cotter pin, axle nut and spindle washer.

4. Slide hub from axle spindle, using a hub puller if

necessary.

5. Remove bearing cups from hub and discard. Thoroughly clean

wheel hub and dry.

6. Press in new bearing cups with thickest edges facing in.

E7
7. Pack bearings with heavy-duty wheel bearing grease, thoroughly forcing grease between

roller cone and bearing cage. Also fill the space between the bearing cups in the hub with grease.

8. Place inner bearing in hub and press in new grease seal with lip pointing toward bearing.

9. Clean axle spindle and install hub.

10. Install outer bearing, spindle washer and slotted hex nut. Tighten slotted hex nut while

rotating the hub until there is noticeable drag. This assures that all bearing surfaces are in contact.

Back off slotted nut to nearest locking slot and install cotter pin.

11. Fill hub cap half full of wheel bearing grease and install on hub.

12. Install wheel, tighten lug nuts to 265 foot pounds and remove jack and blocks.

Tread Width Adjustment


Axle stop Mounting strap Axle stop

The wheel treadwidth may be adjusted to accommodate a vari-

ety of row widths and cropping programs. The narrow axle may be

adjusted to any position between 96 and 120 inches, while the wide

axle may be adjusted to any position between 120 and 144 inches.

To adjust the treadwidth to a narrower or wider position:

1. Jack tire clear of ground and block axle. Make sure you

don’t impede movement of the spindle weldment or the mounting

straps.

2. Loosen the 3/4" x 2-1/2" mounting bolts that clamp the mounting strap and spindle to the axle.

3. Adjust axle treadwidth as required by axle width configuration.

a. For minor adjustment, slide the spindle in or out on the axle as needed, or until contact

is made with the stops.

E8
b. If the preceding step does not provide enough adjustment, remove the mounting strap

from its inboard or outboard position and reattach it in the alternate position.

c. After strap has been repositioned, but left loose, continue to slide the spindle in or out

on the axle as needed.

4. Tighten all strap mounting bolts.

5. Repeat the process on the opposite wheel, making sure the measurement is equal on both sides.

Preparation For Storage


1. Always store the sprayer inside a building if possible. This protects vulnerable components

like hoses, fittings, tires, valves and electronic relays from harmful ultraviolet rays, rain, snow and ice.

2. Thoroughly wash and flush the tank and plumbing system with a detergent solution; then

rinse with clean water. Be sure to dispose of all rinse in a safe and careful manner.

3. Clean all exterior surfaces of the sprayer using clean water and detergent.

4. Touch up all metal surfaces where paint has been scratched or damaged to prevent rust.

5. Lubricate and grease all lubrication points.

6. Hand wash all nozzles, strainers and check caps. Install new diaphragms in the check caps

and reinstall on the nozzle bodies.

7. Drain the foam marker tank by removing the strainer bowl. Clean and replace bowl.

8. Pour 10 to 15 gallons of non-toxic recreational vehicle (RV) antifreeze into the main tank

and rinse tank. Operate the sprayer until all hoses have been filled and RV antifreeze has begun to

spray out each of the spray nozzles before shutting off. Then make sure no RV antifreeze is leaking

from any fittings, hoses or nozzles.

9. Pour one gallon of RV antifreeze into the foam marker tank. Operate the foam marker for

two minutes per side on both sides of the wing.

E9
Glycol is a primary component of antifreeze and is poi-

! WARNING: sonous if ingested. Follow all precautions as if it were

any pesticide. Be especially careful to avoid puddles that pets or other animals can

get to.

10. Drain the personal wash tank completely. Wash the interior with a detergent solution, rinse

and dry by hand.

11. Using a pressurized air hose, blow out all electrical connections, as well as the interior of

the foam marker cabinet.

12. Clean the filter on the foam marker air pump.

13. Cover all unplugged connectors for protection against the weather.

14. If possible, block up the main trailer axle and reduce the air pressure in the tires during

long term storage.

E10
TROUBLESHOOTING GUIDE
Field-Pro II Operation
Problem - Probable Cause. Action

No pressure in spray system


√ Pump not running. Make sure hydraulic hoses are hooked up correctly. Verify that
impeller is turning.
√ Pump not primed. Turn on tank valve. Make sure the pump volute is flooded.
√ Pump impeller plugged. Remove volute and examine impeller for foreign material.
√ Tank suction port blocked. Examine and clean.
√ Throttling valve closed. Open valve at least partially open.
√ Rinse valve or chemical inductor valve not shut off and the respective tanks empty.

System pressure too low


√ Pump running too slowly. Check oil flow setting on tractor while spraying and needle
valve seating on pump motor.
√ Tank sparge on 100%. Partially close tank sparge valve.
√ Strainer plugged. Remove strainer bowl and clean.
√ Pressure regulating valve closed too far. Open throttling valve.
√ Tank spin rinse left on. Shut off spin rinse.

System pressure too high


√ Throttling valve opened too far. Partially close valve while spraying
√ Pressure regulating valve not adjusted properly. Refer to the owner’s manual for the
controller.
√ Pump running to fast Check hydraulic flow to pump.

Erratic pressure while spraying


√ Tank getting empty. Refill tank.
√ Pump suction plumbing leaking air. Tighten all clamps and fittings between pump suction
port and tank.

F1
Boom valves won’t turn on
√ Valved not hooked up to 12 volts. Valves require 12-volt power in addition to the signal
from the controller.
√ Fuse has blown. Check tractor fuse panel for blown fuse.
√ Wiring connection bad. Check all wiring connections.

Individual nozzles turning on and off erratically


√ Spray pressure too low for diaphragm checks installed. Increase pressure or install lower
PSI checks.
√ Diaphragm checks are getting packed with dirt. Remove and clean with clean water.
Check diaphragms and replace as necessary.

Pump will not pump liquid


√ Shaft is not turning. Check for corrosion between the impeller and the volute or in the
seal area.
√ Hydraulic oil is by-passing the gears and failing to turn the shaft. Refer to the instructions
in the pump manual to adjust the needle valve.
√ Pump is not primed. Refer to the pump manual for instructions on checking and priming
the pump.

Pump will not develop pressure


√ Restrictions in the plumbing. Check for clogged strainers, collapsed hoses, standard port
valves or undersized plumbing.
√ Insufficient shaft speed. Have your tractor dealer verify the gallons per minute of oil
going to the orbit motor. Also check the section titled “Regulating hydraulic flow to
the sprayer pump” in the pump operator’s manual.
√ Internal leakage in pump. Refer to the pump manual concerning seal replacement or
replacement of the impeller and/or volute.

Sprayer control fails to operate properly or flashes continuously.


√ Refer to Troubleshooting Guide in sprayer control operator’s manual.

F2
PARTS LISTING
1000 Gallon Frame and Tank Assembly

G1
1000 Gallon Frame and Tank Assembly
REF P/N DESCRIPTION QTY
1 69612 Tank, Assy. - FPII 1000 Gal. 1
2 62532 Fillwell w/Hinged Lid - 16" (HyTek) 1
62830 Gasket, Hinged Lid - 16" (HyTek) 1
62831 Gasket, Fillwell - 16" (HyTek) 1
3 69617 Tank, Eyewash 1000/1200 gal. Replacement w/lid 1
4 TLA-5T Tank Lid, 5” - Ace Tank 1
5A 60146 Valve, Fresh Water 1
5B 73807 Wment, Fresh Water Valve Mtg Bracket 1
STS14.34SS Screw, Self Tap TEK - 1/4 x 3/4 SS 2
5C A-34PP Barb, 3/4 mpt x 3/4 hb Polypro 1
5D HC-34 Clamp, Worm Gear - 3/4" Hose, 11/16"-1 1/4" S.S. 2
5E EPDM34 Hose, EPDM 3/4", 300psi, 31" Lg 1
5F EL-34PP Elbow, 3/4 mpt x 3/4 hb Polypro 1
6 71573 Strap, Tank Hold Down - 120" Nylon 2
7 73941 PLB 69613-Hoop, Tank - 1000 2
8 69553 Buckle, Tank Strap Hold Down 4
9 71702 Wment, Saddle - 1000/1200 2
10 73598 Wment, Frame - FPII 1000 1
11 72440 Plate, Tank Stop Front Top 1
12 72441 Flat, Tank Stop Wear Strip 2
13 72339 PLB 69739-Bracket, Valve Mounting - VSF200CF 1
14 VSF200CF Ball Valve, 2" Manifold x 2" Male Adapter 1
15 71889 Wment, Axle - FPII Narrow Track 1
74220 Wment, Axle - FPII Wide Track 1
16 SU34.6.6 U-Bolt, Sq. - 3/4NC x 6" x 6" x 1-3/4" Gr5 ZP 4
LN34 Nut, Lock - 3/4NC ZP 8
17 SU34.4.8 U-Bolt, Sq. - 3/4NC x 8" x 4" x 1-3/4" Gr5 ZP 2
LN34 Nut, Lock - 3/4NC ZP 8
18 B34.212 Bolt, 3/4NC x 2-1/2 Gr5 ZP 12
LW34 Washer, Lock - 3/4" ZP 12
N34 Nut, 3/4NC Gr5 ZP 12
19 74217 Wment, Spindle Mtg Strap - Wide Track 2
71887 Wment, Spindle Mtg Strap - Narrow Track 2
20 74218 Wment, Spindle - Wide Track 2
71888 Wment, Spindle - Narrow Track 2
21 73543 Wment, Tongue - FPII 750/1000 1
22 73592 Wment, Frame Support - FPII 1000 1
23 73542 PLB 61545-Bracket, Pump Mtg 1
24 73548 Wment, Hose Loop 1
25 69388 Hitch Assy, Cat 2 /w Clevis - Painted 1
69393 Hitch Kit, PPI237 Perfect Hitch Parts - Painted 1
69360 Clevis, Complete for Cat 2/3 Hitch - Painted 1

G2
REF P/N DESCRIPTION QTY
26 B34.6G8SP Bolt, 3/4NC x 6 Gr8 ZP (Special) 2
LW34 Washer, Lock - 3/4" ZP 2
N34 Nut, 3/4NC Gr5 ZP 2
27 B12.112 Bolt, 1/2NC x 1-1/2 Gr5 ZP 2
FW12 Washer, Flat - 1/2" ZP 2
LN12 Nut, Lock - 1/2NC ZP 2
28 B38.112 Bolt, 3/8NC x 1-1/2 Gr5 ZP 4
LW38 Washer, Lock - 3/8" ZP 4
N38 Nut, 3/8NC Gr5 ZP 4
29 B38.112 Bolt, 3/8NC x 1-1/2 Gr5 ZP 4
LN38 Nut, Lock - 3/8NC ZP 4
30 61551 Jack, Side Wind - 10", 2000lb, Black 1
31 73581 Wment, Platform 1
32 73580 Wment, Hand Rail - Long 1
33 73577 PLB 61548-Tube, Hand Rail - Short 1
34 73579 Wment, Ladder 2
35 71375 PLB 60116-Spring, Ladder 2
FW12 Washer, Flat - 1/2" ZP 2
CP532.134 Pin, Cotter - 5/32" x 1-3/4" 2
36 B12.112 Bolt, 1/2NC x 1-1/2 Gr5 ZP 4
FW12 Washer, Flat - 1/2" ZP 4
LN12 Nut, Lock - 1/2NC ZP 4
37 B12.1 Bolt, 1/2NC x 1 Gr5 ZP 8
FW12 Washer, Flat - 1/2" ZP 8
LN12 Nut, Lock - 1/2NC ZP 8
38 70536 Control Plumbing Kit - 3 x 460 Valves 1
39 SU12.4.3 U-Bolt, Sq. - 1/2NC x 3" x 4" Gr5 ZP 4
LW12 Washer, Lock - 1/2" ZP 8
N12 Nut, 1/2NC Gr5 ZP 8
40 69616 J-Bolt, 1/2"NC ZP - 1000/1200 Gal.Tank Hoop 4
FW12 Washer, Flat - 1/2" ZP 4
N12 Nut, 1/2NC Gr5 ZP 8
41 DEC-BW003 Decal, Bestway - 18"W x 4-1/2"T, Black 2
42 SW001 Decal, Warning - Read Manual 1
43 SW900 Decal, Danger - Toxic Chemicals 1
44 67672 Decal, Caution - Chemical Safety, 3" x 5" 1
45 67671 Decal, Warning - General Info, 5-1/2" x 6-5/8" 1
46 67657 Decal, Warning - Max Speed 25 MPH 1
47 67673 Decal, Caution - Do Not Drink, 3" x 5" 1
48 DEC-HAZ01 Decal, Warning - High Pressure Fluid 1
49 69210 Safety Chain, 3/8" x 50" - FPII 2

G3
REF P/N DESCRIPTION QTY
50 SU12.3.6 U-Bolt, Sq. - 1/2NC x 6" x 3" x 2" Gr5 ZP 2
LN12 Nut, Lock - 1/2NC ZP 4
51 B12.112 Bolt, 1/2NC x 1-1/2 Gr5 ZP 2
LN12 Nut, Lock - 1/2NC ZP 2
52 B38.5FT Bolt, 3/8NC x 5 ZP, Full Thread 4
FW38 Washer, Flat - 3/8" ZP 8
N38 Nut, 3/8NC Gr5 ZP 8
53 B14.34FSC Bolt, 1/4NC x 3/4, Flat Head Socket Cap 4
LN14 Nut, Lock - 1/4NC ZP 4
54 B12.112 Bolt, 1/2NC x 1-1/2 Gr5 ZP 2
LW12 Washer, Lock - 1/2" ZP 2
N12 Nut, 1/2NC Gr5 ZP 2
55 B38.114 Bolt, 3/8NC x 1-1/4 Gr5 ZP 16
FW38 Washer, Flat - 3/8" ZP 16
LW38 Washer, Lock - 3/8" ZP 16
N38 Nut, 3/8NC Gr5 ZP 8
56 69123 Tire, 12.4-38-8PlyBias /w 8 Bolt Wheel &
Sensor Holes 2
57 60012 Nut, Wheel - 5/8 16
58 DEC-S/N Plate, Serial Number - Brushed Aluminum /w Foam
Adhesive 1
59 DEC-HAZ09 Decal, Tire Pressures 2
60 60030 Manual Pak 1
61 B14.34 Bolt, 1/4NC x 3/4 4
FW14 Flat Washer, 1/4” 4
LN14 Lock Nut, 1/4NC 4
62 DEC-BW007 Decal, Bestway Logo 1
63 DEC-OM001 Decal, Operators Manual 1

G4
Base Plumbing Details

G5
Base Plumbing Details
REF P/N DESCRIPTION QTY
1 EL-200112PP Elbow, 2"mpt x 1-1/2"hb 2
2 EPDM112 Hose, EPDM 1-1/2", 300psi, 6" Lg 2
3 HC-112TB Clamp, T-Bolt - 1-1/2" Hose, S.S. 2
4 73728 Tube, Sparge - 1000/1200 1
5 MBF200 Bolted Tank Flange, 2" Manifold x 2"mpt, Polypro 2
6 150-G Gasket, 1-1/2" Coupler, EPDM 5
FC200 Clamp, 2" Manifold Fitting, (not shown) 5
7 M200PLG Plug, 2" Manifold, Polypro 1
8 M200125BRB Barb, 2" Manifold x 1-1/4"hb, Polypro 1
9 EPDM114 Hose, EPDM 1-1/4", 300psi, 42" Lg 1
10 HC-114TB Clamp, T-Bolt - 1-1/4" Hose, S.S 2
11 PH112 Hose, Plastic Helix 1-1/2", 66" Lg 1
12 PH200 Hose, Plastic Helix 2", 66" Lg 1
13 HC-200TB Clamp, T-Bolt - 2" Hose, S.S. 2
14 M200BRB Barb, 2" Manifold x 2"hb, Polypro 1
15 VSMT200CF Ball Valve, 2" Manifold x 2”mpt 2
16 M200BRB90 Elbow, 2" Manifold x 2" HB 1
17 BF205BD Bolted Tank Flange, 2" mpt 2
18 VC200 Cap, Vent/Anti-Vortex - 2" 1
19 VSF200CF Ball Valve, 2" Manifold x 2" Male Adapter 1
20 200-CAP Dust Cap, 2" Coupler 1
21 M200150BRB90 Elbow, 2" Manifold x 1-1/2"hb, Polypro 1
22 HC-138TB Clamp, T-Bolt - 1-1/2" Helix Hose, S.S. 4
23 M-2000PP Nipple, 2”mpt 1
24 TT-2000PP Tee, 2”fpt 1
25 F-2000PP Plug, 2”mpt 1
26 BF200 Bolted Tank Flange, 2" mpt 1

G6
X-Fold Boom Center Section

G7
X-Fold Boom Center Section
REF P/N DESCRIPTION QTY
1 73700 Wment, Outer - Xfold 1
2 73600 Wment, Inner - Xfold 1
3 73604 Wment, Frame - Xfold 1
4 73606 Wment, Slider - Xfold 2
72427 "Wear Strip - 24"" Lift 4
5 72428 Wment, Lift Tie Rod - Xfold 1
6 73611 Wment, Frame Brace Mnt - Xfold 2
7 73605 Bar, Brace - Xfold 2
8 SU12.6.312 U-Bolt, Sq.-1/2”NC x 3-1/2" x 6" Gr5 ZP 4
LW12 Washer, Lock - 1/2" ZP 8
N12 Nut, 1/2NC Gr5 ZP 8
9 B58.2 Bolt, 5/8NC x 2 Gr5 ZP 4
10 LN58 Nut, Lock - 5/8NC ZP 4
11 SU12.4.3 U-Bolt, Sq.-1/2”NC x 3" x 4" Gr5 ZP 6
LW12 Washer, Lock - 1/2" ZP 12
N12 Nut, 1/2NC Gr5 ZP 12
12 N34 Nut, 3/4NC Gr5 ZP 4
13 LN12 Nut, Lock - 1/2NC ZP 6
14 B38.34 Bolt, 3/8NC x 3/4 Gr5 ZP 4
15 71349 PLB 68399, Spring - Xfold 4
16 71354 Wment, Spring Tightener Stud - Xfold 4
17 N10 Nut, 1NC Gr5 ZP 8
18 71351 Wear Strip - Xfold 4
19 72487 Spacer, Outer - Xfold 4
20 71430 Spacer, Wear Strip 6
21 73609 Channel, Outer Bracket - Xfold 2
22 B12.6 Bolt, 1/2”NC x 6” Gr5 ZP 6
23 FW12 Washer, Flat - 1/2" ZP 6
24 73057 Wear Strip - Xfold 3
25 B14.34FSC Bolt, 1/4NC x 3/4, Flat Head Socket Cap 6
26 71206 Wment, Lower Brace - Xfold 1
27 69573 Zerk, Grease 1/4-28 threaded 1
61563 Decal, Instruction - Grease Daily 1
28 60986 Decal, Reflective - Red 2
29 60987 Decal, Reflective - Amber 2
30 DEC-S/N Plate, Serial Number - Brushed Alum./w Foam Adh. 1
31 71127 "Pin, 3/4"" Bent - Xfold Stow 1
HP#9 Pin, Hair - #9 1
32 DEC-HAZ02 Decal, Danger - Electrocution Hazard 4
36 69267 Plug, 1.75sq x 14-18ga. Black 10
37 61538 Plug, 1.75sq x 10-14ga. Black 8

G8
X-Fold Boom Inner Wing Detail

G9
X-Fold Boom Inner Wing Detail
REF P/N DESCRIPTION QTY
1 (see previous page) Center Section Assembly 1
2 73671 Wment, 1st Section Left - Xfold 1
73672 Wment, 1st Section Right - Xfold 1
3 73620 Wment, Wing Brace - Xfold 2
4 73689 Bar, Fold Link - Xfold 2
5 73687 Wment, Fold Yoke - Xfold 2
6 73623 Wment, Center Tip Bar - Xfold 1
7 73617 Wment, Cyl Lug - Xfold 2
8 61825 Cylinder, Hyd.- 2-1/2"Bore x 20"Stroke x 1-1/4"Rod 2
9 73650 PLB 61636, Spring - Xfold 4
10 61637 Cable, Assy. - 1/4"OD x 185-1/2"LG w/Ends 2
11 69133 Spring, Die - 2"OD x 1"ID x 4"LG 4
12 PIN1.612 Pin, 1" x 6-1/2" w/Hole 4
13 61824 Roller, Cable - Xfold Lower 1st Section 2
14 61824 Roller, Cable - Xfold Lower 1st Section 2
15 B34.6 Bolt, 3/4NC x 6 Gr5 ZP 2
16 B34.7 Bolt, 3/4NC x 7 Gr5 ZP 2
17 B34.6 Bolt, 3/4NC x 6 Gr5 ZP 4
18 SU56.2.4 U-Bolt, Sq. - 5/16”NC x 4" x 2" Gr5 ZP 3
19 CLP12.2 Pin, Clevis - 1/2" x 2" ZP 2
20 RP14.112 Pin, Roll - 1/4" x 1-1/2" 4
21 B12.212SP Bolt, 1/2”NC x 2-1/2” - Spec. 3/4” thread length 4
22 73832 Wment, Spring Tension Slider - Xfold 2
23 73835 Wment, Spring Tension Rod - Xfold 2
24 73829 Flat, Spring/Cable Mnt - Xfold 2
25 B12.112 Bolt, 1/2NC x 1-1/2 Gr5 ZP 2
26 69298 Cable, Assy. - 1/4"OD x 29-1/2"LG w/Ends 2
27 73851 Flat, SMV Mnt - Xfold 1
28 69290 Emblem, SMV 1

G10
X-Fold Boom Outer Wing Detail

G11
X-Fold Boom Outer Wing Detail
REF P/N DESCRIPTION QTY
1 73671 Wment, 1st Section Left - Xfold 1
73672 Wment, 1st Section Right - Xfold 1
2 73663 Wment, 2nd Section Left - Xfold50 1
73664 Wment, 2nd Section Right - Xfold50 1
73661 Wment, 2nd Section Left - Xfold60 1
73662 Wment, 2nd Section Right - Xfold60 1
3 73612 Wment, Mnt Bracket Left - Xfold 1
73613 Wment, Mnt Bracket Right - Xfold 1
4 60962 Decal, Warning - Overhead Hazard 2
5 73653 Wment, Stand Off - Xfold 2
6 69552 Roller, Cable - 3-1/2" UHMW 2
8 61637 Cable, Assy. - 1/4"OD x 185-1/2"LG w/Ends 2
9 PIN34.578 Pin, 3/4" x 6-1/2" w/Hole 2
10 AA392 PLB BS-16-Boom Spring - 16" 2
11 CLP34.7 Pin, Clevis - 3/4" x 7" ZP 4
12 RP14.112 Pin, Roll - 1/4" x 1-1/2" 2
13 B12.212SP Bolt, 1/2”NC x 2-1/2” - spec. 3/4” thread length 2
14 IB38.4 "Bolt, Eye - 3/8"NC x 4" ZP 2
15 SU38.112.212 U-Bolt, Sq. - 3/8”NC x 1-1/2" x 2-1/2" Gr5 ZP 4
16 FW34 Washer, Flat - 3/4" ZP 2
17 B12.3 Bolt, 1/2”NC x 3” Gr5 ZP 2
18 B12.3 Bolt, 1/2”NC x 3” Gr5 ZP 2
19 FW12 Washer, Flat - 1/2" ZP 8
20 61824 Roller, Cable - Xfold Lower 1st Section 2

G12
X-Fold Boom Hydraulic Detail

G13
X-Fold Boom Hydraulic Detail
REF P/N DESCRIPTION QTY
1 61626 Cylinder, Hyd. - 2" Bore x 30" Stroke x 1-1/8" Rod 1
203-425 Repair Kit, Chief Hyd. Cylinders-2"Bore x 1-1/8"Rod
2 61825 Cylinder, Hyd. - 2-1/2"Bore x 20"Stroke x 1-1/4"Rod 1
203-429 Repair Kit, Chief Hyd. Cylinders-2.5"Bore x 1-1/4"Rod
3 6MP-6FPS90 Adapter, Hyd. 90deg - 3/8"mpt x 3/8"fpsw 6
4 61682 Hose, Hyd. - 1/4" x 34", 3/8"mpt Both Ends 1
5 61683 Hose, Hyd. - 1/4" x 70", 3/8"mpt Both Ends 3
6 61684 Hose, Hyd. - 1/4" x 90", 3/8"mpt Both Ends 2
7 61685 Hose, Hyd. - 3/8" x 17ft, #8mpt x #6male o-ring 2
8 8FP-QM Adapter, Hyd. Quick Disconnet-Male Tip x 1/2"fpt 2
9 69685 Adapter, Hyd. - 6MB x 6FPS, Fasse Hyd. Block 6
10 61680 Valve, Hyd. Assy - Fasse 3 Function 1
69680 Control, Joystick - Fasse 3 Function 1
69681 Control, Foot-Pedal - Fasse 3 Funtion 1
*11 6MP-6FPS-R030 Adapter, Hyd. - 3/8"mpt x 3/8"fpsw, 0.030"restrictor 6
12 69266 Hydra Grip - One Pair, Red and Black 1

G14
X-Fold Boom
Plumbing Schematic

G15
X-Fold Boom Plumbing Schematic
REF P/N DESCRIPTION QTY
1 EPDM10 Hose, 1”EPDM x 35 feet 2
2 EPDM10 Hose, 1”EPDM x 18 feet 1
3 EPDM34 Hose, 3/4”EPDM x 24” 4
4 EPDM34 Hose, 3/4”EPDM x 48” 1
5 EPDM34 Hose, 3/4”EPDM x 19” 29
6 22252312750NYBV Nozzle Body, “T” 3/4”HB 31
7 22251311750NYBV Nozzle Body, “L” 3/4”HB 6
8 QJ111SQ114303SS Clamp, Nozzle Body - Square 1-1/4” S.S. 35
9 QJ111SQ112303SS Clamp, Nozzle Body - Square 1-1/2” S.S. 2
10 EL-3410PP Elbow, 3/4”MPT x 1”HB 3
11 T-3434F Barb Tee Ftg, 3/4”FPT x 3/4”HB 3

G16
*restrictors required only on units without dual opposing poppets in hydraulic block
Quick Fill Meter Kit
REF P/N DESCRIPTION QTY
1 71878 Mount Bracket, Flow Meter - Quick Fill 1
2 A-200 Barb, 2 mpt x 2 hb Polypro 2
3 B14.34 Bolt, 1/4NC x 3/4 Gr5 ZP 2
4 FW14 Washer, Flat - 1/4" ZP 4
5 LW14 Washer, Lock - 1/4" ZP 2
6 N14 Nut, 1/4NC Gr5 ZP 2
7 HC-200TB Clamp, T-Bolt - 2" Hose, S.S. 2
8 RE063-0171-066 Flow Meter - RFM-100 Poly, 3-100 GPM 1
9 RE063-0171-357 Flow Max 110 Monitor 1
10 RU14.1.134 U-Bolt, Rnd - 1/4NC x 1-3/4 x 1 2
11 FW14 Washer, Flat - 1/4" ZP 4
12 LW14 Washer, Lock - 1/4" ZP 4
13 N14 Nut, 1/4NC Gr5 ZP 4

G17
Wheel / Hub Assembly
REF P/N DESCRIPTION QTY
1 69123 Tire, 12.4-38-8PlyBias /w 8 Bolt Wheel & Sensor Holes 2
W38-05100 Rim Only, 12.4 x 38, 8 bolt 2
2 69145 Hub Assembly, W60-8 2
*3 ------- Hub, Studded w/Cups - W60-8 2
68176 Stud, 5/8 x 2-1/4 W60-8 Hub 16
69173 Bearing Cup, W60-8 inner 2
69171 Bearing Cup, W60-8 outer 2
*4 68178 Seal, W60-8 Hub 2
*5 68174 Bearing, Wheel - W60-8 Hub Inner 2
*6 68161 Bearing, Wheel - W60-8 Hub Outer 2
*7 68179 Cap, Dust - W60-8 Hub 2
*8 60012 Nut, Flanged Wheel - 5/8 16
9 69135 Spindle Assembly, W60-8 2
**10 68180 Spindle, 2.75” x 14” 2
**11 68181 Washer, Spindle - 1-1/16"ID x 2-1/8"OD x 1/4"T STL 2
**12 67425 Pin, Cotter - 3/16" x 2" ZP 2
**13 67424 Nut, Spindle - 1-8 HS STL 2

* indicates parts included in hub assembly (item 2)


** indicates parts included in spindle assembly (item 9)

G18
Outback Foam Guidance System, Model 6 or 10

G19
Outback Foam Guidance System, Model 6 or 10
REF P/N DESCRIPTION QTY
1 TLA-5T Tank Lid, 5" - 14,19,&25 gal. ACE Tanks 1
2 ACE003 Tank, 33 Gal Suitcase 1
3 AA719 Wment, 33gal Tank Stand 1
4 B12.3 Bolt, 1/2NC x 3 Gr5 ZP 4
5 FW12 Washer, Flat - 1/2" ZP 8
6 LN12 Nut, Lock - 1/2NC ZP 4
7 SU12.6.312 U-Bolt, Sq. - 1/2NC x 3-1/2" x 6" Gr5 ZP 5
8 LW12 Washer, Lock - 1/2" ZP 10
9 N12 Nut, 1/2NC Gr5 ZP 10
10 73760 Wment, 33gal Tank Mnt Bracket 2
11 AB331 Wment, Foam Guidance System Mnt Bracket 1
12 OBK-6 OUTBACK Premium Foam Guidance, Model 6 1
OBK-10 OUTBACK Premium Foam Guidance, Model 10 1
13 B56.1 Bolt, 5/16NC x 1 Gr5 ZP 4
14 FW56 Washer, Flat - 5/16" ZP 8
15 LN56 Nut, Lock - 5/16NC ZP 4
16 B56.3 Bolt, 5/16NC x 3 Gr5 ZP 2
17 LN56 Nut, Lock - 5/16NC ZP 2
18 AB367 Universal Foam Drop Coupler 2
19 AB366 Ribbon Foam Drop Assembly 2
20 AB365 Boot Drop Assembly 2
21 69551 SALAMANDER Foam Tube 2
22 HC-10 Clamp, Worm Gear - 1" Hose, S.S. 2
23 HC-34 Clamp, Worm Gear - 3/4" Hose, 11/16"-1 1/4" S.S. 6
24 EL-1238PP Elbow, 1/2 mpt x 3/8 hb Polypro 1
RB-3412PP Red. Bushing, 3/4mpt x 1/2fpt Polypro 1
25 73875R Wment, Foam Drop Mnt - Right 1
73875L Wment, Foam Drop Mnt - Left 1
26 B14.2 Bolt, 1/4NC x 2 Gr5 ZP 2
27 FW14 Washer, Flat - 1/4" ZP 4
28 LW14 Washer, Lock - 1/4" ZP 2
29 N14 Nut, 1/4NC Gr5 ZP 2
30 69267 Plug, 1.75sq x 14-18ga. Black 2
31 FP-324 Finish Plug, 2" x 14ga Sq Tubing 2

G20
9303C-HM1C Pump Kit

G21
9303C-HM1C Pump Kit
REF P/N DESCRIPTION QTY
1 9303C-HM1C Pump, Hyd. Centrifugal - 1 1/2"fpt x 1 1/4"fpt, Black 1
2 69826 Hose, Hyd. - 3/8" x 72", 1/2"mpt x 1/2"mpt Elbow 2
3 69266 Hydra Grip - One Pair (Red Grip) 1
4 69266 Hydra Grip - One Pair (Black Grip) 1
5 8FP-QM Adapter, Hyd. Quick Disconnet - Male Tip x 1/2"fpt 2
6 150-G Gasket, 1-1/2" Coupler, EPDM 1
7 FC200 Clamp, 2" Manifold Fitting (not shown) 1
8 B38.112 Bolt, 3/8NC x 1-1/2 Gr5 ZP 2
FW38 Washer, Flat - 3/8" ZP 2
LW38 Washer, Lock - 3/8" ZP 2
N38 Nut, 3/8NC Gr5 ZP 2
9 M200150MPTSS Ftg, 2" Flange x 1-1/2" mpt, 316 S.S. 1
10 M200125MPTSS Ftg, 2" Flange x 1-1/4" mpt, 316 S.S. 1
11 M200125BRB Ftg, 2" Manifold x 1-1/4" hb, Polypro 1

G22
Inductor Kit
REF P/N DESCRIPTION QTY
1 72395 Weldment, Inductor Mount Bracket 1
2 71894 Weldment, Upper Mount Arm 1
3 71895 Weldmnt, Lower Mount Arm 1
4 71891 Weldment, Inductor Tank Bracket 1
5 B12.1 Bolt, 1/2NC x 1” 6
LN12 Nut, Lock - 1/2NC Gr5 ZP 6
6 FW12NYL Washer, Nylon Flat - 1/2” 6
7 SU12.6.312 U-Bolt, 1/2NC x 3-1/2 x 6 2
LW12 Lock Washer, 1/2” ZP 4
N12 Nut, 1/2NC ZP 4

G23
Inductor Kit (continued)
REF P/N DESCRIPTION QTY
8 B12.6 Bolt, 1/2NC x 6” 1
LN12 Nut, Lock - 1/2NC Gr5 ZP 1
9 60043 Clip, Spring 1
10 MLP56.214 Pin, Wire Lock - 5/16” x 2 1/4” 1
11 ACE015 Tank, 15 gallon Inductor 1
TLA-12T Tank Lid, 12” Non-Vented 1
12 60042 Decal, Inductor Operation Instructions 1
13 71884 Weldment, Tank Strap - Inductor Mount 1
14 B38.3FT Bolt, 3/8NC x 3” Full Thread 2
FW38 Washer, Flat - 3/8” ZP 4
N38 Nut, 3/8NC 4
15 MBF200BD Bolted Tank Fitting 1
16 MVT200CF Ball Valve, 2” Manifold w/T-Handle 1
17 M200TEEV075 Tee, Venturi - 2” Manifold, Polypro 1
18 M200BRB90 Elbow, 2" Manifold x 2"hb, Polypro 2
19 M200TEE Tee - 2” Manifold, Polypro 1
20 M200125BRB Barb, 2" Manifold x 1-1/4"hb, Polypro 1
21 MV200CF Ball Valve, 2” Manifold 1
22 M200125BRB90 Elbow, 2" Manifold x 1-1/4"hb, Polypro 1
23 150-G Gasket, 1-1/2" Coupler, EPDM 10
FC200 Clamp, 2" Manifold Fitting, (not shown) 10
24 M200PLG-075 Plug, 2” Manifold x 3/4”fpt 1
25 M-3412PP Nipple, 3/4”mpt x 1/2”mpt 1
26 FCP-12 Ball Valve, 1/2”npt 1
27 A-1214 Barb, 1/2”mpt x 1/4”hb 1
28 HC-38M Hose Clamp, 3/8” Worm Gear 2
29 VR56 Hose, 5/16” Vinyl Reinforced x 60” long
30 A-14PP Barb, 1/4”mpt x 1/4”hb 1
31 22650-PP Trigger Jet, 1/4”npt 1
32 5500-PPB-12 Tip, Adjustable Conejet 1
33 EPDM114 Hose, EPDM 1-1/4"
34 HC-114TB Clamp, T-Bolt - 1-1/4" Hose, S.S. 2
35 PH200 Hose, Plastic Helix 2"
36 HC-200TB Clamp, T-Bolt - 2" Hose, S.S. 4
37 SE-200PP Street Elbow - 2”mpt x 2”fpt 1
38 AB519 Spring, Coil 1
39 FW12 Flat Washer, 1/2” ZP 2
40 CP532.134 Pin, Cotter, 5/32” x 1-3/4” ZP 2
41 VSMT200CF Ball Valve, Stubby - 2” Manifold x 2”mpt 1

G24
Rinse System Assembly

G25
Rinse System Assembly
REF P/N DESCRIPTION QTY
1 61809 Tank, 50 gallon PCO 1
2 TLA-5T Tank Lid - Ace Tanks (with Bestway Logo molded in) 1
3 71920 Tank Strap 2
4 69553 Tank Buckle 4
5 B38.5FT Bolt, 3/8NC x 5 Full Thread 4
FW38 Flat Washer, 3/8" 8
LW38 Lock Washer, 3/8" 4
N38 Nut, 3/8NC 8
6 71124 Wment, Tank Mount Bracket 1
7 SU12.6.312 SQ. U-Bolt, 1/2NC x 3 1/2 x 6 4
LW12 Lock Washer, 1/2" 8
N12 Nut, 1/2NC 8
8 61827 Rinse Diagrahm 1
9 M200125MPT Ftg, 2" Manifold x 1 1/4"mpt 1
10 150-G Gasket, Manifold Fitting 4
FC200 Clamp, 2" Manifold Fitting (not shown) 4
11 M200150BRB90 Elbow Ftg, 2" Manifold x 1 1/2hb 3
12 PH112 Helix Hose, 1-1/2" x 78" 1
13 HC-138TB Hose Clamp, 1 1/2" Helix Hose 4
14 A-112 Ftg, 1 1/2"mpt x 1 1/2"hb 2
15 NRV-112 Non Return Valve 1
16 MV150SLCF Ball Valve, 3 way, 1-1/2" 1
17 69267 Finish Plug 2
18 M200100CPG Red. Coupling, 2" Manifold x 1" Manifold 1
19 M100G Gasket, 1" Manifold Fitting 3
FC100 Clamp, 1" Manifold Fitting (not shown) 3
20 MV100CF Ball Valve, 1" Manifold 1
21 M200100CPG Elbow Ftg, 1" Manifold x 1" Manifold 1
22 M100075BRB90 Elbow Ftg, 1" Manifold x 3/4"hb 1
23 EPDM34 EPDM Hose, 3/4" x 216" 1
24 HC-34 Hose Clamp, 3/4" 2
25 EL-34PP Elbow Ftg, 3/4"mpt x 3/4"hb 1
26 RP-5032PE Tank Ftg, 3/4" Double Thread 1
27 M-34-6PP Nipple, 3/4" x 6" 1
28 27500E-34-18TEF Nozzle, Tank Wash 1

G26
Deluxe Plumbing Plate with 3 Valve Stack Assembly

G27
Deluxe Plumbing Plate with 3 Valve Stack Assembly
REF P/N DESCRIPTION QTY
1 HC-114TB Clamp, T-Bolt - 1-1/4" Hose, S.S 2
2 EPDM114 Hose, EPDM 1-1/4", 300psi 1
3 MLST150-50 Strainer, 2" Manifold, "T", 50 mesh 1
4 M200125BRB90 Elbow, 2" Manifold x 1-1/4" hb, Polypro 4
5 150-G Gasket, 1-1/2" Coupler, EPDM 12
FC200 Clamp, 2" Manifold Fitting, (not shown) 12
6 MV200CF Ball Valve, 2" Manifold 2
7 69423 Bracket, Valve Mount - V150 2
8 B14.34 Bolt, 1/4NC x 3/4 Gr5 ZP 6
9 FW14 Washer, Flat - 1/4" ZP 14
10 LN14 Nut, Lock - 1/4NC ZP 6
11 M200TEE Tee, 2" Manifold, Polypro 2
12 M200PLG Plug, 2" Manifold, Polypro 1
13 M200CPG Coupling, 2" Manifold, Polypro 2
14 75422 Wment, Valve Mount Plate 1
15 HC-114TB Clamp, T-Bolt - 1-1/4" Hose, S.S 2
16 EPDM114 Hose, EPDM 1-1/4", 300psi, 8"LG 1
17 RUB200 U-bolt, S.S. - Manifold Ftg Mount 1
18 M200100TEE Tee, 2” Manifold x 1" Manifold, Polypro 1
19 M100PLG-025 Plug, Modified - 1/4"fpt, 1" Manifold 1
20 ASG-1604 Gauge, 160# NH3, 4" 1
21 M200100CPG Reducing Coupling, 2" Manifold x 1" Manifold 1
22 M100G Gasket, 1" Manifold, EPDM 2
FC100 Clamp, 1" Manifold Fitting, (not shown) 2
23 463BEC-D Ball Valve Manifold (3) 460 Spraying Systems 1
461BEC-D Single Replacement Valve
50515-20DP Motor Drive
46070 Clamp & O-Ring Kit
7717-2/222-VI O-Ring
24 BM6.20 Bolt, 6m1.0x20 Gr8.8, YZ 4
25 LNM6 Nut, NyLock - 6m1.0 Gr8.8 YZ 4
26 60526 Spacer, U-bolt Mount 1
27 AB453 Control Valve Wiring - 3 Section Control 1

G28
ELECTRICAL WIRING
DETAILS

Field Pro II Wiring Diagram

H1
Field Pro II 1000 Wiring Diagram
REF P/N DESCRIPTION QTY
1 69691 Harness, Wire - Fasse Joystick Control 1
2 69684 Harness, Wire - Fasse Hyd. Block 1
3 69692 Harness, Extension - 17', Fasse 3 Function 1
4 AB363 Wiring Harness, Complete -OBK10 (AB474 & AB473) 1
AB474 Wiring Harness, Main Cable - OBK10 1
AB473 Wiring Harness, Replacement Battery Cable - OBK10 1
* AB383 Wiring Harness, Models 6 & RA 1
5 AB462 Wiring Extension, 10ft - OBK10 Power
6 EXT4/14X10 Wiring Extension, 10ft - 14ga x 4wire
7 AB371 Cab Control Box, OBK Markers 1
8 AB421 Wiring Harness, Battery Cable - 14ga x 12ft 1
9 61680 Valve, Hyd. Assy - Fasse 3 Function 1
10 69680 Control, Joystick - Fasse 3 Function 1
69681 Control, Foot-Pedal - Fasse 3 Funtion 1

*Outback 6 harness (AB383) does not include a power cable to the battery

H2
Field Pro II Wiring Diagram
for 3 Section Ball Valve
Plumbing

H3
Field Pro II 1000 Wiring Diagram (for 3 Section Ball Valve Plumbing)
REF P/N DESCRIPTION QTY
1 AB453 Control Valve Wiring - 3 Section Control 1
1A TS000 DIN Connector 3
1B AB455 Control Valve Wiring - Replacement Harness 3
1C 32902 Ring Connector, #10 x 12-10ga, Heat Shrink 2
37052 Male Tab, #10 - 1/4" Push On 2
31513 Female Spade, Blue Fully Insulated 1
1D 31903 Ring Connector, #10 x 16-14ga, Heat Shrink 3
37052 Male Tab, #10 - 1/4" Push On 3
1E 32902 Ring Connector, #10 x 12-10ga, Heat Shrink 2
37052 Male Tab, #10 - 1/4" Push On 2
31513 Female Spade, Blue Fully Insulated 1
1F 69363 Junction Box - Control Valve Wiring 1
2 AB458 Power Harness, Trailer End - Control Valve Wiring 1
3 AA858 Power Harness, Tractor End - Control Valve Wiring 1
4 RE063-0171-357 Flow Max 110 Monitor 1

H4

You might also like