You are on page 1of 2
Paper / Subject Cocle: TE1233 / 2)Radar System Engineering Te1233 Total No. of Printed Pages: ‘T.E. (ETC/ECE) (Semester-VP) (RC 2019-20) EXAMINATION JULY 2022 Radar System Engineering [Duration : Three Hours} [Total Marks :100] Instruction : 1. Assume suitable data wherever necessary 2. Attempt any two full questions from Part A, any two full questions from Part Band any one full question from Part C PART A 1. a) Derive the simple form of radar equation. What are the reasons for simple radar equation 6 does not predict the range performance of actual radar? 'b) Define radar cross section. What are the commonly employed swerling target fluctuation models and explain them with relevant expressions. 6 2 a) Derive the expression for probability of false alarm in terms of threshold to noise power 6 ratio b) A3 GHz radar system with unambiguous range 20 km uses a parabolic dish antenna of 6 aperture efficiency 0.55 and diameter 5 m. The system achieves a range resolution of 10 m. Find the gain of the radar’s antenna. Find the average power transmitted by the radar ifa 1 KW peak power is transmitted. If a target is detected at time delay 100 microsec, find the range to the target. ©) Obtain the frequency response of a single delay line canceller and sketch the same. Define 8 blind speed with reference to this frequency response. 3. a) Explain how FM- CW Radar with Triangular modulation can be used for range 7 ‘measurement 'b) With the help a neat block diagram explain the working of Non Coherent MTI Radar 7 system. Give its applications and limitations ©) Explain how staggered PRF helps in eliminating blind speed. What are the limitations of 6 this method? PART B 4. a) Bymeans of a Block diagram explain the working principle of amplitude comparison 7 monopulse tracking, b) With the help of block diagram explain two an, Radar. ©) By means of a sketch illustrate the low an, faced by it? Methods to reduce gle coordinate conical scanning tracking 7 igle tracking process. What are the problems 6 ‘ATN6FA609514287D67A72373BF6163E a) Paper / Subject Code: TE1233 / 2)Radar System Engineering Describe any two types of tracking Radar Deseribe the working principle and applications of Synthetic Aperture Radar With neat sketches, explain how tracking in range is performed using split gates. What is pulse compression? Draw the block diagram of Linear Pulse Compression Radar and explain its operation with the help of suitable wave forms. What are radomes? Explain in brief any two types of Radomes By means of an example, describe the basic principles of secondary surveillance Radar. PART C ‘xplain the concept of integration of Radar Pulses Write a short note on Pulse Repetition Frequency Explain how pulsed radar that extracts the Doppler frequency shifted echo signal. Describe the working principle of Phase Comparison Monopulse tracking With the help of neat sketches, explain Sequential lobing Write a short note on any 2 of the below: i) Bistatic Radar ii) Rotodomes iii) Multistatic Radar 7€1233, 5 5 2x5=10

You might also like