SS a
Fautts
Fault in OP logic card
OR REFERENCE VALUE FAULT
TO SIGMA [VOLTAGE TOO HIGH)
Fault in safety relay or lost loop
(Wite guidance oniy)
Fault in drive panel
Sigma OK signal missing
Fault in speed sensor
M INCORRECTLY ADJUSTED SENSOR
2/ ONE OF SENSORS OR CABLES
NOT FUNCTIONING.
sors oF
bistable reterence sensor
Aisle middle sensor stil on, outside aisle
{isle end braking function only)
Travel switeh jammed
Forwarditeverse in joystick
(SIGNAL FORWARO/REVERSE
AT THE SAME TIME}
Stooring servo gives incorrect signal
(Check power steering unit A3)
Fault in loop-tollowing
(Wire guidance only)
Deraitment in Joop aisie
(Check R3 or cables)
F
i(26/06/2006 «11:16 BT ESPANA > 0968694460
INTERLOCKS; (1 Hz, STOPS FUNCTION, RESET
AUTOMATICALLY ONCE INTERLOCK IS OK)
Gate not closed
Dead man’s handle held for a long time.
Left-hand character for I.h. handle, and
right-hand character for r.h. handle.
The left-hand character can also indicate
that the override button or that the
.h. dead man’s handle is not actuated "in aisle".
Spec.height sensor not active.
Over spec. height and override
button not actuated.
Maximum height sensor not active.
Lifting not permitted.
Low battery condition.
Interrupts cabin lift.
Slack chain monitor missing.
Slack chain!
Fault signal from Keltronics
Wire guidance
ed a
=