Professional Documents
Culture Documents
Halo Health Pack First Aid Kit
Halo Health Pack First Aid Kit
LY
N
O
EL
morleykert
VIEW IN BROWSER
Summary
Halo-inspired wall-mounted first aid kit!
Has room for a roll of medical tape, adhesive bandages, eye drops,
tweezers, gauze pads, alcohol pads and more!
Require two (2) 8x3mm magnets to form the closure. Cavities are
modeled, magnets just need to be glued in place.
Here is a link to the magnets that I used, but plenty of brands will work:
https://amzn.to/3ko5TVS (This is an affiliate link)
Printed in white Sunlu PLA at 20% infill, using the "0.15mm QUALITY"
preset in PrusaSlicer and auto-generated supports everywhere.
The little ridge that goes on the end of the tape hook is included as a
separate STL to avoid extra support material. I glued it in place with
superglue.
I printed the top and bottom pieces in their final orientation to get the best
surface finish possible, but this uses a lot of difficult-to-remove support
material for the top piece. I would recommend modelling your own
supports, playing with the settings in your slicer or trying a different
printing orientation.
I gave the mating surfaces a light sanding with 220 grit to ensure a nice
fit.
I've included the "hinge pin" STL, but I found it was too small to be printed
in PLA with sufficient strength. I ended up using a large sewing needle for
the hinge pin.
A tapered paint syringe and paper clip are perfect for applying the red
accent paint!
Model files
hinge-pin-first-aid-kit.stl
top-first-aid-kit.stl
bottom-first-aid-kit.stl
tape-ridge-first-aid-kit.stl
License
Attribution-NonCommercial