Professional Documents
Culture Documents
(First Revision )
(Page 13, clause 5.1.1.7) — Add the following new clause after 5.1.1.7:
'5.1.1.8 At the end of the text, the eye-protectors shall meet the following
mechanical and optical requirements:
a) The amount of diffused light shall not exceed the permissible limit
given in 5.1.1.3 by more than 25 percent.
(CHD 8)
IS : 5983 - 1980
Indian Standard
SPECIFICATION FOR EYE-PROTECTORS
(First Revision )
Glassware Sectional Committee, CDC 10
Chairman Representing
SIIRI K. D. SHARMA Central Glass and Ceramic Research Institute
(CSIR), Calcutta
Members
DR S. KUMAR (Alternate to
Shri K. D. Sharma)
SHRI P. N. AGARWAL Hindustan Safety Glass Works Ltd, Calcutta
SHRI P. K. AGAR~AL (Alternate)
SHRI C. G. AMIN Alembic Glass Industries Ltd, Vadodara
SHRI V. R. BHIDE Victorv Flask Co Pvt Ltd. Bombav
SHRI D. S. CHABHAL Directorate General of Technical Development,
New Delhi
SHRI I. K. K~pud (Alternate)
DR K. H. DAVE Haffkine Institute, Bombay
SIXRIP. S. CHAVAN (dlternate)
DEPUTY DIRECTORSTANDARDS(CAR- Ministry of Railways
RIAGE)-II, RDSO, LUCKNOW
SARI S. K. GUPTA J. G. Glass Industries Pvt Ltd, Pune
SARI A. B. KARANDIKAR (Alternate)
( Continued on page 2 )
(0 Copyright 1981
INDIAN STANDARDS INSTITUTION
This publication is protected under the Indim Copyright Act (XIV of 1957) and
reproduction in whole or in part by any means except with written permission of the
publisher shall be deemed to be an infringement of copyright under the said Act.
ISI ‘(uraq3) JovaJ!a Bndaa
2Tj ‘V I=%
ISI ‘(uraq(l)) Jo$m!a hdaa
LVMSWIVS 'd '3 I'aEIS
IS : 5983 - 1980
Indian Standard
SPECIFICATION FOR EYE-PROTECTORS
(First Revision)
0. FOREWORD
0.1 This Indian Standard (First Revision) was adopted by the Indian
Standards Institution on 30 November 1980, after the draft finalized by
the Glassware Sectional Committee had been approved by the Chemical
Division Council.
0.2 This standard was first published in 1971 under the title ‘Specification
for protective filters for welding, cutting and similar operations’. How-
ever, need was felt for revising the standard with a view to covering eye-
protectors for other operations also thus making it comprehensive.
Accordingly, the scope of this standard has now been enlarged to cover
eye-protectors for use in operations where small particles flying at high
velocity, molten metal, chemical splashes, dust, gases, optical radiations
(ultra-violet, infra-red and glare from intense visible light) pose hazards
which are likely to impair vision or damage the eye.
0.3 In this revision important aspects, such as designation of filters, classifi-
cation of eye-protectors and oculars on the basis of their types, constructions
and protection provided by them have been covered. General require-
ments applicable to all eye-protectors and specific requirements applicable
to eye-protectors ‘depending on the specific purpose for which they are used,
have also been prescribed. Transmission requirements have been pres-
cribed in respect of filters meant for use in flame-welding and braze-welding
of heavy metals, welding with emitive fluxes, oxygen cutting, plasma jet
thermal cutting, arc welding or arc gouging and direct arc welding in
addition to those meant for protection against ultra-violet and infra-red
radiations and intense daylight.
0.4 In the formulation of this standard due weightage has been given
to international coordination among the standards and practices prevailing
in different countries in addition to relating it to the practices in the field
in this country. This has been met by deriving assistance from the following
publications :
IS0 : 4849 Personal eye-protectors - Specifications.
IS0 : 4850 Personal eye-protectors for welding and related techniques -
Filters - Utilization and transmittance requirement.
IS0 : 485 1 Personal eye-protectors - Ultra-violet filters - Utilization
and transmittance requirements.
3
-uoti ‘a[q+ay 30
us passa.rdxa s! $1
ama;raafp JaMod
[[eys Mo[aq uanL.8
3d03S ‘I
*p~epuo~s s!y~ us an[eA paypads aq3 30 imp se ames ayl aq p[noys an[m
$0 papunos ay$ uf paurt?$al saaE[d vw~y@~s 30 laqumu ayL ‘*og6[-f, : SI
~JIM a3uepJome uf &o papunol aq [[~qs ‘s&[eua Jo Isal B 30 J[nsa;r aql
%!ssaldxa ‘paw[m[m JO pahlasqo ‘an[m [euy ay$ ‘~I!M par[_dtuo:, st p.wpuels
SO
IS : 5983 - 1980
2.16 Goggles -An eye-protector which fits the contour of the face to
enclose the optical area and is held in position by a head band.
2.17 Hood-A device covering the head and neck which includes eye
protection.
2.18 Impact Protector - An eye-protector able to provide safety against
impact of particles flying at high velocity.
5
IS : 5983 - 1980
nm
780
4beh T (4 V (4 d A
380 nm
l-v =
780 nm
+, x v (4 d h
I 380 nm
2.20 Meniscus - An ocular having two spherical surfaces of which one
is convex an&the other concave.
2.21 Molten Metal Protector - An eye-protector able to provide safety
against Hying molten metals or hot solids.
2.22 Ocular (or Lens) - That part of an eye-protector through which
an operator sees.
2.23 Prismatic Power - The apparent angular displacement of an object
by an optical system. It is expressed in ‘prism dioptres’.
NOTE - A prismatic effect can be produced by prismatic power in the ocular by the
position of the ocular relative to its correct visual axis or by a combination of these.
.N= 1+ ilogl0. f
V
where
Jv = shade number, and
TV = luminous transmittance (see 2.19).
2.28 Spectral Transmittance-The ratio of the transmitted spectral
radiant flux to that of the incident spectral radiant flux.
I(h) =&-
6
I!
maax3s ysaur ax!M (a
put2 %pIayys pueq pm am3 ‘salis (P
sue-dg:, hJa3tzs (3
‘sa~wg3ads haa3Es (4
‘sa~.So~ (e
NOILVNElIS3CI CTNV S3dAk '6
.saha aql JO
luoy ui sua~ luaxedsuexl
e 8uylexodxo3ur pm aze3 ayl30 lu0.13
II!
palxoddns
am& pzlaru uahoM 30 Bu?s!suo:, azyAap v - snaa.ms qsaw a.qM E-2
*UO!S!A30 play a.tixeI ‘I?Su~pxo~~ ‘a3z3 ayl 30 y~py IIn ayl xalzo pualxa
sawa xo suaI ay$ yafq~ IIF xowaloxd-aha uv - sa@SoD u?tsFA-apEM cgf;
*suogexado xy~u~!s xo
Ziuupltw %!u!pIaM Burxnp yaau arp30 ~110x3pue peayaxo3 ‘azw3 ‘saha ayl pIa!ys
03 xolexado ay3 hq U.IOM xol3a)oxd-aha p$x v - slauqaH .%qqaM z$‘t
.suopexado x~~!yis puz Bug~n:,
Qu!pjaM Burxnp y3au ayl30 )110x3 puv peayaxo3 ‘a3z3 ‘Saha ayl Suy3aloxd
x03 puny UT play aovaloxd-aha p!S$x v - pIafqs-pnaH Pqpla~ 1~2
.suo!ltczxado xe~~u~~spm Suyvm ‘Sknp~am Bufxnp partrrua suopa!pex In3tuxgy
JaaHax x0 qxosqe ‘xa)Ig ol pau+sap sali% -- saI8803 .SaFplaM ogt
mu 08L
YPYB
"UOOOZ
= WSL
UIU08L
YP k) _LYZ
"UOOOZ
:eInuUo3 .8u~Mo~~03aql Bulsn pm
fqruug mu 000 z pm UIU 08~ uaamaq ‘(v x!puaddV aas) uop~rpex
J$S 30 uognq!xw!p 1vx13ads ayl sysvq B se Bu!yv~ ‘uopexSamr hq
pauw~qo ST~1s~ ame~~!wsuex~ pax-ex3u: xe~os ayl sxaJIy w@ghEp xod (4
UnJ OOEI
YP w _L Of = zI1KL
um 000 z I
:av~nuno3 ay, liq pauyap axe samw!muex~ ayL
0861- C86S : SI
IS : 5983 - 1980
8
- - - - 91 (axx
- - - - - SI (4=
- - - PI (!!F
- - - - (!I*
- - - - - z: (I=
* -- - - -01-p
- A: (b
CX!X
- -- --1 -- (!!?X
5 (!I‘=
-- -- -f:; -
-- *DL W
1 L (AX
- - - L-+ - - *v9 (“!X
- - - - 9 (!!!X
- - - 9-ti - - *“G (!!X
- - c-%J 5-c - 5 (!X
- - - - - *3 (x
-
+-9 P-P P-E (X!
E-‘b E-E E (!!!A
-E-9 -;:; Jv5.pp - = - (!!A
SC9 S.Z‘S 53-P S.Z% (!A
- - &p; - 1 5; (A
Z-G Z-E - (A!
L.I% L.13 - 1.1 (I!!
A L.I-f
P.I-9 VI% VI-E %=.1-z %.I (!!
2.1-C ;:;I; Z.13 z.1-z z.1 6
2.1-g
(L) (9) (S) ($1 (E) (z) (1)
JaquIn&J, JaquJnN JaquInN JaqUJnN JaqurnN
aP=W aP=w aPew aPTS aPeys Quo
-9 JaqUInN -s JaqUInN -$ JaqUIIlN -~"q"nN -~Jaq""N JaquJnN
apo3 apo3 To3 apo3 apo3 aPays
7 - ’ u c---y- C-Y-J
SXKLlI~ S83J.71~ SI3&712
sas~md um7nva CI3~-v?IANI ~37oIA-vm7n t,NIa73hi ‘ON 7s
(1'7;'E PUV Z’E S~T3)
SX3XIId d0 SNOLZVNfXSBCI I 3’ISV.I.
0861- 686s : SI
IS : 5983 - 1980
DD - Datum Line
AA’ - Datum Length of Lens
M - Datum Centre (Mid-Point of AA’)
BB’ - Mid-Datum Depth of Lens (Measured Through M)
FIG. 1 DIMENSIONS
OF OCULARS
5.1.1.2 Optical requirements- In order to affect vision as little as
possible, the prismatic and spherical effects and astigmatism shall be as smal1
as possible.
10
IS : 5983 - 1980
(2)
11
IS : 5983 - 1980
of safety signs. Colour tint limits shall be established on the basis of ex-
perimental information obtained on filters under actual use conditions
and the chromatic adaptation of the human eye.
12
IS : 5983 - 1980
through its entire thickness into two or more pieces; or if more than 5
mg of the ocular material becomes detached from the surface remote from
that struck by the ball, or if the ball passes through the ocular.
b) Mounted oculars -- Mounted oculars shall withstand the impact of a
22 mm diameter steel ball, of about 44 g mass, dropped from a height
of I.27 to 1.30 m. The test shall be carried out in accordance with the
method given in 4.2 of IS : 7524 (Part I)-1980*. On so testing, the
following defects shall not occur:
13
-SL JO poyad B u!yl!~ Jnxo $0~
saop 11Eq ayl 30 uoyaxwuad ala@uo:, ‘+0861-(I 3xEd) $2~ : ~1 JO 11 ~I!M
a3uepxo33e us paw32 uayM ‘os[-e pue Ielaur ua31ow 30 a3uvxaqpr? ou SI
axaql ‘*0861-(I 1x”d) +ZIj’L : SI JO ()I UT paqyxwxd poylaUI ayl ‘il!M a3UB
-pxo~ze us pajsal uayM ‘Jr Xxo~~3s!las sz papx&ax aq 11~9s s~e!xal~ur aye
.rroyysod us xuIn3o ue Burp~oy 30 aIqvde:, xa8uoI ou
SF J! 3! xo sIxed IexaAas OJU! salexedas 1~3: pa[w3 ahey 03 paxaprsuo:,
aq Ip2ys awexf x0 Bu!snoy xuInD0 UE - a*n~,zv~aum.i...bo 2uUfsn?y .&30
puE i11eq sy-l dq
yanxls saylo? al!soddo ap!s ayl uo xaded a$rqM ay uo sxvadde yxeur
e 3~ pawxo3ap su paxapysuo9 aq Ipz’ys xeln20 UB - uoyxu.ioJap qn30
fxe1wo ay$ y%oxyJ sassed
IIvq ayl3~ x0 ‘1pzq ayl iiq y9nxzs leq~ troy ajourax aD_ejxns ayl urog
payz$ap auwJaq aka payeu aql 01 alqys!a saaayd axocu xo OM$ 3~
‘xalaurwp axriua s$f uo pue ssauyzyyl ax!lua SJ! y8noxy~ sy32?x3 lr 3:
paxtweg aAey 0~ paxapysuo9 aq II[E~S xvIn30 UB - a.mfm*J .qn90
%!MOIIO~ ay$ LzIdsyp IOU ~pzys xolDa$oxd-aiia a91 ‘aAoqe SE palsal UaqM
.ax[d y.ront nq~ UT puno~ asoqx 01
‘*0861-b Jxed) PZ5L : SI 30
.palsaw aq 11eys
.*0861-(I Ixed) +ZSL : SI Jo 2.8 *I
paq!xDsaxd poqJaur aye ylrlzz a%n?pxo~~ U! palsal uarlM porxad Isa2 ay?
Burxnp a@! lou op Lay3 Jo dxowe3spes se papxe9ax aq Ipzys @+ep 30
uoyenualw ayz x03 XlaIos spzuo!ssa3oxd liq pasn sxoJ3aloxd-a& (q
0861- E86S : SI
IS : 5983 - 1980
NOTE 2 .- As eye-pro ectors intended for protection against chemicals, dust and gas
are tested for resistance to penetration on a standard head-form, greatest care should
be taken to ensure a proper fit of the individual piece.
6. TESTS
6.1 Oculars - Oculars of eye-protectors shall be subjected to appropriate
tests listed in Table 4 and in the sequence described therein.
6.1.1 The tests shall be conducted on not less than 10 oculars of each
type, or 5 pairs of each type of oculars, and each ocular shall satisfy the
requirements of the relevant tests.
6.2.1 The tests shall be conducted on not less than 5 assembled eye-
protectors ofeach design or model and each protector shall satisfy the require-
ments of the relevant tests.
16
IS : 5983.1980
iv) Transmittance :
a) Non-filtering x X :-: 5.2.1.1(a)
b) Filtering - - X 5.2.1.1(b)
x = mandatory
0 = optional
17
TABLE 5 SCHEDULlji OF TESTS FOR EYE-PROTECTORS
(Clause 6.2)
USE OFEYE- OPTI- Row- HEAT CORRO- DISIN- TRANS- FLAF.IE HIGII MOLTEN Cmwc- DUST G.4S
PROTECTOR CAL STNRSS STARI- SION FEC- MITTANCR RESIS- VELO- METAL AL 5.2.2.5 AND
5.1.1.2 5.1.1.6 LITY 5.1.2.2 TION rA -7 TANCE CITY AN0 SPLASII- VAP-
5.1.2.1 5.1.2.3 5.2.1.1 5.2.1.1 5.2.2.1 IhlPACT HOT OURS
(4 (b) 5.2.2.2 SOLIDS 5.2EI.4 5.2.2.6
5.2.2.3
(1) (2) (3) (4) (5) @I (7) (8) (9) (10) (11) (12) (13) (14)
General x x :< :/ x X - X - - - - -
purpose
E Molten metal X 0 x x ?: x x x - - -
and hot solids
Dust X X X X X X - x - - ?< -
Gases and X 0 X X X x 0 X - - - X
vapours
Filtering action X 0 X X X - X x o - _ -
APPENDIX B
(Clause 5.2.1.1)
TRANSMITTANCE AND CHROMATICITY LIMITS OF FILTERS
AND GUIDANCE ON THEIR SELECTION AND USE
B-O. GENERAL
B-0.1 Transmittance requirements and limits of chromaticity have been
prescribed for filters for protection against harmful radiations. Information
useful in the selection and use of such filters has also been provided.
B-1.1.1 In addition, the filters shall also comply with the requirements
given below:
B-1.1.2 Sfiecial Filters for Flame- Welding with a Flux - When a flux is used
in flame-welding, the light emitted by the source is often very rich in mono-
chromatic light of one or more wavelengths, which makes it very difficult
to follow the work properly; for example, light from sodium and lithium
which is rich in radiations ofwavelengths 589 nm and 671 nm respectively.
21
TABLE 8 TRANSMITTANCE REQUIREMENTS FOR FILTERS USED IN WELDING ..
[Cln&B-I.1 a&B-1.3(b)]
8
DESIGNATION TRANSMITTANCE IN THE LUMINOUSTRANSMITTANCE MEAN TRANSMITTANCE IN THE 8
OF WELDING ULTRA-VIOLET (UV) (TV) INFRA-RED (IR) SPECTRUM ’
FILTERS SPECTRUM,
T (h) _---~-h-_~_~ _-w---_-_-h--.----~
r_---_--__ Percent. Percent, 1 300 (IR),
Near to 780TNtR
nm Mid 2(IR),
000 to
TX,,, ga
At 313 nm At 365 nm Max Mitt
percent, A&w percent, Mns perceni, Mnx 1 300 *ml
percent, Max
USE 10 15 20 30 40 GO 80 100 125 150 1 5 200 225 250 275 300 350 400 450 500
I I I
Covered elcc-
u-odes
(shielded
metal arc)
hiIG on heavy 12 I 13 14
metals*
MIG on light 12 I 13 14 15
alloys
N
cn
TIG on all 13 14
metals and
alloys
MAG [ 10 1 11 / 12 14 15
-2
13 I I
‘Arc-air’ 10 12 13 14 15
gouging -I 11 1 I I
*The expression ‘heavy metals’ applies to steels, alloy steels, copper and its alloys, etc.
NOTE 1 - Next higher or lower designation may be used, according to the conditions of use.
NOTE 2 - The symbol:
MIG - corresponds to the use of an arc operated by an inert gas: with an axial spray metal transfer;
TIG - corresponds to the use of a tungsten electrode arc protected by an inert gas;
MAG -- corresponds to the use of an arc protected by carbon dioxide either pure or in mixture, and electrode
arc protected by an inert gas; and
Arc-air - corresponds to the use of a carbon electrode and a compressed air jet urcd in gouging in order to
remove the molten metal.
LZ
Z.1 2% OS.0 E 000.0 S-E
Z-E S.8 L‘6.0 E 000.0 VE
8.LI 8.71 E 000.0 E-E
E I .6Z %,Y E 000.0 s+s
I .6Z I 33 %I E 000.0 2-E
Z%P I .8S ZZ E 000.0 L.I-E
paqrmaxd I .8S WL SE E ooo*o %.I-E
1oN *+A! 001 OS E 000.0 Z.I-E
I .8S P%L E.0 E 000.0 +I-Z
WL 001 G.0 E 000.0 Z*I-z
(9) (2) (P) (E) (z) ir)
WI
NOI.LVICIVl% L3’IOIA-V?IL.?fl .LSNIVtW NOLLD3LOXd
ZIOtI SlEK.LTIiI XOI SLN3EU3lXI~~3lI 33NVLLIE4ISNVlLL $1 3WIV.L
01 SE 0%FI
6 SI Oa 6
8 6 03 5T
L s 0% 5.z
9 S,ZOJ I
s I 0) dn
V
(z) (I)
DNlCI3M-32lVLD3lIIa X06
S83LL?Is d0 SNOI.LVN%S3a
: MOIaq ua@
smaura+nbaJ ayl y?~ d$uo:, oqe IIys s.wIy aql uoypp~ UI 1’1’2%
0861- E86E : SI
IS : 5983 - 1980
(Clause B-2.2)
2-1.2 Filters may change colour per- For use when total absorption of
ception. Appearance: verypale ultra-violet radiation is required
yellow
Z-1.4 Filters may change colour per- For use when some absorption of
ception. Appearance: pale visible light is required in addition
yellow to total absorption of ultra-violet
radiation
29
sz.0 01.0 S 800.0 EZO.0 01-P
6E-0 oz.0 EZO.0 190.0 6-P
89.0 EP.0 190.0 91.0 8-P
Z.1 18.0 91.0 W.0
L.1 fP.0 z.1 ;:;
g:; 71% z.1 Z% S-P
vs P.9 Z.E 5.8 VP
S.8 ZI S.8 6.LI E-P
OPOZ ozi- 6.LI 1.6Z "S.Z-+
6.LI 1.6Z 5.65
OZ.“3 oz.7 1.67; "Z-V
IZ 1.67;
ZG LE
EE t: 1.8G %.1-P
L6 P.PL Z.I-P
(cl bj. (El (I)
XDN 'zuaxad qq ‘maxad
"uOOE I O~OOOZ tnu 08LOl OOE I
F_L) (mN_L)
Pawwur PIVI PW?J~I J=aN
cI-_.---y---t----------J
IUlXLD3dS (81) aax sa3.L-q
-VXWI 3H.L NI XJNVLLIXWNVX~ d0 NOUVNOIS3a
0861- C86S : SI
-._ _--__ ._~_.------I___-.-- ..-.. ------
000.0 000.0 000.0 8L+98 08L
000.0 000.0 LOO.0 +I%18 OLL
000.0 900.0 &IO.0 69.Z9L 09L
000.0 900.0 810.0 EG%IL OSL
000.0 910.0 8EO.O EL.599 OPL
000.0 czo.0 I LO.0 66.619 OEL
000~0 L.bO.0 LEI.0 LC.PLS OZL
000.0 160.0 zsz.0 PE.IE!Y OIL
000.0 591 .o LSP.0 8L.68t 001,
000.0 ZOE.0 LE8.0 ~6+W 069
000.0 PLS.0 6LC.I EL.ZZP 089
000.0 C86.0 069.Z Z93LE OL9
000.0 SOL.1 019% ZZ.IX 099
000~0 0LI.L 69.806 OTT9
000~0 ;!$:g EOZ.01 90.8LZ ot9
000.0 EIP% ZZI%I ZE .6+Z OE9
POO.0 ‘Gq6.9 %LS.SI 6+ZZZ 029
500.0 IPI. 9ZZ.91 PS.LGI 019
110.0 610.6 281.51 9P.PL I 009
$10.0 ZO5.6 Z88.ZI IZ+FiI 06C
610.0 PE~~6 IPO.01 c;L*EEI 085
020.0 O’GO.6 5PZ.L PO.91 I OLS
ZEO.0 ZCI.8 IL8.P 00~001 09s
190.0 9L6.9 6’20% 8s%8 0%
IZI.0 189.q 6ZL.I 69.ZL OPS
ZIZ-0 9zs.v 168.0 9z.19 0%
8ZE.O 8L6.Z 592.0 61.1’; ozs
oss.0 LPL.1 ZEO.0 OP.ZP 01s
SLL.0 026.0 PIO.0 8L+E 00s
L LO-I 18P.O PLO.0 CZ.82 06+
z1s-1 8’GZ.O 8LI.O OL.ZZ 08fi
106.1 fEI.0 681.0 CO.81 OLP
PE6.1 OLO.0 LEE.0 PI.%1 09P
685.1 x0.0 ZOE.0 C6.01 OS*
961.1 910.0 8EZ.O 9’2.8 OPP
FIL-0 900.0 9%1 .o 8Z.9 OEP
9PZ.O zoo.0 150.0 s9.v OZf
LSO.0 000.0 ZIO.0 8E.E 01%
EIO.0 000.0 E00.0 1P.Z OOP
E00.0 000.0 100.0 89.1 06E
IOO*O 000.0 000.0 Cl.1 08E
(5) ($1 (E) (z) (I)
(Y )t( Y ls ( Y M-c Y 1s ( Y M Y 1s ( Yh T!
(X61) 313 3H.L UNV I 006 I XO.LVIUV?I ?‘Ifld V OL 3ALLV?~
- SlEUWd d0 S3&VNICllXOOD A.LI3LLVBUOXH3 UNV 33NV.LLIIU
‘SNVXJ. ‘IVXLD3dS 60 NOLLV‘U-l3?\r3 3H.L XOd S~OXWd LI 3’IBV.Z
0861- E86S : SI
(‘SpI BIqOJ IIf
‘qdumxa JOJ ‘~quassa $0~ SF a.@ w~~e8a
uonxqod axapt ea.m a%qel~osazmos WOJJ v’; .z-‘b
uo+apz~ pa.mqiturmake% uopaao;ld JO& vz-ti
OS1 z 01-P
000 z 6-+
008 I 8-P
OS9 I L-P
00s I 9-5
06s I 5-p
06Z I P-%
OIZ I E-P
OPI I S.Z_f
011 I Z-P
060 I L.I?
OLO I *.I-+
OS0 1 Z.I-P
(7;) (I)
3, ‘S3DXflOS 3XflJXXSdlu3~ W3JJIIJ
NV3JQ d0 SKX3~ NI NOUVDl?ddV TKIIdAJ a0 ?.IoIn-Ntxsaa
(E’E-8 aw3)
NOIJ.VICIVX CI3X-V‘LItINI .TSNIV%’
NOLL33,LOXd XOd SlI3XtId d0 NOUD3T3S 813W.VA
‘3 a3mos 313 atp
JO uopnqysyp Iewads ayl uo paseq aq IIeys (E ‘.%A aas) s.xa?Iy v@~Aep JOJ Saleufp~oo~
.+!J~XIIOJ~~ pue 61 aIq86 u! uMoqs se sanIeA aX_re~~!uIsu~.IJSnOUFny - I s&ON
Z% 5.43
‘iY.8 8.LI
(E) iz) (I)
?W TJJ
UIu OS!? w uIu EIE w
-_-y_--
(y)1 Jwlx.Load~
(&J) ~3-IOI~-“aL~~ SX331II~ d0
3H.L NI 33NVJJlIWNVX~ SNOIAVNtXS3a
u-muva NI 3sn
ZTI9 C8< 000 z
ZFI9 C8< 006 I
ZFI9 ‘i78< 008 I
ZFO9 C8< OOL I
Zf9S S8< 009 I
ZfOS ‘G8< 00s I
Zf!3 C8< OOP I
ZFOP C8< OOEI
Zf6E S8< 007; I
Z7=8E ‘G8< 001 I
1765 ‘G8< 000 I
t=m C8< 006
ZFG 09< 008
- 0%’ 08L
- 01’ 09L
- I> OPL
- 0 OZL
- 0 OOL
JuaSlad $Lmlad UIU
(E) (7;) (I)
3 w6 8 w!d
L-_._.-_-v----J
33NVLLIYVSNVlIJ, ‘lVliJ.33dS HL3N3?3AVM
(z WJN- ‘I'I'P-8~fq3)
RUi-IXL33dSa3v
-VlIdNI PIU NI 3DNVLLWSNVlI.L EBNIlIflSV3W XOd 3 CINV
3 SXiLLTId (JI’IOS 10 33NV.L.LIFUSh TVXJ.33dS OZ 313V.t
0861- 686S : SI
00&.0=X 06Z.O="
SEE.O"X 0+0=X OWO'X
OO&.O’C
~SlUO'Z!JOH
f$3go.o=C f8@).O’d
L%.O=X Lss.o=x
samnpmo3 a.*zua3 a~empJoo3 a.xlua3
f6IE.O=b
sn!pe;l tQ!M aqf
($1 (z)
ALI3I~vWO?m~
.Lv .LIWI’~ -IvJ.oJ_
0861- E86S : SI
~_..~-... -. - __._-_..__ -__.- -..- - .. ..-..--_-
SXOXKUOXd-3A3 if0 f.lNI?dEUVS
(I-8 2snW)
3 XICIN3ddV
auy-dep JOJ sa IBM SE ‘sap ~v!~wnpu~ .mpo pm sar.mmb iam.I8 pm
91eqzl ‘putzs U’ pasn aq In?3 I(aq ‘JaaeM pm? MOUS ‘S,X?O3 EKUOS ql!M se
axm3aga.z y8!yjo sam~ns rep wea axe aJay la*aalay,w mq ‘suo$aJ
pm!docqns pm Iydoq u! &msn ‘a.@uns asuaw! ~su@a uo!l3aioJd
S?9
S~FF
o.z-9
i 0%~
l@guns jo aauasqv ay2 u! f@nsn ‘a.n# wu~voPe uoywoJd ( 4:;:;
~$iguns fo axxasqa arl, u! XII~~JOU ca.re18 ~su$h2 uop3a*old %,I-‘;
a.xs@ o$ aag!suas hra.t suoslad dq asn snonuguo3 Z.I-9
( Z.I-S
(z) (1)
Sx3L71~
‘dOd SNOILVWIddV -IVOIdAJ, d0 SNOILVNfMS3a
(I ‘E’P-8 ~~v3)
U-IDITAVCI XOd SWLLWd d0 NOLLD3’3.3S ZZ 378V.L
0861, E86E : SI
8E
‘EZ 319% 30
g 103 u! ua@ Jaqrunu ame~dazmz BurpuodsaxJoD aylo~ pmba JO ueyz ssa~ sf
aIdures ayl uf pun03 saapaajap 30 laqumu ayl j! s$uauraqnbal asayl paysyss
alley 01 ‘pamaap aq Ipzys $01 ayL *aApDajap SB patma) aq Ipzys smaw
-al!nbal asay? 30 alow JO auo Xjsyes 02 Bugye aolaalold-aba hQ TIO~BXJ
-iDads ayl30 s)uatual!nbaJ pmydo pm pmo!suauup ‘pms!A a03 paurursxa aq
IIE~S ~2 alqeL 30 z 103 01 %~~.IOXX paqaalas slowalold-ah ayl 1IQ lop3
A.LItWIOdN03 ‘tIOd VIl?3U?I3 CINV S.LSB& 60 X38IWlN ‘t-3
*uo~.m3 yzma
tuog laqumu Imba Buyye~ Xq pawal aq ~pys slol2aloJd-alia 30 laqmnu
pa+nbal ayl pua pauado aq ~[vys suo~.re:, aql 30 luamad 0s Issal la ‘S.IOJ
-3alold-alia 30 Jaqumu ‘t! Suy~yuo~ SUOJ.WD30 syuo:, JOI ayl3I t’gl-3
‘*8961-CO6P : SI
u10;rj pry aq dmu amep!nS ‘uoy3aIasjo ssaumopuw ayl amsua 01 laplo uI
*mopuw )TZpal3aIas aq 11vys dIaw_mdas pagddns 3! s.ywo ayL I*);‘I-3
-B E OS a*09 Iy 10s
E Z 00s IS1
Z I 0”: OS1 “
I I EI OS 01 ilsfl
(f) (E) (z) (I)
ONLLS3L JIaqUmN
mkmnxsaa o~mnt?a~ ame~damv az!S qdmes .LO?
S3ILSIX3.LCWXVH~ 3H.L 80 I I 3HL NI SXOLD3LOXd
v
II383 ‘dOd SLS3.J d0 ‘ON SLN3M38In83~ ?VDI~dO -LX3 d0 X33KflN
(INV -IVNOISN3PJIa ‘?VIlSI~
d0 X33WlN 3’IBISSIBUlEfd UNV =INI%IEUVS d0 3TV3S EZ 3W?V.T,
086 I - %86S : SI