Professional Documents
Culture Documents
Electrician 1st Year NIMI MCQ Hindi
Electrician 1st Year NIMI MCQ Hindi
1 What is the name of the safety sign? | इस सरु क्षा 5 Which step of the 5s-concept refers
चिन्ह का नाम क्या है ? “Standardization”? | 5s-सींकल्पना में ननम्न में से कौन सा
िरण “Standardization” को इींचगत करता है?
A Step - 1 | प्रिम िरण
B Step - 2 | द्ववतीय िरण
C Step - 3 | तत
ृ ीय िरण
A Warning sign | िेतावनी चिन्ह D Step - 4 | िति
ु ि िरण
B Mandatory sign | आवश्यक चिन्ह
C Prohibition sign | ननषेधक चिन्ह 6 Which plier is used for making wire hooks and
loops? | कौन से प्लायर का उपयोग तार के हुक और लप
ू
D Information sign | सि
ू नात्मक चिन्ह
बनाने में होता है ?
2 What is smothering in extinguishing of fire? | अग्नन A Flat nose plier | फ्लैट नोज़ प्लायर
का शमन क्या है ? B Long nose plier | लॉन्ग नोज़ प्लायर
A Adding the fuel element to the fire | अग्नन में ईंधन C Round nose plier | राउीं ि नोज़ प्लायर
ममलाना D Diagonal cutting plier | िायगोनल कटटींग प्लायर
B Removing the fuel element from the fire | अग्नन से
7 What is the use of pincer? | वपींसर का क्या उपयोग है ?
ईंधन अलग करना
A Twisting the flexible wires | फ्लेग्क्सबल तार को
C Using of water to lower the temperature | जल का
ट्ववथट करना
उपयोग करके तापमान कम करना
B Cutting small diameter of wires | छोटे व्यास के तार
D Isolating the fire from the supply of oxygen | अग्नन
काटना
को ऑक्सीजन की आपनू ति से अलग करना
C Extracting the pin nails from the wood | लकड़ी में से
3 Which is the physical hazard? | ननम्न में से भौनतक वपन तिा कीलें ननकालना
हानन क्या है? D Holding small objects, where finger cannot reach |
छोटी वथतु पकड़ना, जहााँ ऊाँगली न पहुाँि सके
A Smoking | धूम्रपान
B Vibration | कम्पन
8 What is the name of road safety sign? | इस सड़क
C Corrosive | क्षरण
सरु क्षा चिन्ह का क्या नाम है ?
D Radio active | रे डियो सक्रियता
B Pull, Aim, Sweep, Squeeze | खीींिना, ननशाना लगाना, B Cautionary sign | सिेतक चिन्ह
घम Informatory sign | सि
ू नात्मक चिन्ह
ु ाना, दबाना
C
C Push, Arrange, Squeeze, Sweep | धकेलना, व्यवग्थित D Prohibition sign | ननषेधक चिन्ह
करना, दबाना, घम
ु ाना
D Push, Arrange, Sweep, Sequence | धकेलना,
व्यवग्थित करना, घम
ु ाना, अनि
ु म
9 What is the back-ground colour of warning signs in B Crane and slings | िेन और ग्थलींग
the basic category? | मल
ू श्रेणी में सिेतक चिन्ह के पश्ि C Layers and Rollers | लेयर और रोलसि
भाग का रीं ग क्या होता है ? D Machine moving platforms | मशीन िामलत प्लेटफामि
A Blue | नीला
B White | श्वेत
C Yellow | पीला 15 What is starving in extinguishing of fire? | आग
D Green | हरा बझ
ु ाने में थटावविंग क्या है ?
A Adding fuel to the fire | अग्नन में ईंधन ममलाना
10 Which type of fire extinguisher is used for fire on B Using water to cool the fire | अग्नन से ईंधन अलग
electrical equipment? | ववद्यत
ु उपकरण में लगी अग्नन हे तु करना
कौन सा अग्ननशामक प्रयोग क्रकया जाता है? C Removing fuel element from the fire | जल का
A Halon type | हे लॉन प्रकार उपयोग करके तापमान कम करना
B Foam type | झाग प्रकार D Preventing oxygen supply to the fire | अग्नन को
C Gas cartridge type | गैस कारतस
ू प्रकार ऑक्सीजन की आपनू ति से अलग करना
D Stored pressure type | सींग्रटहत दबाव प्रकार
11 Which is the waste disposal method that produces 16 What is the name of PPE? | पीपीई का नाम क्या है?
heat? | अपमशष्ट ननपटान ववचध कौन सी है , जो गमी पैदा
करती है ?
A Recycling | पन
ु िििण
B Composting | खाद िालना
C Incineration | भथमीकरण
D Waste compaction | अपमशष्ट सींघनन
क्रकस व्यग्क्तगत सरु क्षा उपकरण (पीपीई) का उपयोग क्रकया C Face shield | िेहरे का कवि
A Apron | एप्रन
17 Which disposal method of waste save lot of
B Goggles | िश्मा energy? | अपमशष्ट ननपटान ववचध कौन सी है , जो बहुत सारी
C Ear mask | कान कवि ऊजाि बिाती है ?
D Nose mask | नाक कवि A Land fill | जमीन में भरना
B Recycling | पन
ु िििण
13 What is the full form of BIS? | BIS का पण
ू ि रूप है
C Incineration | भथमीकरण
A Board of Indian Standard
B Bureau of Indian Standard D Composting | खाद िालना
C Board of International Standard
D Bureau of International Standard
18 Which artificial respiration method is to be 22 What is the name of the tool? | इस औजार का क्या
performed to the victim with injuries on the chest and
नाम है ?
belly? | क्रकस प्रकार की कृत्रिम श्वसन ववचध का प्रयोग उस
पीडड़त के मलए करते हैं, ग्जसकी छाती और पेट में िोट हो?
A Schafer’s method | शेफर ववचध
B Mouth to mouth method | मह
ुीं से मह
ुीं ववचध
C Mouth to nose method | मह
ुीं से नाक ववचध
D Nelson’s arm-lift back pressure method | नेल्सन की A Wire stripper | वायर ग्थिपर
भज
ु ा ऊपर पीछे दबाव ववचध B Crimping tool | क्रिग्म्पींग टूल
C Combination pliers | कॉग्म्बनेशन प्लायर
19 Which type of occupational health hazard is cause D Diagonal cutting pliers | िायगोनल कटटींग प्लायर
for infection? | क्रकस प्रकार के व्यावसानयक थवाथ्य खतरे के
कारण सींिमण हो सकता है? 23 What is the name of the safety sign? | इस सरु क्षा
A Electrical hazard | ववद्यत
ु ीय नक
ु सान चिन्ह का नाम क्या है ?
B Biological hazard | जैववक नक
ु सान
C Physiological hazard | शारीररक खतरा
D Psychological hazard | मानमसक नक
ु सान
A Gets pain in spinal guard | रीढ़ की हड्िी में ददि से लगे हुए भाग पर दबाव िालना
25 What immediate action should be taken to rescue और वह मर रहा हो, तो उसके मलए थवर्णिम घींटा कौन सा है ?
the victim, if he is still in contact with the electrical
A First 15 minutes | पहले 15 ममनट
power supply? | पीडड़त को बिाने हे तु क्या तात्कामलक कदम
B First 30 minutes | पहले 30 ममनट
उठाना िाटहए, यटद वह अभी भी ववद्यत
ु शग्क्त थिोत से सींपकि
C First 45 minutes | पहले 45 ममनट
में है ?
D First 60 minutes | पहले 60 ममनट
A Pull or push him from the contact by hand | हाींिों
द्वारा खीींिें या धक्का दें 28 Which condition of the victim is referred as COMA
B Inform your authority about this electric shock | stage? | पीडड़त की कौन सी ग्थिनत को कोमा कहा जाता है ?
अपने प्राचधकारी ववद्यत ु झटके के बारे में जानकारी दें A Unconscious but can respond to calls | बेहोश रहना
C Call someone for helping to remove him from
पर बल
ु ाने पर उत्तर दे ना
contact | क्रकसी को उस व्यग्क्त को छुड़ाने हे तु बल
ु ाएाँ
B Conscious but cannot respond to calls | होश में रहना
D Break the contact by switching OFF the power
supply | सींयोजको को अलग करके शग्क्त आपनू ति को बींद करदें पर बल
ु ाने पर उत्तर न दे ना
C Breathing but cannot respond to calls | साींस लेना पर
26 What is the name of the cautionary sign? | इस बल ु ाने पर उत्तर न दे ना
सिेतक चिन्ह का नाम क्या है? D Lie totally senseless and do not respond to calls |
परू ी तरह सींवेदनहीन होकर लेटे रहना एवीं बल
ु ाने पर उत्तर न
दे ना
Answers:
1-D|2-D|3-B|4-A|5-D|6-C|7-C|8-A|
9 - C | 10 - A | 11 - C | 12 - D | 13 - B | 14 - B | 15 - C |
16 - D | 17 - B | 18 - D | 19 - B | 20 - C | 21 - D | 22 - D |
23 - D | 24 - D | 25 - D | 26 - D | 27 - B | 28 - D |
A School | ववद्यालय
B Guarded | सींरक्षक्षत
C Unguarded | असींरक्षक्षत
D Pedestrian crossing | पैदल िामसींग
A Rasp cut file | राथप कट रे ती 6 Which type of stake is used for sharp bends in
B Single cut file | एकल कट रे ती sheet metal? | शीट मेटल में तेज़ मोड़ों हे तु क्रकस प्रकार
C Double cut file | दोहरी कट रे ती का थटे क उपयोग क्रकया जाता है ?
D Curved cut file | विाकार कट रे ती A Square stake | वगािकार थटे क
B Hatchet stake | है िट
े थटे क
3 What is the name of the tool? | इस औजार का
C Blow horn stake | ब्लो हॉनि थटे क
क्या नाम है ?
D Bevel edge square stake | बेवल एज वगािकार
थटे क
7 Which type of cold chisel is used for squaring 10 What is the name of the stake used for
materials at the corners? | क्रकस प्रकार की ठीं िी छे नी general purpose in sheet metal work? | शीट मेटल में
का उपयोग क्रकनारों पर पदािों को वगािकार करने हे तु सामान्य उपयोग हे तु क्रकस प्रकार का थटे क उपयोग क्रकया
क्रकया जाता है ? जाता है ?
A Web chisel | जाली छे नी A Square stake | वगािकार थटे क
B Cross cut chisel | िॉस कट छे नी B Hatchet stake | है िट
े थटे क
C Half round chisel | अधि वत्ृ ताकार छे नी C Blow horn square stake | ब्लो हॉनि थटे क
D Diamond point chisel | हीरा पॉइींट छे नी D Bevel edge square stake | बेवल एज वगािकार
थटे क
8 Which type of calliper is used to draw parallel
lines along the outer edges of the materials? | क्रकस 11 What is the number 1.25 indicates in ISO
प्रकार के कैलीपर का प्रयोग पदािि के बाहरी मसरों पर metric fine thread M12 x 1.25? | आईएसओ मेटिक
समान्तर रे खाएीं खीींिने में होता है ? फाइन थ्रेि M12 x 1.25 में 1.25 नींबर क्या इींचगत करता
है ?
A Inside calliper | आतींररक कैलीपर
A Diametric of the thread | थ्रेि का व्यास
B Jenny calliper | जेनी कैलीपर
B Pitch of the thread | थ्रेि का वपि
C Outside calliper | बाह्य कैलीपर
C Depth of the thread | थ्रेि की गहराई
D Spring joint calliper | ग्थप्रींग जोड़ कैलीपर
D Length of the thread | थ्रेि की लम्बाई
9 What is the name of the drill bit? | इस डड्रल त्रबट 12 What defect will occur in timber due to
irregularity in growth of the branches? | लकड़ी में
का क्या नाम है ?
अननयममत रूप से शाखाओीं के उगने के कारण कौन सा
दोष उत्पन्न होता है ?
A Knot | गााँठ
B Cupping | कवपींग
C Cracking | िटकना
D Twisting | घम
ु ाना
B Taper shank bit | टे पर शैंक त्रबट तेज करने के मलए क्रकस रे ती का उपयोग क्रकया जाता है ?
D Straight shank bit | थिे ट शैंक त्रबट B Round file | वत्ृ ताकार रे ती
C Triangular file | त्रिभज
ु ाकार रे ती
D Half round file | अधि वत्ृ ताकार रे ती
14 Name the part marked ‘X’ of the file. | "X" से 17 What is the use of firmer chisel? | फमिर छे नी
इींचगत रे ती के भाग का नाम बताइए- का क्या उपयोग है?
A Paring and finishing joints | छीलने और जोड़ों की
क्रफननमशींग में
B General chiselling work | सामान्य छे नीकरण
कायि
A Edge | एज
C Making rectangular holes in wood | लकड़ी में
B Heel | हील
आयताकार छे द बनाना
C Tang | टैंग
D Light chiselling and to clean sharp corner |
D Shoulder | शोल्िर
लकड़ी में हल्का छे नीकरण तिा तेज़ क्रकनारों की सफाई
15 What is the name of the tool? | इस औजार का 18 Which type of half lap joint is used if one part
क्या नाम है ? of a job meets another part at some distance from
the ends? | क्रकस प्रकार का अधि लैप जोड़ प्रयोग क्रकया
जाता है , जब जॉब का एक भाग मसरों के अींत से कुछ दरू ी से
ममलता है ?
A End-lap input | एींि-लैप जोड़
B Cross-lap joint | िॉस-लैप जोड़
C Middle-lap joint | मध्य-लैप जोड़
A Jenny calliper | जेनी कैलीपर
D Corner-half lap joint | कोना-अधि लैप जोड़
B Inside calliper | आतींररक कैलीपर
C Outside calliper | बाह्य कैलीपर 19 Which type of notch is used for making a
D Firm joint calliper | फमि जोड़ कैलीपर metal tray with 90° bend and an inside flange? | 90
° मोड़ और अींदर से ननकले हुए क्रकनारे के साि धातु िे
16 What is the name of the angle marked ‘X’ of बनाने के मलए क्रकस प्रकार के नॉि का उपयोग क्रकया जाता
the chisel? | छे नी में "X" द्वारा प्रदमशित कोण का नाम है ?
क्या है ? A ‘V’ notch | V नॉि
B Slant notch | नतरछा नॉि
C Square notch | वगािकार नॉि
D Straight notch | सीधा नॉि
20 What is the purpose of hem folding in sheet 24 What is the name of the formation of thread
metal work? | शीट मेटल कायि में हे म फोग्ल्िींग का क्या marked as X in the galvanized sheet pipe joint? |
उद्देश्य है ? जथती शीट पाइप जोड़ में X के रूप में चिग्ह्नत थ्रेि के का
A Helps for forming a square box | वगािकार डिब्बे नाम क्या है ?
को बनाने में सहायक
B Helps for bending sheet metal easily | शीट
मेटल को सरलता से मोड़ने में सहायक
C Prevents burrs forming after cutting | काटने के
बाद खरु दरु े क्रकनारे बनने से रोकता है
D Prevents the sheet from damage | शीट को क्षनत
A Hemp | जट
ू
से बिाना
B Full form thread | फुल फॉमि थ्रेि
21 Which defect in the timber is caused to C Tapered male thread | नतरछी मेल थ्रेि
reduce its strength? | लकड़ी में कौन सा दोष इसकी
D Parallel female thread | समान्तर फीमेल थ्रेि
शग्क्त को कम करता है?
A Twisting | घम
ु ाना
B Cupping | कवपींग 25 Which type of notch is used for bending the
C Cracking | िटकना edge of the sheet? | शीट के मसरों को मोड़ने हे तु क्रकस
D Irregularity | अननयममतता प्रकार की नॉि का प्रयोग क्रकया जाता है ?
27 Which type of notch is used to make a job B Tack hammer | टै क्स हिौड़ा
with 90° bend? | 90O मोड़ने हे तु क्रकस प्रकार का नॉि C Cross pein hammer | िॉस पीन हिौड़ा
प्रयोग होता है ? D Straight pein hammer | थिे ट पीन हिौड़ा
A ‘V’ notch | V नॉि
B Slant notch | नतरछा नॉि
C Square notch | वगािकार नॉि 31 Which type of chisel is used for separating
D Straight notch | सीधा नॉि metals after chain drilling? | िेन डड्रमलींग के बाद
धातओ
ु ीं को अलग करने हे तु क्रकस प्रकार की छे नी का
28 Which type of curve cutting hand saw is used प्रयोग क्रकया जाता है ?
for internal cutting in wood? | लकड़ी की आतींररक
A Flat chisel | िपटी छे नी
कटटींग के मलए क्रकस प्रकार की वि कटटींग दथती आरी
B Web chisel | जालीदार छे नी
प्रयोग की जाती है ?
C Cross cut chisel | िॉस कट छे नी
A Compass saw | कम्पास आरी
D Diamond point chisel | हीरा पॉइींट छे नी
B Key hole saw | की होल आरी
C Coping saw | कोवपींग आरी 32 Which type of stake is used for riveting or
D Fret saw | फ्रेट आरी seaming tapered cone shaped articles? | क्रकस प्रकार
की थटे क का उपयोग टे वपींग शींकु के आकार के लेखों को
29 What is the name of the stake used for sheet ररवेटटींग या सीममींग करने के मलए क्रकया जाता है ?
metal work? | शीट मेटल कायि के मलए उपयोग होने वाले
A Square stake | वगािकार थटे क
थटे क का क्या नाम है ?
B Hatchet stake | है िट
े थटे क
C Blow horn stake | ब्लो हॉनि थटे क
D Bevel edged square stake | बेवल एज वगािकार
थटे क
A Square stake | वगािकार थटे क 33 Which causes knot defect in timbers? | लकड़ी
B Hatchet stake | है िट
े थटे क में गााँठ दोष का क्या कारण है ?
C Blow-horn stake | ब्लो हॉनि थटे क A Defective storage | दोषपण
ू ि भण्िारण
D Bevel-edge square stake | बेवल एज वगािकार B Uneven shrinkage | असमान मसकुड़ना
थटे क C Growth of branches | शाखाओीं की ववृ द्ध
D Improper seasoning | गलत सीज़ननींग
30 What is the name of tool? | औजार का क्या
नाम है ? Answers:
1-A|2-A|3-B|4-B|5-B|6-B|7-D|8-B
| 9 - B | 10 - A | 11 - B | 12 - A | 13 - C | 14 - B |
15 - A | 16 - B | 17 - B | 18 - C | 19 - A | 20 - D |
21 - D | 22 - A | 23 - D | 25 - D | 26 - A | 27 - A |
28 - B | 29 - C | 30 - B | 31 - B | 32 - C | 33 - C |
1 What is the current carrying capacity of 32 5 Which method of soldering is used for quantity
amp. rated cable, if it is protected by the rewireable production and for tinning work? | मािा उत्पादन
fuse? | 32 एग्म्पयर रे टेि केबल की धारा वहन क्षमता और टटननींग कायि हे तु कौन सी सोल्िररींग ववचध का प्रयोग
क्या होगी, यटद इस पन
ु ः तार बााँधने योनय फ्यज
ू से क्रकया जाता है ?
सरु क्षक्षत क्रकया गया हो? A Dip soldering | डिप सोल्िररींग
A 13 Amp
B Soldering with a flame | ज्वाला के साि सोल्िररींग
B 16 Amp
C 26 Amp C Soldering with soldering iron | सोल्िररींग आयरन
D 39 Amp के साि सोल्िररींग
2 What is the possible range to measure the size D Soldering with soldering gun | सोल्िररींग गन के
of the wire in a Standard Wire Gauge (SWG)? | SWG साि सोल्िररींग
से तार का आकार मापने की परस क्या है ?
A 0-44 6 What is the name of the part marked as X in
B 0-42 the underground (UG) cable? | इस भमू मगत केबल में
C 0-38
X से इींचगत भाग का नाम बताइए|
D 0-36
A Bedding | बेडिींग
B Armouring | आमिररींग
C Lead sheath | लेि शीि
D Paper insulation | कागज़ कुिालक
A Aerial tap joint | एररएल टै प जोड़
B Knotted tap joint | नॉटे ि टै प जोड़ 7 What is the full form of XLPE Cable? | XLPE का
C Duplex cross tap joint | िुप्लेक्स िॉस टै प जोड़ पण
ू ि रूप है
D Double cross tap joint | िबल िॉस टै प जोड़ A Cross Line Poly Ethylene
B X’ess Line Phase Earthing
4 Which type of soldering flux is used for C Cross Linked Poly Ethylene
D Excess Length Paper and Ebonite
soldering galvanised iron? | गैल्वेनीकृत लोहे के मलए
क्रकस प्रकार के सोल्िररींग फ्लक्स का उपयोग क्रकया जाता 8 What is the purpose of ‘serving’ layer in
है ? underground cable? | भमू मगत केबल में सवविंग परत
A Rosin | रोग्जन का क्या उपयोग है?
B Zinc chloride | जथता क्लोराइि A Protect the cable from moisture | केबल को नमी
C Sal ammonia | साल अमोननया से बिाना
D Hydrochloric acid | हाइड्रोक्लोररक अम्ल B Protect the cable from mechanical injury |
केबल को याींत्रिक क्षनत से बिाना
C Protect metallic sheath against corrosion |
धाग्त्वक कवि को क्षरण से बिाना
D Protect armouring from atmospheric condition
| आमिररींग को वायम
ु ि
ीं लीय ग्थिनत से बिाना 13 What is the unit of insulation resistance? |
कुिालक प्रनतरोध की इकाई है -
9 Which type of fault of U.G Cable can be located A Ohm | ओह्म
by this loop test? | लप
ू टे थट में भमू मगत केबल के क्रकस B Kilo ohm | क्रकलो ओह्म
प्रकार के दोष के थिान को ज्ञात क्रकया जा सकता है ? C Milli ohm | ममली ओह्म
D Mega ohm | मेगा ओह्म
17 What is the effect on molten solder due to 20 What is the name of the part marked X in UG
repeated melting? | वपघले हुए सोल्िर को बार-बार cables? | इस भमू मगत केबल में X से इींचगत भाग का नाम
वपघलाने से क्या प्रभाव पड़ता है ? बताइए|
A Tin content reduced | टटन का भाग कम हो जाता
है
B Lead content reduced | सीसे का भाग कम हो
जाता है
C Prevent slug formation | थलग को बनने से रोक
दे ता है A Serving | सवविंग
B To control the excessive heat | अनतररक्त ऊष्मा B Soldering with a flame | ज्वाला के साि सोल्िररींग
33 What does the number 1.40 represent if a 37 What is the name of the tool? | इस औजार का
stranded conductor is designated as 7/1.40? | यटद क्या नाम है ?
एक हुए िालक को 7/1.40 से इींचगत क्रकया जाता है , तो
1.40 क्या दशािता है ?
A Area of cross section | अनप्र
ु थि काट का क्षेिफल
B Radius of one conductor | एक िालक की त्रिज्या
C Diameter of all conductor | सभी िालकों का
व्यास A Cutting plier | कटटींग प्लायर
D Diameter of each conductor | प्रत्येक िालक का B Wire stripper | वायर ग्थिपर
C Crimping tool | क्रिग्म्पींग टूल
D Side cutting plier | साइि कटटींग प्लायर 43 What is the unit for Quantity of electricity? |
त्रबजली की मािा के मलए इकाई क्या है ?
39 What is the reading of the micrometer? | A Mho | म्हो
माइिोमीटर का पाठयाींक क्या है ? B Coulomb | कूलाम
C Volt /second | वोल्ट/सेकींि
D Ampere/second | एग्म्पयर/सेकींि
A 5.05 mm
B 5.00 mm
C 4.55 mm
D 4.05 mm
42 What is the current capacity of the 16 Amp. 46 What is the current rating factor for close
Cable, if it is protected by coarse excess current excess current protection of cable? | केबल की पास
protection? | 16 A केबल की धारा क्षमता क्या है , यटद की अनतररक्त धारा सरु क्षा के मलए धारा रे टटींग कारक क्या
यह अचधक अनतररक्त धारा सरु क्षा द्वारा सींरक्षक्षत है ? है ?
A 11 A A 0.81
B 13 A B 0.92
C 15 A C 1.23
D 18 A D 1.5
48 What is the name of the soldering method? | 51 Which is the example for coarse excess
सोल्िररींग ववचध का क्या नाम है ? current protection? | अचधक अनतररक्त धारा सरु क्षा
हे तु क्या उदाहरण है ?
A MCB
B MCCB
C H.R.C fuses | H.R.C फ्यज
ू
D Rewireable type fuse unit | पन
ु ः तार बााँधने
योनय फ्यज
ू इकाई
1 How many electrons are there in the third cell 5 What is the value of hot resistance of a bulb
of the copper atom? | ताींबे के परमाणु के तीसरे कक्ष में rated as 100W/250V? | 100W/250V से रे टेि बल्ब के
क्रकतने इलेक्िान होते हैं? गमि प्रनतरोध का मान क्या होगा?
A 8 A 31.25 ohm
B 13 B 62.50 ohm
C 18 C 312.50 ohm
D 29 D 625.00 ohm
2 Which is the semiconductor material? | 6 Which law states that in closed electric circuit,
अधििालक पदािि कौन सा है ? the applied voltage is equal to the sum of the
A Eureka | यरू े का voltage drops? | कौन सा ननयम कहता है , क्रक बींद
A 23 x 103 W ± 5%
A Indicate zero reading | शन्
ू य पाठयाींक पर सींकेत B 26 x 103 W ± 10%
C 32 x 104 W ± 10%
B Indicate infinite resistance | अनींत पाठयाींक पर D 37 x 104 W ± 5%
सींकेत
C Total resistance value of the circuit | पररपि का 13 Why the ohmmeter is graduated with non-
linear scale?| ओह्ममीटर को अरे खीय िम में क्यों
कुल प्रनतरोध मान
समींग्जत क्रकया जा सकता है?
D Value of sum of the resistance of R1 and R3
only | R1 और R3 प्रनतरोधों के योग का मान
14 Calculate the value of unknown resistance 17 Calculate the value of resistance ‘R2’ in the
‘RDC’ in the Wheatstone bridge network, If PAB = parallel circuit. | समान्तर पररपि में R2 का मान ज्ञात
500W, QBC = 300W, SAo = 15W, at balanced
कीग्जये
condition. | वीटथटोन त्रब्रज की सींतल
ु न की अवथिा में
अज्ञात प्रनतरोध ‘RDC’ का मान ज्ञात कीग्जये, जब PAB =
500Ω, QBC = 300Ω, SAo = 15Ω हो
A 2Ω
B 4Ω
C 6Ω
D 8Ω
16 What electrical quantities are related in 19 What is the unit of resistivity? | प्रनतरोधकता
Ohm’s law? | ओह्म के ननयम से सम्बींचधत ववद्यतु की क्या इकाई है ?
रामशयााँ कौन सी हैं? A ohm / cm | ओह्म/सेमी
A Current, resistance and power | धारा, प्रनतरोध B ohm / cm2 | ओह्म/सेमी2
एवीं शग्क्त C ohm - metre | ओह्म-मीटर
B Current, voltage and resistivity | धारा, वोल्टे ज D ohm / metre | ओह्म/मीटर
और प्रनतरोधकता
C Current, voltage and resistance | धारा, वोल्टे ज
और प्रनतरोध
D Voltage, resistance and current density |
वोल्टे ज, प्रनतरोध और धारा दक्षता
20 Which type of resistor is used for Arc 23 What is the reading of the voltmeter V? |
quenching protection in circuit breakers? | सक्रकिट वोल्टमीटर V का पाठयाींक बताइए|
ब्रेकरों में आकि शमन सरु क्षा के मलए क्रकस प्रकार के
प्रनतरोध का उपयोग क्रकया जाता है ?
A Varistors | वैररथटर
B Sensistors | सेंमसथटर
C Thermistors | िममिथटर
D Light dependent resistor (LDR) | लाइट डिपें िेंट
रे मसथटर
A 0V
B 6V
21 Calculate the value of resistance by colour C 9V
coding method. | रीं ग कूट ववचध के द्वारा प्रनतरोध का D 18 V
मान बताइए
24 Which is the application of series circuit? |
श्रेणी पररपि का क्या उपयोग है ?
A Voltmeter connection | वोल्टमीटर सींयोजन
B Lighting circuits in home | घरों में प्रकाशीय
26 Calculate the resistance value in R3 resistor. | 29 What is the formula for Quantity of electricity
R3 प्रनतरोधक में प्रनतरोध का मान बताइए (Q)? | ववद्यत
ु मािा का सि
ू क्या है ?
A Current x Time | धारा x समय
B Voltage x Current | वोल्टे ज x धारा
C Current x Resistance | धारा x प्रनतरोध
D Voltage x Resistance | वोल्टे ज x प्रनतरोध
A 330 ± 5% Ohm
B 3300 ± 10% Ohm
C 33000 ± 5 % Ohm
D 330000 ± 10% Ohm
35 Which method is used for measuring 1 Ohm A To limit the current in the circuit | पररपि में
to 100K Ohm range resistance? | 1 ओह्म से 100K धारा को सीममत करना
ओह्म तक मापन हे तु कौन सी ववचध का उपयोग क्रकया B To increase the value of meter resistance |
जाता है ? मीटर प्रनतरोध के मान को बढ़ाना
C To adjust the zero position of the pointer |
A Substitution method | प्रनतथिापन ववचध
सींकेतक की शन्
ू य ग्थिनत को समींग्जत करना
B Kelvin bridge method | केग्ल्वन त्रब्रज ववचध
D To prevent the excess current in the circuit |
C Wheat stone bridge method | व्हीटथटोन त्रब्रज पररपि में अनतररक्त धारा को रोकना
ववचध
D Voltmeter and ammeter method | वोल्टमीटर 39 Which electrical quantity affects the heat
और एमीटर ववचध generated in a conductor? | कौन सी ववद्यत
ु ीय रामश
िालक में ऊष्मा उत्पन्न को प्रभाववत करती है ?
36 What is the S.I unit of specific resistance? | A Voltage | वोल्टे ज
ववमशष्ट प्रनतरोध की SI इकाई क्या है ? B Square of the current | धारा का वगि
A Ohm/cm
C Square of the resistance | प्रनतरोध का वगि
B Ohm/metre2
C Ohm-metre D Current passed through it | उससे प्रवाटहत धारा
D Micro ohm/cm2
40 What is the change in value of resistance of 44 Calculate the hot resistance of 200W / 250V
the conductor, if its cross section area is doubled? | rated lamp. | 200W / 250V रे टेि लैंप के गमि प्रनतरोध
िालक के प्रनतरोध के मान में क्या पररवतिन होता है , अगर की गणना करें ।
इसका अनप्र
ु थि काट क्षेिफल दोगन
ु ा हो जाता है ? A 31.25
A No change | कोई पररवतिन नहीीं B 62.5
C 312.5
B Decreases 2 times | दो गन
ु ा कम हो जाता है
D 625
C Increases 2 times | दो गन
ु ा अचधक हो जाता है
D Decreases 4 times | िार गन
ु ा कम हो जाता है 45 What is the value of resistance in an open
circuit? | एक खुले सक्रकिट में प्रनतरोध का मान क्या है ?
41 Calculate the voltage drop across the resistor A Zero | शन्
ू य
‘R4’ in the circuit? | पररपि में प्रनतरोधक R4 पर
B Low | कम
वोल्टे ज पात की गणना कीग्जये|
C High | अचधक
D Infinity | अनींत
20 - A | 21 - C | 22 - B | 23 - D | 24 - D | 25 - C |
Answers: 26 - D | 27 - A | 28 - B | 29 - A | 30 - A | 31 - D |
32 - B | 33 - B | 34 - A | 35 - C | 36 - C | 37 - B |
1-C|2-D|3-A|4-D|5-D|6-D|7-B| 38 - C | 39 - B | 40 - B | 41 - D | 42 - B | 43 - B |
8 - D | 9 - B | 10 - B | 11 - B | 12 - B | 13 - B| 44 - C | 45 - D | 46 - D | 47 - C | 48 - D |
14 - B | 15 - A | 16 - C | 17 - C | 18 - C | 19 - C |
1 Calculate the total capacitance value in the 5 Which is the diamagnetic substance? |
circuit. | पररपि की कुल सींधाररता की गणना कीग्जये परािुम्बकीय पदािि कौन सा है ?
A Air | वायु
B Steel | इथपात
C Water | जल
D Platinum | प्लैटटनम
सकता है ?
1 2 3
1
D LT = 𝐿
1 +𝐿2 +𝐿3
A Increasing the plate area | प्लेट क्षेिफल को
बढ़ाकर 9 What is the unit of permeance? | परममयेंस की
B Increasing the resistance of the plates | प्लेटों के इकाई क्या है ?
प्रनतरोध को बढाकर A Ampere - turns | एम्पेयर-टन्सि
C Increasing the distance between the plates | B Weber/Ampere turns | वेबर/एम्पेयर-टन्सि
प्लेटों के मध्य दरू ी बढाकर
C Ampere turns/Weber | एम्पेयर-टन्सि/वेबर
D Using high dielectric constant material | उच्ि
D Weber/Square metre | वेबर/मीटर2
पराववद्यत
ु ननयताींक पदािि का उपयोग करके
10 Which rule is applied to find the direction of
magnetic fields in a solenoid coil? | पररनामलका
कींु िली में िुींबकीय क्षेि की टदशा खोजने के मलए कौन सा 13 Which material is the paramagnetic
ननयम लागू क्रकया जाता है ? substance? | कौन सा पदािि अनि
ु ुम्बकीय पदािि है ?
A Cork screw rule | कॉकि थिू ननयम A Cleat wiring | क्लीट वायररींग
का ननयम
14 What is the part marked as X in B.H curve? |
D Flemings right hand rule | फ्लेममींग का दायााँ हाि B-H वि में X द्वारा अींक्रकत भाग का नाम बताइए
का ननयम
A Coercivity | कोएमसिववटी
B Saturation point | सींतप्ृ त त्रबींद ु
A 4µfd C Magnetizing force | िम्
ु बकीय बल
B 10µfd
D Residual magnetism | अवशेष िम्
ु बकत्व
C 15µfd
D 40µfd
15 What is the similar term in magnetic circuit
12 What precaution to be taken before for “conductance” in electrical circuit? | ववद्यत
ु
connecting the different voltage rating capacitors in पररपि में "िालकता" के मलए िुींबकीय सक्रकिट में समान
series? | श्रख
ीं ृ ला में ववमभन्न वोल्टे ज रे टटींग सींधाररिों को
शब्द क्या है ?
जोड़ने से पहले क्या सावधानी बरती जानी िाटहए?
A Reluctivity | ररलक्टीववटी
A All the capacitors must be same manufacturer
B Permeance | परममयेंस
| सभी कैपेमसटर एक ही ननमािता के होने िाटहए
B Each capacitors voltage drop must be less than C Reluctance | ररलक्टें स
its voltage rating | प्रत्येक कैपेमसटर वोल्टे ज ड्रॉप इसकी D Permeability | परममयेंत्रबमलटी
वोल्टे ज रे टटींग से कम होना िाटहए
C Total capacitors value must be less than the 16 What is the unit of Reluctance? | ररलक्टें स की
lowest value of capacitor | कुल कैपेमसटर का मान इकाई क्या है ?
सींधाररि के ननम्नतम मान से कम होना िाटहए A Weber / metre2
B Weber / metre
D Break down voltage of each capacitor must be
C Ampere turns / Weber
same | प्रत्येक सींधाररि का ब्रेकिाउन वोल्टे ज समान D Ampere turns / metre2
होना िाटहए
25 What indicates the shape of a BH curve 29 What is the effect of the electrolytic capacitor,
(Hysteresis loop) of material? | पदािि का B-H वि if open circuit fault occurs? | इलेक्िोलाइटटक सींधाररि
(टहथटै ररसीस लप
ू ) के आकार क्या दशािता है ? का प्रभाव क्या होता है , अगर खुला पररपि दोष होता है ?
A Reluctance of the material | पदािि का ररलक्टें स A It will not function | यह कायि नहीीं करे गा
B Field intensity of the substance | पदािि की क्षेि B It will burst at once | यह एक बार में फट जाएगा
तीव्रता C It will become leaky | यह लीक हो जाएगा
C Magnetic properties of the material | पदािि की D It will function normally | यह सामान्य रूप से
िुम्बकीय ववशेषताएीं कायि करे गा
D Pulling power of the magnetic material |
िुींबकीय सामग्री की शग्क्त खीींिना 30 What will be the change in value of
capacitance if the distance of the plates are
26 Which electrical quantity is directly decreased in the capacitor? | यटद सींधाररि में प्लेटों
proportional to the eddy current? | कौन सी ववद्यत
ु की दरू ी कम हो जाती है , तो धाररता के मान में क्या
मािा सीधे भींवर धारा के समानप
ु ाती होती है ? पररवतिन होगा?
A Voltage | वोल्टे ज A Becomes zero | शन्ू य हो जायेगा
B Current | धारा B Remains same | समान रहे गा
C Frequency | आवग्ृ त्त C Decreases | कम होगा
D Resistance | प्रनतरोध D Increases | बढ़े गा
27 Which is the cause for changing the 31 Which property of magnet is illustrated? |
permeability? | परममयेत्रबमलटी के पररवनतित होने का िम्
ु बक की कौन सी ववशेषता दशािई गई है ?
क्या कारण है ?
A Length | लम्बाई
B Flux density | फ्लक्स घनत्व
C Field intensity | क्षेि तीव्रता
D Magneto motive force | िुबकीय वाहक बल
28 Which type of capacitor is used for space A Directive property | टदशीय ववशेषता
electronics? | क्रकस प्रकार का सींधाररि अींतररक्ष B Induction property | प्रेरण ववशेषता
इलेक्िॉननक्स के मलए उपयोग क्रकया जाता है ? C Saturation property | सींतप्ृ त ववशेषता
Plastic film type | प्लाग्थटक क्रफल्म प्रकार Poles existing property | ध्रव
ु मौजद
ू ववशेषता
A D
B Ceramic disc type | मसरे ममक डिथक प्रकार
C Electrolytic-Aluminum type | इलेक्िोलाइटटक- 32 Which is a paramagnetic substance? |
एल्यम अनि
ु ुम्बकीय पदािि कौन सा है ?
ू ीननयम प्रकार
D Electrolytic-Tantalum type | इलेक्िोलाइटटक- A Air | वायु
34 What is the effect of inductance if the 37 Which type of capacitors are used in RF
distance between the turns increases? | यटद घम
ु ावों coupling circuit? | आरएफ यनु मन सक्रकिट में क्रकस प्रकार
के बीि की दरू ी बढ़ती है , तो प्रेरण का प्रभाव क्या है ? के सींधाररि का उपयोग क्रकया जाता है ?
A Increases | बढ़े गा A Tantalum | टैंटलम
B Decreases | घटे गा B Monolithic | मोनोमलचिक
C Becomes zero | शन्ू य हो जायेगा C Electrolytic | इलेक्िोमलटटक
D Remains same | समान रहे गा D Metalized poly propylene | धातक
ु ृत
पॉलीप्रोपाइलीन
35 What is the function of dielectric insulator in
capacitor? | सींधाररि में पराववद्यत
ु कुिालक का कायि Answers:
क्या है ?
A Increases the strength of capacitance | 1-B|2-C|3-A|4-C|5-C|6-B|7-C|
सींधाररता की ताकत बढ़ाता है 8 - B | 9 - B | 10 - B | 11 - D | 12 - B | 13 - B |
B Prevents any current flow between plates |
14 - A | 15 - B | 16 - C | 17 - A | 18 - A | 19 - A |
प्लेटों के बीि क्रकसी भी धारा प्रवाह को रोकता है
C Protects from short circuit between the plates 20 - C | 21 - D | 22 - B | 23 - A | 24 - A | 25 - C |
| प्लेटों के बीि लघप ु िन से बिाता है 26 - C | 27 - B | 28 - D | 29 - A | 30 - D | 31 - A |
D Helps to hold the charge in capacitor for long
period | सींधाररि में आवेश को लींबे समय तक रखने में 32 - A |33 - A | 34 - A | 35 - B | 36 - A | 37 - B |
मदद करता है
1 What is the unit of susceptance? | सथप्टें स की A Due to fluctuation of voltage | वोल्टे ज के उतार-
इकाई क्या है ? िढ़ाव के कारण
A Mho | म्हो B True power due to resistive load | प्रनतरोधक
B Ohm | ओह्म भार के कारण असली शग्क्त
C Henry | हे नरी C Reactive power due to more inductive load |
D Farad | फैराि अचधक प्रेरक भार के कारण प्रनतक्रियाशील शग्क्त
D Reactive power due to more capacitive load |
2 What is the resistance of the inductive coil अचधक धररतीय भार के कारण प्रनतक्रियाशील शग्क्त
takes 5A current across 240V, 50Hz supply at 0.8
power factor? | प्रेरकत्व कींु िली का प्रनतरोध क्या होगा, 6 What is the current in neutral conductor in 3
phase unbalanced load in star connected system? |
जो 240V पर 5A धारा ले, 50 हट्िज आपनू ति, 0.8 शग्क्त
थटार सींयोग्जत मसथटम में 3 कला असींतमु लत भार में
गण
ु ाींक है?
उदासीन िालक में धारा क्या है ?
A 48 Ω
B 42.5 Ω A No current will flow | कोई धारा नहीीं बहे गी
C 38.4 Ω B The algebraic sum of current in 3 phases | 3
D 26.6 Ω कलाओीं में धारा का बीजीय योग
C The algebraic sum of current in 2 phases only |
3 How the resonance frequency (fr) can be केवल 2 कलाओीं में धारा का बीजीय योग
increased in A.C series circuit? | A.C श्रेणी पररपि में D Lesser than the lowest current in any one of
अनन
ु ाद आवग्ृ त्त (fr) को कैसे बढ़ाया जा सकता है ? the phases | कलाओीं में से क्रकसी में सबसे कम धारा की
A Increasing the inductance value | प्रेरकत्व मान तल
ु ना में कम
में ववृ द्ध
7 Calculate the apparent power in KVA of 3
B Reducing the capacitance value | सींधाररता मान
phase 415V, 50 Hz, star system, if the line current
में कमी (IL) is 16A at 0.8 power factor. | 3 कला, 415V, 50 Hz,
C Increasing the capacitance value | सींधाररता थटार मसथटम में केवीए में आभासी शग्क्त की गणना
मान में ववृ द्ध कीग्जये, यटद लाइन धारा (IL) 16A है 0.8 शग्क्त गण
ु ाींक
D Increasing the value of resistance | प्रनतरोध पर-
मान में ववृ द्ध A 15.2 KVA
B 11.5 KVA
4 What is the formula to find 3 phase Reactive C 9.2 KVA
power (PR) if the line voltage is VL and line current is D 5.3 KVA
IL? | 3 कला ररएग्क्टव पावर (PR) को ननकालने के मलए
8 What will be the readings of two watt meters
क्या सि
ू है , यटद लाइन वोल्टे ज VLऔर लाइन करीं ट IL है ? (W1& W2) in 3 phase power measurement, if the
A Pr = VL IL power factor is zero? | 3 कला त्रबजली मापन में दो वाट
B Pr = 3 VL IL Cos
C Pr = 3 VL IL Sin मीटर (W1 & W2) की रीडिींग क्या होगी, यटद पावर फैक्टर
D Pr = 3 VL IL Cos शन्
ू य है ?
A W1 & W2 both are positive reading | W1 और
5 What is the main cause for below 0.5 lagging
W2 दोनों धनात्मक पाठयाींक
power factor in 3 phase system? | 3 कला प्रणाली में
B W1 is Positive and W2 is negative reading | W1
शग्क्त गण
ु ाींक 0.5 पश्िगामी से नीिे होने मख्
ु य कारण
धनात्मक है और W2 ऋणात्मक पाठयाींक है
क्या है ? C W1 is equal to W2 but with opposite signs |
W1, W2 के बराबर है , लेक्रकन ववपरीत सींकेतों के साि तिा फेज़ वोल्टे ज(VP) में सम्बन्ध बताइए|
D Zero W1 is Positive reading, and W2 is negative A 𝑉𝐿 = √3𝑉𝑃
reading | W1 शन्
ू य धनात्मक है और W2 ऋणात्मक
B 𝑉𝐿 = 3𝑉𝑃
पाठयाींक है VP
C 𝑉𝐿 =
√3
9 What is the maximum value of voltage for 240 D 𝑉𝐿 = 𝑉𝑃 /3
volt RMS? | 240 वोल्ट आरएमएस के मलए वोल्टे ज का
अचधकतम मल्
ू य क्या है ? 15 Calculate the line current of the 3 phase 415V
A 240V 50 HZ supply for the balanced load of 3000 watt at
B 415V 0.8 power factor is connected in star. | 3000 वाट
C 339.5V सींतमु लत भार, 0.8 शग्क्त गण
ु ाींक पर थटार में सींयोग्जत 3
D 376.8V
कला 415V 50 HZ आपनू ति है ; लाइन धारा की गणना करें ।
A 8.5 A
11 What is the formula for Reactive Power (Pr) in B 5.2 A
an AC circuit? | AC सक्रकिट में ररएग्क्टव पावर (PR) का C 4.5 A
सि
ू क्या है ?
D 3.4 A
A Pr = VI
16 What is the power factor in a 3 phase power
B Pr = √2 VI
measurement of two wattmeters showing equal
C Pr = VI cos θ
D Pr = VI sin θ readings? | तीन कला शग्क्त मापन में दो वाट मीटरों में
समान रीडिींग टदखाने पर शग्क्त गण
ु ाींक क्या है?
12 Calculate the impedance of the circuit R = 5Ω, A 0
XL= 36Ω and XC = 24 Ω. | R = 5Ω, XL= 36Ω and XC = B 1
24 Ω हैं, तो पररपि में प्रनतबाधा की गणना कीग्जये| C 0.5
D 0.8
A A IL = IR - IC
B IL = IR + IC
C IL = IR2 - IC2
B D IL = √(IR2 - IC2)
आभासी शग्क्त की गणना करें , अगर यह 0.8 शग्क्त पररपि में वोल्टे ज (V) और करीं ट (I) के बीि का कला
गण
ु ाींक पर 3 कला 415volt / 50Hz आपनू ति से जड़
ु ा है और सींबध
ीं होता है ?
फेज़ धारा 10 A है ।
A 12.45 KVA
B 57.50 KVA
C 3.320 KVA
D 7.188 KVA
33 How will you obtain positive reading in the एवीं वोल्टे ज कला में नहीीं है
wattmeter reads negative reading during 3- phase
C Current lags behind the voltage | धारा, वोल्टे ज
two wattmeter method? | 3 कला दो वाटमीटर ववचध
के पीछे रहती है
में वाटमीटर के ऋणात्मक पाठयाींक दे ने पर आप
D Current leads ahead of the voltage | धारा,
धनात्मक पाठयाींक कैसे प्राप्त करें ग?े
वोल्टे ज के आगे रहती है
A By interchanging the connections of input
terminals | आगत मसरों के सींयोजन आपस में बदलने पर
37 Calculate the total power by two wattmeter
B By disconnecting the connection of current coil (W1 & W2) method, if one of the wattmeter (W2)
in meter | धारा कींु िली को मीटर में से ववसींयोग्जत करने reading is taken after reversing. | दो वाटमीटर (W1 &
पर W2) ववचध द्वारा कुल शग्क्त की गणना करें , यटद एक
C By reversing the connection of pressure coil in
वाटमीटर (W2) रीडिींग उलटने के बाद ली जाती है ।
meter | मीटर में दबाव कींु िली के सींयोजन बदलने पर
A W1 x 2
D By reversing the pressure coil and current coil
B W1 only | केवल W1
connection in meter | मीटर में दबाव कींु िली और धारा
C W1 - W2
कींु िली के सींयोजन बदलने पर D W1 + W2
34 What is the form factor (Kf) for sinusoidal AC? 38 In which 3 phase system, the artificial neutral
| ज्याविीय एसी के मलए फॉमि फैक्टर (Kf) क्या है ? is required to measure the phase voltage? | कौन सी
A 1 3 कला प्रणाली में , फेज़ वोल्टे ज को मापने के मलए कृत्रिम
B 1.11
उदासीन तार की आवश्यकता होती है ?
C 2.22
D 4.44 A 3 wire star connected system | 3 तार थटार
सींयोग्जत मसथटम
35 What is the reciprocal of inductance in AC
B 4 wire star connected system | 4 तार थटार
parallel circuit? | एसी समानाींतर पररपि में प्रेरकत्व का
सींयोग्जत मसथटम
पारथपररक क्या है?
C 3 wire delta connected system | 3 तार िेल्टा
A Reactance | प्रनतघात
सींयोग्जत मसथटम
B Admittance | एिममटें स
D 4 wire delta connected system | 4 तार िेल्टा
C Conductance | िालकता
सींयोग्जत मसथटम
D Susceptance | सथप्टें स
मान
𝐴𝑣𝑒𝑟𝑎𝑔𝑒 𝑣𝑎𝑙𝑢𝑒 44 Which condition is called as resonance RLC
D Kf = 𝑀𝑎𝑥𝑖𝑚𝑢𝑚 𝑣𝑎𝑙𝑢𝑒 | Kf =औसत मान/अचधकतम
circuit? | क्रकस ग्थिनत को अनन
ु ाद RLC सक्रकिट कहा
मान
जाता है ?
A XL > XC
41 Which formula is used to calculate the
B XC > XL
impedance (z) of a RLC series circuit? | RLC श्रींख
ृ ला C XL = XC
सक्रकिट के प्रनतबाधा (z) की गणना करने के मलए क्रकस सि
ू D R < XL
1 Which device converts sunlight into electrical 6 What is the unit of electric charge? | विद्यि
ु
energy? | कौन सी यक्ु ति धुप को विद्यि
ु ऊर्जा में आिेि की तयज इकजई है ?
बदलिी है ? A Volt | िोल्ट
A Photo voltaic cell | फोटो िोल्टे इक सेल B Watt | िजट
B Liquid crystal diode | ललक्तिड क्रिस्टल डजयोड C Ampere | एम्पेयर
C Light emitting diode | लजइट एलमटटिंग डजयोड D Coulomb | कूलजम
D Light dependent resistor | लजइट डडपें डेंट रे लसस्टर
7 What is the output voltage of lithium cell? |
2 Which law secondary cell works? | द्वििीयक ललथथयम सेल कज ननगाि िोल्टे र् क्रकिनज होिज है ?
सेल क्रकस ननयम से कजया करिे हैं? A 1.2 V
B 1.5 V
A Lenz’s law | लेन्र् कज ननयम
C 1.8 V
B Joule’s law | र्ूल कज ननयम D 2.5 V
C Faradays laws of electrolysis | फैरजडे के विद्यि
ु
8 What is the method of charging if the battery is
अपघटन कज ननयम to be charged for short duration at higher rate? |
D Faradays laws of electromagnetic induction | कम समय में उच्च दर से बैटरी आिेलिि करने हे िु कौन
फैरजडे के विद्यि
ु चम्
ु बकीय प्रेरण कज ननयम
सी विथध अपनजयी र्जिी है ?
3 What is the formula to calculate the Mass A Initial charge | प्रजरिं लिक आिेि
deposited during electrolysis? | विद्यि
ु अपघट्य के B Boost charge | बस्
ू ट आिेि
दौरजन एकत्रिि द्रव्यमजन की गणनज करने कज सि
ू तयज है ? C Trickle charge | टट्रकल आिेि
A M = it gm D Freshening charge | फ्रेक््निंग आिेि
B M = zit gm
C M = it/z gm 9 Which electrolyte used in carbon zinc dry cells?
D M = z/it gm
| कजबान र्स्िज िष्ु क सेल में कौन सज विद्यि
ु अपघट्य
4 How the capacity of batteries is specified? | उपयोग क्रकयज र्जिज है?
बैट्री की क्षमिज कैसे बिजई र्जिी है ? A Dilute sulphuric acid | िनु सल््यरू रक अम्ल
A Volt | िोल्ट B Ammonium chloride | अमोननयम तलोरजइड
B Watt | िजट C Potassium hydroxide | पोटे लियम हजइड्रोतसजइड
C Volt Ampere | िोल्ट एम्पेयर D Concentrated hydrochloric acid | सजन्द्र
D Ampere hour | एम्पेयर घिंटज सल््यरू रक अम्ल
5 What is the name of defect that bending of 10 Which effect causes by passing electric
plates in secondary cells? | उस दोष कज नजम बिजइए, current in liquids? | द्रिों में विद्यि
ु धजरज प्रिजटहि होनज
क्र्स कजरण से द्वििीयक सेल में प्लेट मड़
ु र्जिी हैं- कौन सज प्रिजि है?
A Buckling | बकललिंग A Heating | ऊष्मीय
B Local action | स्थजनीय क्रियज B Lighting | प्रकजिीय
C Partial short | आिंलिक लघप
ु थन C Magnetic | चम्
ु बकीय
D Hard sulphation | कठोर सल्फेिन D Chemical | रजसजयननक
11 Which material is used to make negative C Selection of voltage range | िोल्टे र् परजस कज
plates in lead acid battery? | सीसज अम्ल बैटरी में चुनजि
ऋणजत्मक प्लेट बनजने हे िु कौन सज पदजथा प्रयोग होिज है? D Selection of charging method | आिेिन विथध
A Lead dioxide | लेड डजयऑतसजइड कज चुनजि
B Sponge lead | स्पजिंर् सीसज
C Lead peroxide | लेड पेरोतसजइड 16 What is the effect on output power with
D Lead sulphate | लेड सल्फेट respect to temperature in solar cells? | सौर सेल में
िजपमजन के सन्दिा में ननगाि िक्ति पर तयज प्रिजि होगज?
12 Which technique is used to control the A No effect on change in temperature | िजपमजन
corrosion of a metal surface? | धजिु सिह के क्षरण के में कोई प्रिजि नहीिं
ननयिंिण हे िु कौन सी िकनीकप्रयोग होिी है ? B Increases with increase in temperature |
A Anodic protection | अनोडडक सरु क्षज िजपमजन में िवृ ि के सजथ िवृ ि
B Cathodic protection | कैथोडडक सरु क्षज C Decreases with increase in temperature |
C Electrolytic protection | इलेतट्रोललटटक सरु क्षज िजपमजन में िवृ ि के सजथ कमी
D Decreases with decrease in temperature |
D Electrostatic protection | क्स्थर विद्यि
ु सरु क्षज
िजपमजन में कमी के सजथ कमी
13 Which cell is most often used in digital
17 What purpose the hydrometer is used during
watches? | डडक्र्टल घडड़यों में सजमजन्यिः कौन सज सेल
charging of battery? | बैटरी में आिेिन के समय
प्रयोग होिज है ?
हजइड्रोमीटर कज तयज उद्दे्य है ?
A Voltaic | िोल्टे इक
A Determine the AH capacity | Ah क्षमिज ननधजाररि
B Lithium | ललथथयम
करने हे िु
C Mercury | पजरज
B Assess the battery voltage level | बैटरी िोल्टे र्
D Silver oxide | लसल्िर ऑतसजइड
स्िर ननकजलने हे िु
14 What is the effect if one cell is connected with C Assess the discharge level of battery | बैटरी कज
reverse polarity in a parallel combination circuit? | ननरजिेलिि स्िर ननकजलने हे िु
समजन्िर यग्ु मन पररपथ में यटद एक सेल को विपरीि D Determine the specific gravity of electrolyte |
ध्रुििज के सजथ सिंयोक्र्ि क्रकयज र्जए, िो तयज प्रिजि होगज? विद्यि
ु अपघट्य कज विलिष्ट गरु ु त्ि ननधजाररि करने में
A Voltage become zero | िोल्टे र् िन्
ू य हो र्जएगज
18 What is the formula for Faraday’s first law of
B Become open circuit | खुलज पररपथ हो र्जयेगज
electrolysis? | फैरजडे के विद्यि
ु अपघटन के प्रथम
C Will get short circuited | लघप
ु थथि हो र्जयेगज
ननयम कज सि
ू तयज है ?
D No effect will function normally | कोई प्रिजि
A M = Z/it
नहीिं, सजमजन्य रूप से कजया करे गज B M = Zit
C M = it/ Z
15 What is the function of fine selector switch in D M = Zt/i
battery charger? | बैटरी आिेिक में फजइन सेलस्
े तटर
क्स्िच कज तयज कजया है ?
A Selection of current rating | धजरज रे टटिंग कज चुनजि
B Selection of charging time | आिेिन समय कज
चुनजि
19 Which is used as an electrolyte in lead acid D To check the colour changes in the plates |
battery? | सीसज अम्ल सेल में विद्यि
ु अपघट्य की िरह प्लेट कज रिं ग बदलनज र्जिंचने हे िु
तयज उपयोग क्रकयज र्जिज है?
23 In which method the battery is charged at low
A Hydrochloric acid | हजइड्रोतलोररक अम्ल
current for long period? | कौन सी विथध में बैटरी को
B Ammonium chloride | अमोननयम तलोरजइड
कम धजरज पर लम्बे समय िक आिेलिि क्रकयज र्जिज है?
C Potassium hydroxide | पोटे लियम हजइड्रोतसजइड
A Rectifier method | टदष्टकजरी विथध
D Diluted sulphuric acid | िनु सल््यरू रक अम्ल
B Trickle charging method | टट्रकल आिेिन विथध
20 What is the total voltage of the circuit? | C Constant current method | ननयि धजरज विथध
पररपथ कज कुल िोल्टे र् तयज है ? D Constant potential method | ननयि वििि विथध
33 Which is used as a positive electrode in a dry 37 What is the Electro Chemical Equivalent (ECE)
cell? | िष्ु क सेल में धनजत्मक इलेतट्रोड के रूप में तयज of copper? | िजिंबे कज विद्यि
ु रजसजयननक िल्
ु यजिंक तयज
प्रयोग होिज है ? है ?
A Zinc | र्स्िज A 0.329 mg / coulomb
B 0.329 g/ coulomb
B Carbon | कजबान
C 1.1182 mg / coulomb
C Copper | िजिंबज D 1.1182 g/ coulomb
D Lithium | ललथथयम
38 Which is the cause for buckling defect in lead
34 What happen to the terminal voltage of a cell acid battery? | सीसज एलसड बैटरी में बकललिंग दोष कज
if load increases? | िर बढ़ने पर सेल के लसरों के िोल्टे र् कजरण कौन सज है?
में तयज होगज? A Overcharging or over discharging | अनि
A Increases | बढ़े गज आिेिन यज अनि ननरजिेिन
B Decreases | घटे गज B Charging with low rate for short period | छोटी
C Falls to zero | िन्
ू य िक थगरे गज अिथध के ललए कम दर के सजथ चजर्ा करनज
D Remains same | समजन रहे गज C Formation of sediments falling from the plate |
प्लेट से थगरने िजले अिसजदों कज बननज
35 How local action defect is prevented in voltaic D Battery is kept in discharged condition for long
cell? | िोल्टे इक सेल में स्थजनीय क्रियज दोष को कैसे रोकज period | बैटरी को लिंबे समय िक ननरजिेलिि क्स्थनि में
र्जिज है ? रखज र्जनज
A By connecting cells in series | सेलों को श्रेणी में
39 Which apparatus is used to check the charging
सिंयोक्र्ि करके
condition of voltage in battery? | बैटरी में िोल्टे र् की
B By using a depolarizing agent | विध्रुिक रिं र्क कज
चजक्र्िंग क्स्थनि की र्जिंच करने के ललए क्रकस उपकरण कज
उपयोग करके
उपयोग क्रकयज र्जिज है?
C By connecting cells in parallel | सेलों को
A Voltmeter | िोल्टमीटर
समजन्िर में सिंयोक्र्ि करके
B Multimeter | मल्टीमीटर
D By amalgamating the zinc plate | र्स्िज प्लेट कज
C Hydrometer | हजइड्रोमीटर
अमलगम करके
D High rate discharge tester | उच्च दर ननरजिेिन
Answers: | 21 - B | 22 - A | 23 - B | 24 - C | 25 - A | 26 - D
| 27 - C | 28 - C | 29 - B | 30 - B | 31 - A | 32 - D
1-A|2-C|3-B|4-D|5-A|6-D|7-D| | 33 - B | 34 - B | 35 - D | 36 - B | 37 - A | 38 - A
8 - B | 9 - B | 10 - D | 11 - B | 12 - B | 13 - C | 14 - C | 39 - D | 40 - B |
| 15 - A | 16 - D | 17 - D | 18 - B | 19 - D | 20 - A
41 How the conduit pipes are specified? | D Diazed screw type cartridge fuse | डजयज्ड पें च
कन््यट
ू पजइप कैसे ननटदा ष्ट क्रकए र्जिे हैं? प्रकजर कजटट्रा र् ्यर्
ू
A Length in metre | लम्बजई, मीटर में
B Wall thickness in mm | दीिजर की मोटजई, लममी में 45 What is the name of electrical accessory? |
C Inner diameter in mm | आििंररक व्यजस, लममी में विद्यि
ु सजमग्री कज नजम तयज है
56 What is the name of the accessory used in 100 A धजरज रे टटिंग से ऊपर क्रकयज र्जिज है ?
electrical appliances? | विद्यि
ु उपकरणों में प्रयत
ु ि A Miniature Circuit Breaker (MCB | लमननएचर
सजमग्री कज तयज नजम है? सक्रकाट ब्रेकर
B Earth Leakage Circuit Breaker (ELCB) | अथा
लीकेर् सक्रकाट ब्रेकर
C Moulded Case Circuit Breaker (MCCB) | मोल्डेड
केस सक्रकाट ब्रेकर
D Residual Current Circuit Breaker (RCCB) |
अििेष धजरज सक्रकाट ब्रेकर
A 2 Pin plug | 2 वपन प्लग
60 What is the purpose of tin coating on copper
B Three pin plug | िीन वपन प्लग
fuse wire? | िजिंबे के ्यर्
ू िजर पर टटन कोटटिंग कज तयज
C Iron connector with direct entry | सीधे प्रिेि के
उद्दे्य है ?
सजथ लौह सिंयोर्क
A Withstand high temperature | उच्च िजपमजन
D Flat connector with side entry | बगल प्रिेि के
सहनज
सजथ चपटे सिंयोर्क
B Increase the fusing factor | ्यक्ु ग
िं गण
ु जिंक में
57 What is the name of the accessory symbol? | िवृ ि
सजमग्री प्रिीक कज नजम तयज है? C Prevent oxidation of copper wire | िजिंबे के िजर
कज ऑतसीकरण रोकनज
D Increase the mechanical strength | यजिंत्रिक
िक्ति में िवृ ि
70 Which is the application of DC series MCB? | D Maintain voltage level constant | िोल्टे र् स्िर
DC श्रख
िं ृ लज MCB कज अनप्र
ु योग कौन सज है? क्स्थर बनजए रखें
A AC motor | एसी मोटर
B DC motor | डीसी मोटर 75 What is the name of the lighting circuit? |
C Locomotives | लोकोमोटटि प्रकजिीय पररपथ कज तयज नजम है ?
72 Which place the Tree system of wiring is most 76 What is the tool used to bend conduits? |
suitable? | िजयररिंग कज ट्री लसस्टम क्रकस स्थजन पर सबसे कन््यट
ू को मोड़ने के ललए क्रकस उपकरण कज उपयोग
उपयत
ु ि है? क्रकयज र्जिज है ?
A Godown wiring | गोदजम िजयररिंग A Hickey | टहकी
B Industrial wiring | औद्योथगक िजयररिंग B Coupler | कपलर
C Domestic wiring | घरे लू िजयररिंग C Pipe vice | पजइप िजईस
D Multi storied building | बहु मिंक्र्लज ििन D Bench vice | बेंच िजईस
78 What is the purpose of ELCB? | ELCB कज उद्दे्य C Holding accessories | होक्ल्डिंग सजमग्री
तयज है ? D General accessories | सजमजन्य सजमग्री
A Detects the fault in circuit | पररपथ में दोष
82 What is the purpose of the circuit diagram in
खोर्नज
wiring installation? | िजयररिंग इिंस्टॉलेिन में पररपथ
B Monitors the residual current | अििेष धजरज को
आरे ख कज उद्दे्य तयज है ?
दे खनज
A To show the physical position of accessories |
C Protects the equipment from over load |
सजमग्री की िौनिक क्स्थनि टदखजने के ललए
अनििजर से उपकरण की सरु क्षज करिज है
B To estimate the various accessories in the
D Protects from short circuit fault | लघप
ु थन से circuit | सक्रकाट में विलिन्न सजमग्री कज अनम
ु जन लगजने
उपकरण की सरु क्षज करिज है के ललए
C To inform the reader quickly what for the
79 What is the purpose of the fuse cut out
circuit is designed | पजठक को र्ल्दी से सथू चि करने के
provided at the incoming power supply? | आगि
ललए क्रक सक्रकाट क्रकसललए डड जइन क्रकयज गयज है
त्रबर्ली आपनू िा में प्रदजन क्रकए गए ्यर्
ू कट कज उद्दे्य D To show the schematic connection of the
तयज है ? circuit for a specific task | क्रकसी विलिष्ट कजया के ललए
A To ensure the line is not over loaded | यह सक्रकाट कज योर्नजबि कनेतिन टदखजने के ललए
सनु नक््चि करने के ललए क्रक लजइन अनििजर नहीिं है
B To maintain the stabilised supply voltage | 83 Which electrical equipment is provided with L
क्स्थर आपनू िा िोल्टे र् बनजए रखने के ललए series MCB? | L श्रख
िं ृ लज MCB के सजथ कौन से विद्यि
ु
C To protect the circuit from the leakage current उपकरण प्रदजन क्रकए र्जिे हैं?
| सक्रकाट को लीकेर् करिं ट से बचजने के ललए A General lighting | िनरल लाईटटिंग
D To protect the human beings from electric
B Motors | मोटर
shock | िजक्रक इिंसजन को त्रबर्ली के झटके से बचजयज र्ज
C Air conditioner | िजिजनक
ु ूल
सके
D Halogen lamp | है लोर्न लैंप
99 What is the application of the wiring circuit? | 102 Which types of accessories are used to
िजयररिंग सक्रकाट कज अनप्र
ु योग तयज है ? operate a portable appliance? | पोटे बल उपकरण को
सिंचजललि करने के ललए क्रकस प्रकजर के सजमजन कज उपयोग
क्रकयज र्जिज है ?
A Safety accessories | सरु क्षज के सजमजन
B Holding accessories | पकड़ने योग्य सजमजन
C Outlet accessories | ननगाि सजमजन
D Controlling accessories | ननयिंिण सजमजन
A Two lamps dim operation only | दो लैंप मिंद
सिंचजलन 103 Which insulation is necessary for proper
B Two lamps controlled by one switch | एक क्स्िच function and basic protection? | उथचि कजया और
द्िजरज ननयिंत्रिि दो लैंप बनु नयजदी सरु क्षज के ललए कौन सज कुचजलक आि्यक है ?
C Two lamps controlled by two switches | दो A Double insulation | दोहरज कुचजलक
लैंप दो क्स्िच द्िजरज ननयिंत्रिि B Functional insulation | कजयजात्मक कुचजलक
D One lamp bright and two lamp dim operation | C Reinforced insulation | प्रबललि कुचजलक
एक लैंप उज्ज्िल और दो लैंप मिंद सिंचजलन D Supplementary insulation | परू क कुचजलक
100 What is the reason for home theatre wiring 104 Which type of accessories of fuse is comes
not to run along with power wiring? | होम थथएटर under? | ्यर्
ू क्रकस प्रकजर के सजमजन के अिंिगाि आिज
िजयररिंग को पजिर िजयररिंग के सजथ नहीिं चलजने कज तयज है ?
कजरण है? A Controlling accessories | ननयिंिण सजमजन
A Avoid leakage current in home theatre wiring | B Holding accessories | पकड़ने योग्य सजमजन
होम थथएटर िजयररिंग में लीकेर् करिं ट से बचें
C Safety accessories | सरु क्षज के सजमजन
B Control temperature in home theatre wiring |
D Outlet accessories | ननगाि सजमजन
होम थथयेटर िजयररिंग में ननयिंिण िजपमजन
C Avoid electrical interference in audio, video
105 What is the expansion of ECC? | ईसीसी कज
system | ऑडडयो, िीडडयो लसस्टम में विद्यि ु हस्िक्षेप
विस्िजर तयज है ?
से बचें
A Earth Conductor Continuity
D Reduce the power consumption in power
B Earth Continuity Conductor
supplies | त्रबर्ली की आपनू िा में त्रबर्ली की खपि को C Earth Carrying Conductor
कम करें D Earth Continuity Cable
101 What will happen to the value of earth 106 Which type MCBs suitable for halogen
resistance if length of the earth pipe is increased? | lamps? | हलोिन लैंप िे ललए िौन सा प्रिार एमसीबी
यटद अथा पजइप की लिंबजई बढ़ र्जिी है , िो अथा के प्रनिरोध उपयक्
ु त है?
के मजन कज तयज होगज? A L series MCBs |L श्ख
िं र ला MCB
111 What is the minimum size of Copper earth D Voltage drop=IR/2 volt | िोल्टे र् पजि = IR/2
continuity conductor used in single phase domestic
िोल्ट
wiring as per BIS? | बीआईएस के अनस ु जर एकल चरण
घरे लू िजयररिंग में तािंबा अथा ननरिं िरिज किंडतटर कज 115 What is the maximum permissible load for a
न्यन
ू िम आकजर तयज है ? power sub circuit as per I.E rules? | I.E ननयमों के
A 3 Sq.mm अनस
ु जर पजिर उप-पररपथ के ललए अथधकिम अनम
ु ेय
B 3.5 Sq.mm
िजर तयज है?
C 2.5 Sq.mm
D 1.5 Sq.mm A 800 Watt
B 1500 Watt
112 Which method is used to reduce earth C 2000 Watt
D 3000 Watt
resistance value in a existing earth? | मौर्ूदज अथा
सिंयोर्न में अथा प्रनिरोध मजन को कम करने के ललए क्रकस 116 Which location the service connection supply
पिनि कज उपयोग क्रकयज र्जिज है ? leads to be connected at consumer main board? |
A Increasing the length of electrode | इलेतट्रोड की उपिोतिज मख् ु य बोडा में सेिज सिंयोर्न आपनू िा क्रकस स्थजन
गनि से चलने कज तयज कजरण है ? B Providing by plate earthing | प्लेट अथथिंग द्िजरज
A Open circuit in the neutral line | न्यट्र
ू ल लजइन में प्रदजन करनज
खल
ु ज पररपथ C Increasing conductor size | चजलक कज आकजर
B Short circuit between conductors | चजलकों के बढ़जनज
बीच लघप
ु थन D Providing parallel earthing | समजन्िर अथथिंग
C High value series resistance fault | उच्च मजन दे नज
श्रेणी पररपथ दोष
128 What is the function of current reverser in
D Open circuit in the earth conductor | िू समपका
earth resistance tester? | अथा प्रनिरोध परीक्षक में
िजर में खुलज पररपथ
धजरज उत्िमक कज कजया तयज है?
125 Which wiring installation the System A Converts A.C. into D.C | ए.सी. को डी. सी. में
earthing is to be done? | लसस्टम अथथिंग को क्रकस पररिनिाि करिज है
िजयररिंग स्थजपनज के ललए क्रकयज र्जनज है ? B Reverses the polarity of D.C | D.C की ध्रुिीयिज
B Godown wiring | गोदजम िजयररिंग C Changes D.C. supply into A.C supply | डीसी
आपनू िा को एसी आपनू िा में बदलनज
C Domestic wiring | घरे लू िजयररिंग
D Reverses the direction of rotation of the
Commercial wiring | व्यजिसजनयक िजयररिंग generator | र्ननि की घम ू ने की टदिज बदलनज
D
126 Which method of earth resistance 129 What is the advantage of stranded
measurement is illustrated? | पथ् conductor over solid conductor? | गथ
ु े हुए किंडतटर
ृ िी प्रनिरोध मजप की
कौन सी विथध सथचि है ? कज ठोस किंडतटर की िल
ु नज में तयज फजयदज है ?
A Cost is less | लजगि कम है
B More flexible | अथधक लचीलज
C Less voltage drop | कम िोल्टे र् पजि
D More insulation resistance | अथधक कुचजलक
प्रनिरोध
131 What is the reason for supplying AC to the A Self induction | स्ि प्रेरण
electrodes for measuring earth resistance? | पथ्
ृ िी B Mutual induction | अन्योन्य प्रेरण
प्रनिरोध को मजपने के ललए इलेतट्रोड को एसी की आपनू िा C Fall of potential method | वििि पजि विथध
करने कज तयज कजरण है? D Fleming’s left hand rule | ्लेलमिंग कज बजएिं हजथ
A Provide electrostatic shield | क्स्थर विद्यि
ु कज ननयम
िील्ड प्रदजन करें
B Protect the coils in the meter | मीटर में किंु डली 135 Why system earthing is different in
को सरु क्षक्षि रखें utilization than equipment earthing? | उपकरण
C Reduce the value of current in the meter | अथथिंग की िल
ु नज में लसस्टम अथथिंग अलग तयों है ?
मीटर में धजरज कज मजन घटजनज A It protects human only | यह केिल मनष्ु यों की
D Avoid the effect of electrolytic emf रक्षज करिज है
interference | विद्यि
ु अपघट्य वििज बल को हटजनज B It protects from all circuit faults | यह सिी
पररपथ दोषों से बचजिज है
132 Why the pointer is not stable at zero on the
C It is associated with current carrying
scale as the megger is not in use? | मेगर उपयोग में
conductors | यह धजरज िजहक चजलकों से सम्बिंथधि है
नहीिं है , क्रफर िी तयों सच
ू क पैमजनज िन्
ू य पर क्स्थर नहीिं है ?
D It is connected to the non current carrying
It is not having controlling Torque | यह बलजघण
ू ा metal work | यह गैर धजरज िजहक धजिओु िं से सम्बिंथधि है
A
को ननयिंत्रिि नहीिं कर रहज है
B Provided with air friction damping | हिज घषाण 136 What is the effect if a person receives a
डैक्म्पिंग प्रदजन की shock current of 20 mA? | यटद क्रकसी व्यक्ति को 20
C The deflecting torque is directly proportional to mA धजरज कज झटकज प्रजप्ि होिज है िो तयज प्रिजि पड़िज है?
the current | विचलन बलजघण ू ा धजरज के समजनप
ु जिी है A No sensation | कोई सिंिेदनज नहीिं
D The deflecting torque is directly proportional B Painful shock | ददा नजक झटकज
to the square of the current | विचलन बलजघण ू ा धजरज C Heart convulsions | ह्रदय आघजि
के िगा के समजनप
ु जिी है D Become unconscious | बेहोि होनज
133 Which is proportional for the deflection of 137 Which electrical equipment L series type
ohmmeter needle in earth resistance tester? | पथ्
ृ िी MCB’s are used? | MCB के क्रकस विद्यि
ु उपकरण L
प्रनिरोध परीक्षक में ओह्ममीटर सई
ु के विक्षेपण क्रकसके श्रेणी कज उपयोग क्रकयज र्जिज है ?
आनप
ु जनिक है ? A Geysers | गीर्र
A Current in current coil | धजरज किंु डली में धजरज B Locomotives | लोकोमोटटि
B Current in potential coil | वििि किंु डली में धजरज C Halogen lamps | है लोर्न लैंप
Speed of the handle rotation | हैंडल घण
ू न
ा की Air conditioners | िजिजनक
ु ू लक
C D
गनि
D Ratio of the current in two coils | दो किंु डललयों में 138 What is the megger reading in a dead short
धजरज कज अनप wiring installation? | डेड लघु िजयररिंग इिंस्टॉलेिन में
ु जि
मेगर तयज पढ़ रहज है ?
134 Which principle the earth resistance tester A 0MΩ
works? | पथ्
ृ िी प्रनिरोध परीक्षक क्रकस लसिजिंि पर कजम B 1MΩ
करिज है ? C 500 M Ω
D Infinity | अनिंि
140 What is the S.I unit of luminous intensity? | C Increase the working voltage | कजयाकजरी िोल्टे र्
दै दीप्यमजन िीव्रिज की SI इकजई तयज है ? को बढ़जनज
A Lux | लतस D Ignite the high voltage initially | प्रजरिं ि में उच्च
B Lumen | ल्यम
ु ेन िोल्टे र् को दे नज
C Candela | कैन्डेलज
D Steradian | स्टे रेडडयन 145 How stroboscopic effect in industrial twin
tube light fitting is reduced? | औद्योथगक दो ट्यब
ू
141 What is the working temperature of filament लजइट क्रफटटिंग में स्ट्रोबोस्कोवपक प्रिजि कैसे कम होिज है ?
lamp? | ििंिु लैंप कज कजयाकजरी िजपमजन क्रकिनज होिज है ? A Connecting capacitor parallel to supply |
A 1500°C सिंधजररि को आपनू िा के समजन्िर में सिंयोक्र्ि करनज
B 1800°C B Connecting capacitor in series with supply |
C 2000°C
सिंधजररि को आपनू िा के श्रेणी में सिंयोक्र्ि करनज
D 2300°C
C Connecting capacitor in series with one tube
142 Which material is coated in tungsten light | सिंधजररि को एक ट्यब ू लजइट के श्रेणी में सिंयोक्र्ि
electrode of a fluorescent tube lamp? | ्लोरोसेंट करनज
ट्यब
ू लैंप में टिं गस्टन इलेतट्रोड को क्रकस पदजथा से लेवपि D Connecting two capacitors in series to each
क्रकयज र्जिज है ? tube light | सिंधजररि को प्रत्येक ट्यब
ू लजइट के श्रेणी में
A Silver oxide | लसल्िर ऑतसजइड सिंयोक्र्ि करनज
B Phosphor powder | फोस्फेर पजउडर
146 What is the current carrying capacity of
C Fluorescent powder | ्लोरोसेंट पजउडर flasher, if the current is 100 mA in each row? |
D Barium and stroatium oxide | बेररयम िथज ्लैिर की ििामजन िहन क्षमिज तयज है , यटद प्रत्येक
स्ट्रोलियम ऑतसजइड पिंक्ति में करिं ट 100 mA है?
156 What is the name of the reflector? | परजििाक 159 What is the name of lamp? | लैंप कज नजम तयज
कज नजम तयज है ? है ?
162 Which force is required to move the pointer 166 Which instrument is used to measure one
from zero position in an indicating instrument? | ohm and below one ohm resistance value
एक सिंकेिक उपकरण में पॉइिंटर को िन्ू य क्स्थनि से accurately? | एक ओह्म और एक ओह्म से नीचे
स्थजनजिंिररि करने के ललए क्रकस बल की आि्यकिज होिी प्रनिरोध मजन को मजपने के ललए क्रकस उपकरण कज
है ? उपयोग क्रकयज र्जिज है?
A Controlling force | बल को ननयिंत्रिि करनज A Megohm meter | मेगज ओह्म मीटर
B Deflecting force | विचलन बल B Multimeter (analog) | मल्टीमीटर (एनजलॉग)
C Air friction damping | िजयु घषाण मिंदन C Shunt type ohm meter | ििंट टजइप ओह्म मीटर
D Eddy current damping | ििंिर धजरज मिंदन D Series type ohm meter | श्रिंख
ृ लज प्रकजर ओह्म
मीटर
163 Which is the position to use the instrument
provided with gravity control? | गरु
ु त्िजकषाण ननयिंिण 167 What is the purpose of the 3rd terminal
के सजथ प्रदजन क्रकए गए उपकरण कज उपयोग करने की provided in a advanced megohm meter? | उन्नि
क्स्थनि कौन सी है ? मेगजओह्म मीटर में प्रदजन क्रकए गए िीसरे लसरे कज उद्दे्य
A Any position | क्रकसी िी क्स्थनि में तयज है ?
B Vertical position | ऊध्िजाधर क्स्थनि A Get higher ohmic values | उच्च ओक्ह्मक मजन
C Inclined position | झुकी हुई क्स्थनि प्रजप्ि करें
D Horizontal position | क्षैनिर् क्स्थनि B Pass the excess voltage to ground | अनिररति
िोल्टे र् र्मीन पर पजस करें
164 What is the name of the scale? | पैमजने कज C Pass the excess current to ground | अनिररति
नजम तयज है ? धजरज र्मीन में डजलने हे िु
D Get accurate readings without oscillation |
दोलन के त्रबनज सटीक रीडडिंग प्रजप्ि करें
169 What is the reason for the moving coil meter बचें
having uniform scale? | चल किंु डली मीटर के एक B Minimize the error in reading | पजठयजिंक में िटु ट
समजन पैमजने पर होने कज तयज कजरण है ? को कम करें
A Deflecting torque is directly proportional to the
C Adjust the current to safe value | धजरज को
current | विचलन बलजघण ू ा धजरज के आनप ु जनिक है
सरु क्षक्षि मजन पर समजयोक्र्ि करें
B Deflecting torque is inversely proportional to
the current | विचलन बलजघण ू ा धजरज के व्यत्ु िमजनप
ु जिी D Adjust the pointer to zero adjustment | पॉइिंटर
है को िन्
ू य समजयोर्न में समजयोक्र्ि करें
C Deflecting torque is inversely proportional to
173 Which material is used to make control
the square of the current | विचलन बलजघणू ा धजरज के
spring in measuring instruments? | मजपने िजले
िगा के व्यत्ु िमजनप
ु जिी है
उपकरणों में ननयिंिण क्स्प्रिंग बनजने के ललए क्रकस सजमग्री
D Deflecting torque is directly proportional to the
square of the current | विचलन बलजघणू ा धजरज के िगा कज उपयोग क्रकयज र्जिज है ?
के समजनप
ु जिी है A Steel | इस्पजि
B Silver | चजिंदी
170 Which error if the energy meter disc rotating C Tinned copper | कलई क्रकयज हुआ िजिंबज
continuously on no load? | यटद ऊर्जा मीटर डडस्क
D Phosphor bronze | फॉस्फर ब्रॉन्
त्रबनज क्रकसी लोड के लगजिजर घम
ू िी है िो कौन सी िटु ट है?
A Speed error | गनि की िटु ट 174 Which electrical effect that the single phase
B Phase error | कलज िटु ट energy meter works? | एकल चरण ऊर्जा मीटर कौन से
C Friction error | घषाण िटु ट विद्यि
ु प्रिजि पर कजम करिज है ?
D Creeping error | रें गने की िटु ट A Heating effect | ऊष्मीय प्रिजि
B Induction effect | प्रेरण प्रिजि
171 What is the effect on CT if its secondary is C Chemical effect | रजसजयननक प्रिजि
kept open? | यटद सीटी कज द्वििीयक खुलज रखज र्जिज
D Electrostatic effect | क्स्थर विद्यि
ु प्रिजि
है िो इस पर तयज प्रिजि पड़िज है ?
A CT primary burns out | CT की प्रजथलमक किंु डली 175 Which is the position to use the instrument
र्ल र्जएगी provided with spring control? | स्वप्रिंग ननयिंत्रण िे
B Volt ampere capacity reduces | िोल्ट एम्पीयर साथ प्रदान किए गए उपिरण िा उपयोग िरने िी
क्षमिज कम हो र्जिी है स्वथनत क्या है ?
C Volt ampere capacity increases | िोल्ट एम्पीयर A Any position | क्रकसी िी क्स्थनि में
क्षमिज बढ़ र्जिी है B Vertical position only | केिल ऊध्िजाधर क्स्थनि
D CT secondary winding burns out | CT की C Inclined position only | केिल झक
ु ी हुई क्स्थनि
द्वििीयक किंु डली र्ल र्जएगी D Horizontal position only | केिल क्षैनिर् क्स्थनि
176 What is the name of meter? | मीटर कज नजम A Deflecting force is directly proportional to the
तयज है ? Current | विचलन बल, धजरज के समजनप ु जिी होिज है
B Deflecting force is inversely proportional to the
Current | विचलन बलजघण ू ा धजरज के व्यत्ु िमजनप
ु जिी है
C Deflection of force is directly proportional to
the square of the Current | विचलन बल, धजरज के िगा
के समजनपु जिी होिज है
D Deflection force is inversely proportional to the
square of the Current | विचलन बल, धजरज के िगा के
व्यत्ु िमजनप
ु जिी होिज है
A AC multirange ammeter | एसी मल्टीरें र् एमीटर
B DC multirange voltmeter | डीसी मल्टीरें र् 180 Which source of measuring error is caused
िोल्टमीटर by the effect of magnetic fields? | चुिंबकीय क्षेि के
C AC and DC multirange ammeter | एसी और डीसी प्रिजि के कजरण मजपने की कौन सी िटु ट होिी है?
A By reducing rated voltage | रे टेड िोल्टे र् को कम B Two element 3 phase wattmeter | दो अियि 3
B By increasing the inductive load | प्रेरण िजर को C Three element 3 phase wattmeter | िीन अियि
C By adjusting the brake magnet position | ब्रेक D Three phase two element with C.T & P.T | िीन
चुिंबक की क्स्थनि को समजयोक्र्ि करके चरण दो अियि C.T & P.T के सजथ
D By drilling two holes diametrically opposite on
disc | डडस्क पर दो छे द डड्रल व्यजस के विपरीि
C Induction type instrument | प्रेरण प्रकजर उपकरण A To reduce the disc weight | डडस्क के िर्न को
D Dynamo meter type moving coil | डजयनजमो B Indicates the quantity | मजिज कज सिंकेि दे िज है
मीटर प्रकजर चलकिंु डली C Registers the quantity | मजिज को दर्ा करिज है
D Measures the quantity | मजिज को मजपनज
192 Which meter is used to measure revolution
per minute of a motor? | मोटर के घण
ू न
ा प्रनि लमनट 197 Which position an instrument using gravity
को मजपने के ललए क्रकस मीटर कज उपयोग क्रकयज र्जिज है ? control reads accurately? | गरु
ु त्िजकषाण ननयिंिण कज
उपयोग करने िजलज एक उपकरण क्रकस क्स्थनि में सटीक B Keep high input impedance | उच्च आगि
रूप से पढ़िज है ? प्रनिबजधज रखें
A Any position | क्रकसी िी क्स्थनि में C Use short connecting leads | छोटी कनेक्तटिं ग
B Vertical position | ऊध्िजाधर क्स्थनि लीड कज उपयोग करें
C Inclined position | झुकी हुई क्स्थनि D Provide correct damping system | सही मिंदन
D Horizontal position | क्षैनिर् क्स्थनि प्रणजली प्रदजन करनज
198 Which quantity is measured by an 200 Calculate the value of shunt resistance
electrodynamo type instrument? | एक required to measure 10 mA with one mA meter? |
इलेतट्रोडजयनजमो प्रकजर के उपकरण द्िजरज क्रकस मजिज को एक mA मीटर के सजथ 10 mA मजपने के ललए आि्यक
A 70.5 Kilo calories | 70.5 क्रकलो कैलोरी B Armature coil open | आमेचर किंु डली खुली
C 71.6 Kilo calories | 71.6 क्रकलो कैलोरी D Field winding partially short | क्षेि किंु डली आिंलिक
209 What is the purpose of protection grooves at 213 What is the defect in a single phase pump
various places in a heater base plate? | हीटर बेस motor if it runs with slow speed? | एकल कलज पिंप
प्लेट में विलिन्न स्थजनों पर सरु क्षज खजिंचे कज उद्दे्य तयज मोटर में दोष तयज है , यटद यह धीमी गनि से चलिज है ?
A Radiate the heat properly | ऊष्मज को ठीक से B Open starting winding | खुली िजइिंडडिंग
B Provides voltage level constant | िोल्टे र् स्िर D Capacitor start capacitor run motor | कैपेलसटर
क्स्थर प्रदजन करिज है स्टजटा कैपेलसटर रन मोटर
C Reduces voltage drop in wiring | िजयररिंग में
िोल्टे र् ड्रॉप को कम करिज है 217 What is the name of the circuit? | सक्रकाट कज
ननयि रखिज है
218 Which type of transformer is used for high A Copper loss | िजम्र हजनन
frequency application? | उच्च आिक्ृ त्ि अनप्र
ु योग के B Windage loss | िजयु हजनन
ललए क्रकस प्रकजर के ट्रजिंसफजमार कज उपयोग क्रकयज र्जिज है? C Hysteresis loss | टहस्टै ररसीस हजनन
A Ring core transformer | ररिंग कोर ट्रजिंसफजमार D Eddy current loss | ििंिर धजरज हजनन
B Ferrite core transformer | फेरजइट कोर ट्रजिंसफजमार
C Silicon steel core transformer | लसललकॉन स्टील 222 Calculate the voltage regulation in
percentage of the transformer if the no load voltage
कोर ट्रजिंसफजमार
is 240 volt and full load voltage is 220 volt? |
D Grain oriented core transformer | रिज उन्मख
ु ट्रजिंसफजमार में िोल्टे र् के प्रनििि विननयमन की गणनज
कोर ट्रजिंसफजमार करें , यटद िन्
ू य िजर िोल्टे र् 240 िोल्ट है और पण
ू ा िजर
िोल्टे र् 220 िोल्ट है?
219 What is the relationship between primary
voltage (E1, V1) and secondary voltage (E2, V2) in a A 7.2 %
B 8.3 %
ideal transformer? | एक आदिा ट्रजिंसफजमार में प्रजथलमक
C 8.71 %
िोल्टे र् (E1, V1) और मजध्यलमक िोल्टे र् E2, V2) के बीच D 9.09 %
तयज सिंबध
िं है ?
223 What is the purpose of using laminated core
in transformer? | ट्रजिंसफजमार में टुकड़े टुकड़े में कोर कज
उपयोग करने कज उद्दे्य तयज है ?
A Reduce copper loss | िजम्र हजनन को कम करें
B Reduce hysteresis loss | टहस्टै ररसीस हजनन को
कम करें
A E1= V1 and E2 = V2 | E1= V1 और E2 = V2
C Reduce mechanical loss | यजिंत्रिक क्षनि को कम
B E1 > V1 and E2 > V2 | E1> V1 और E2> V2
करें
C E1 < V1 and E2 < V2 | E1 < V1 और E2 < V2
D Reduce eddy current loss | ििंिर धजरज हजनन को
D E1 = V2 and E2 = V1 | E1 = V2 और E2 = V1
कम करनज
220 What is the function of conservator in
transformer? | ट्रजिंसफजमार में किंर्रिेटर कज कजया तयज है ? 224 What is the cooling method of transformer?
| ट्रजिंसफजमार की िीिलन विथध तयज है ?
A Prevents the moisture entry | नमी के प्रिेि को
रोकिज है
B Transfers the heat to atmosphere | िजयम
ु ड
िं ल में
ऊष्मज को स्थजनजिंिररि करिज है
C Allows to release internal pressure | आिंिररक
दबजि छोड़ने की अनम ु नि दे िज है
A Oil natural cooling | िेल प्रजकृनिक ठिं डज
D Allows expansion of oil level due to load
variation | लोड लिन्निज के कजरण िेल स्िर के विस्िजर B Oil natural air forced cooling | िेल प्रजकृनिक हिज
की अनम
ु नि दे िज है बललि ठिं डज करनज
C Oil forced air forced cooling | िेल बललि हिज
221 Which loss of transformer is determined by बललि ठिं डज करनज
short circuit test? | िॉटा सक्रकाट टे स्ट द्िजरज ट्रजिंसफजमार
D Oil natural water forced cooling | िेल प्रजकृनिक
के क्रकस हजनन कज ननधजारण क्रकयज र्जिज है ?
पजनी बललि ठिं डज
231 Which condition is absolutely essential for D Constant voltage transformers | ननयि िोल्टे र्
parallel operation of two transformers? | दो ट्रजिंसफजमार
ट्रजिंसफजमार के समजनजिंिर सिंचजलन के ललए कौन सी क्स्थनि
त्रबल्कुल आि्यक है ? 235 How does the moisture is controlled in
A Nature of load | िजर की प्रकृनि breather fitted on power transformers? | पजिर
B Type of cooling | िीिलन प्रकजर ट्रजिंसफजमार पर लगे हुए ब्रेदर में नमी को कैसे ननयिंत्रिि
By using grain oriented core | रिज उन्मख परीक्षण द्िजरज क्रकस िक्ति हजनन कज आकलन क्रकयज र्जिज
C ु कोर
कज उपयोग करके है ?
D Use stepped core arrangement | चरणबि कोर A Hysteresis loss only | केिल टहस्टै ररसीस हजनन
व्यिस्थज कज उपयोग करें B Eddy current loss only | केिल ििंिर धजरज हजनन
C Copper loss | िजम्र हजनन
233 What is the name of transformer? | D Core loss | कोर हजनन
ट्रजिंसफजमार कज नजम तयज है ?
237 Which is determined by the crackle test of
transformer oil? | ट्रजिंसफजमार के िेल के िैकल टे स्ट से
क्रकसकज ननधजारण होिज है?
A Acidity | अम्लिज
A Air core transformer | िजयु कोर ट्रजिंसफजमार B Moisture | नमी
B Iron core transformer | आयरन कोर ट्रजिंसफजमार C Viscosity | ्यजनिज
C Ring core transformer | ररिंग कोर ट्रजिंसफजमार D Dielectric strength | परजविद्यि
ु िक्ति
D Ferrite core transformer | फेरजइट कोर ट्रजिंसफजमार
238 Which material is used to make core of
234 Which transformer is used to measure high power transformer? | पजिर ट्रजिंसफजमार कज कोर बनजने
voltage installations? | उच्च िोल्टे र् प्रनिष्ठजनों को के ललए क्रकस सजमग्री कज उपयोग क्रकयज र्जिज है ?
मजपने के ललए क्रकस ट्रजिंसफजमार कज उपयोग क्रकयज र्जिज है? A Soft iron | नमा लोहज
A Pulse transformers | पल्स ट्रजिंसफजमार B Rolled steel | रोल्ड स्टील
B Ignition transformers | इक्ग्निन ट्रजिंसफजमार C Copper alloy | िजाँबज लमथश्रि धजिु
C Potential transformers | वििि ट्रजिंसफजमार D Cold rolled grain oriented | कोल्ड रोल्ड ग्रेन
ओररएिंटेड
िोल्टे र् अनप
ु जि प्रजप्ि करने के ललए
239 What is the name of transformer? |
C To regulate the primary current | प्रजथलमक धजरज
ट्रजिंसफजमार कज नजम तयज है ?
को विननयलमि करने के ललए
D To stabilise input and output voltage | इनपट
ु
और आउटपट
ु िोल्टे र् को क्स्थर करने के ललए
242 Why primary of potential transformer is C Short circuit test | लघु पररपथ टे स्ट
wound with thin wire and large number of turns? | D Open circuit test | खल
ु ज पररपथ टे स्ट
तयों वििि ट्रजिंसफजमार कज प्रजथलमक पिली िजर और बड़ी
सिंख्यज में घम
ु जिों के सजथ किंु डललि क्रकयज र्जिज है ?
A To offer high inductance | उच्च प्रेरण दे ने के ललए
B To obtain required voltage ratio | आि्यक
246 Why ferrite core is used in radio receivers? | D Cannot isolate the secondary winding |
फेरजइट कोर कज उपयोग रे डडयो ररसीिर में तयों क्रकयज द्वििीयक िजइिंडडिंग को अलग नहीिं कर सकिज
र्जिज है ?
250 Which cooling method is used in pole
A To reduce the constant losses | ननयि हजनन को
mounting distribution transformer? | पोल
कम करने के ललए
समजयोक्र्ि वििरण ट्रजिंसफजमार में क्रकस िीिलन विथध कज
B To reduce electric interference | विद्यि
ु
उपयोग क्रकयज र्जिज है?
व्यनिकरण को कम करने के ललए
A Air natural | िजयु प्रजकृनिक
C To increase the quality of sound | ध्िनन की
B Oil natural air blast | िेल प्रजकृनिक िजयु विस्फोट
गण
ु ित्िज बढ़जने के ललए
C Oil forced air forced | िेल बललि हिज बललि
D To increase the efficiency of receivers | ररसीिर
D Oil natural air natural | िेल प्रजकृनिक हिज
की दक्षिज बढ़जने के ललए
प्रजकृनिक
247 What is the advantage of stepped core
251 What is the composition of steel and silicon
arrangement in larger transformers? | बड़े ट्रजिंसफजमार
steel in transformer core? | ट्रजिंसफजमार कोर में स्टील
में चरणबि कोर व्यिस्थज कज तयज फजयदज है ?
और लसललकॉन स्टील की सिंरचनज तयज है ?
A Minimizes copper use | िजिंबे के उपयोग को कम
A Steel 97% and silicon 3% | स्टील 97% और
करिज है
लसललकॉन 3%
B Reduces hysteresis loss | टहस्टै ररसीस हजनन कम
B Steel 95% and silicon 5% | स्टील 95% और
कर दे िज है
लसललकॉन 5%
C Reduces eddy current loss | ििंिर धजरज हजनन को
C Steel 93% and silicon 7% | स्टील 93% और
कम करनज
लसललकॉन 7%
D Reduces the space for core | कोर के ललए र्गह
D Steel 90% and silicon 10% | स्टील 90% और
कम कर दे िज है
लसललकॉन 10%
248 Which material is used in breather to
prevent moisture entering in the transformer oil? | 252 What is the purpose of tap changing in
ट्रजिंसफजमार िेल में नमी को रोकने के ललए ब्रेदर में क्रकस power transformers? | त्रबर्ली ट्रजिंसफजमार में टै प
C Ammonium chloride | अमोननयम तलोरजइड B Change voltage ratio in distribution | वििरण में