Professional Documents
Culture Documents
340 en
SANDVIK CJ408:01
This document is valid for:
SANDVIK CJ408:01
© Copyright 2007 Sandvik SRP AB.
All rights reserved. No parts of this document may be reproduced or
copied in any form or by any means without written permission from
Sandvik SRP AB. All data and information in this manual may be
changed without further notice. Reservations for misprints.
Sandvik SRP AB
Stationsplan, SE-233 81 Svedala, Sweden
Tel: +46 40-40 90 00, Fax: +46 40-40 92 60
www.sandvik.com
Wear Parts Catalog
General
Ordering information
When ordering parts, always state the machine type and serial number
according to the identification plate on the jaw crusher. State quantity, article
number and denomination for each ordered part. (Quantities listed in this
catalog are number of parts that are usually exchanged at the same time in a
certain position or function.)
Identification plate
The figure below shows an example of the crusher’s identification plate. The
identification plate contains data needed when contacting Sandvik SRP AB
concerning wear parts.
Please enter the serial number of the associated machine in the intended field
on the first page of this wear part catalog (the copyright page).
1 2
1 Machine type
2 Serial number
Think ahead!
Avoid unnecessary downtime and increased freight charges by ordering parts
well in advance.
Adjustment shims
5002-0
1211-5
3500-0
1211-6
3400-0 3401-5
1211-5 1210-0 3401-1 3401-6
1211-1 1211-0 3401-5
1211-3
3401-1
3401-3
Jaw plates
1208-1
3300-1
(Continued)
Corrugated
C
Wide teeth
WT
Wear plates
1300-0
3100-0
Support bars
Cheek plates
1103-1 1103-2
1104-1
1104-2
1106-0
1106-4
1106-5
1106-2
1106-1