Professional Documents
Culture Documents
QUICK 492E - Wrist-Strap-Footwear-Tester
QUICK 492E - Wrist-Strap-Footwear-Tester
ESD Safe
This Combo Tester tests both ESD Wrist Straps and ESD Footwears in single instrument.
It is an important equipment to comply with the ANSI ESD S20.20 para 6.1.3.2
‘Compliance Verification Plan’
Features:
• Dual test circuit tests Footwear and Wrist Straps
• LEDs display different test results
• Provides audible alarms besides visual LED indications
• Accuracy: ±10% for ESD Wrist Straps
±20% (100MΩ), ±30% (1GΩ) for ESD Footwears
• 2 connection methods: Banana Jack & Grounding Pole
• Battery powered with low-battery indication
• Test parameters are factory set but can be adjusted
• Optional AC Adaptor is available.
Scope of Supply
- Combo Tester - Bracket
- 9 Volt Battery - Locking Nut
- Face Plate - Screws & Nuts
- Base Plate - Shims
- Grounding Cord
Operation
Plug Grounding Cord of the Wrist Strap into the Tester,
press test button. The following will be test results:
It can also be connected to the door control system with external wire
to prevent the personnel from entering the antistatic places freely.
The personnel Grounding Tester PGT 120 is a wrist strap and footwear tester for access control of
ESD protected Areas (EPA). Used for compliance with the ANSI ESD S20.20 para 6.1.3.2
‘Compliance Verification Plan’.
Features:
• Simultaneous testing of wrist strap, right and left shoe
• Separate measurement of right and left foot
• LEDs display different test results
• Test result is indicated with audible and visual LED indications
• Can be used on becnh tops or as a wall mounted unit
(Wall mounting requires an additional wall mounting plate
• Battery powered with low-battery indication
• Optional AC Adaptor is available.
• Lower limit disabling is possible.
also available with
Specifications: RS232 interface
• Floor Plates : Aluminum
• Unit dimensions : 150 x 200 x 65mm
• Foot Plate size : 350 x 500 x 8 mm
• Battery : 9 volt
• LEDs : (6) Low, High & Pass
• Alarm : Internal buzzer
• External Power : AC/DC (optional) Footwear Electrode
for separate shoe testing
Limit Values and Measure Mode: (350 x 500 x 8mm)
140 MΩ or 70 MΩ
Footwear in series (both shoes in series) ----
Note: Special version of the Personnel Grounding Tester PGT®120 with RS232 interface is also available
Scope of Supply (Model PGT120.COM) P/N: 7100.PGT120.COM
- Main PGT120 Combo Tester with RS232 - Footwear Electrode
- 9 Volt Battery - User Manual & Calibration Certificate
shown trademarks are property of their respective owners.
While the information contained herein in, has been carefully compiled to the best of our knowledge, nothing is intended as representation and warranty on our part; and no statement shall be construed as recommendation to infringe any of existing
patents. We accept no liability of whatsoever for any faults and errors in the information contained herein. Contents of this catalogue and specifications of the products, are subject to change without notice due to continuous improvements.
157
Email: headoffice@indeonline.in Fax: 0172-4640415 Cell: 09316134502 Landline: 0172-6535745 www.indeonline.in