Professional Documents
Culture Documents
Medb00004x5 2
Medb00004x5 2
Application of: Directive 2014/90/EU of 23 July 2014 on marine equipment (MED), issued as "Forskrift
om Skipsutstyr" by the Norwegian Maritime Authority. This Certificate is issued by DNV GL AS under the
authority of the Government of Norway.
This is to certify:
That the Sewage systems
Issued to
TECNICOMAR S.P.A.
Marsala, TP, Italy
Further details of the equipment and conditions for certification are given overleaf.
...
Approval Engineer:
Notified Body Roald Vårheim
Thomas Grafton
No.: 0575 Head of Notified Body
The mark of conformity may only be affixed to the above type approved equipment and a Manufacturer’s Declaration of Conformity
issued when the production-surveillance module (D, E or F) of Annex B of the MED is fully complied with and controlled by a written
inspection agreement with a Notified Body. The product liability rests with the manufacturer or his representative in accordance with
Directive 2014/90/EU.
This certificate is valid for equipment, which is conform to the approved type. The manufacturer shall inform DNV GL AS of any
changes to the approved equipment. This certificate remains valid unless suspended, withdrawn, recalled or cancelled.
Should the specified regulations or standards be amended during the validity of this certificate, the product is to be re-approved
before being placed on board a vessel to which the amended regulations or standards apply.
© DNV GL 2014. DNV GL and the Horizon Graphic are trademarks of DNV GL AS.
Job Id: 344.1-008923-2
Certificate No: MEDB00004X5
Revision No: 2
Product description
The ECOmar S series treats batches of sewage using the following process: i) transfer of a fixed amount
of sewage from a holding tank to a treatment tank, ii) chemical treatment and addition of a flocculant, iii)
adding a fixed amount of dilution water, iv) maceration and return to treatment tank, v) filtration and UV
treatment prior to overboard discharge, vi) washing of the tank and discharge of the waste (sewage
sludge) to sludge holding tank.
The chemical treatment and flocculation processes uses hydrogen peroxide and ECOFLOC (based on
poly-aluminium chloride and polyelectrolyte). After the chemical treatment the sewage batch is diluted
with sea water (within the limits prescribed in IMO Res.MEPC.227(64)).
Application/Limitation
Application: -
Model Hydraulic Loading (litres/day) (*) Organic Loading, BOD5 without nitrification
(kg/day)
ECOmar 20 S 2,000 0.70
ECOmar 32 S 3,200 1.12
ECOmar 45 S 4,500 1.58
ECOmar 70 S 7,000 2.46
ECOmar 145 S 14,500 5.09
ECOmar 230 S 23,000 13.89
ECOmar 340 S 34,000 20.54
ECOmar 545 S 54,500 32.92
Dilution water may be either salt water (sea water) or fresh water.
The ECOmar S series may be used on Passenger Ships in Special areas (ref. IMO Res.MEPC.227(64)
Section 4.2).
Installation Requirements: -
Sewage Sludge shall be directed to a sludge tank/holding tank, as shown in the Piping Diagrams / Flow
Diagrams listed in the Type Examination documentation.
Limitations: -
The design of structural tanks constructed by the shipyard (e.g. Collecting Tanks, Sludge Tanks, etc.)
are not evaluated as part of the type examination.
The ship should have on board at all times a copy of the Operation and Maintenance Manual listed in
‘Type Examination documentation’.
A copy of this certificate should be carried on board any ship equipped with the sewage treatment plants
described above.
Performance Tests: -
Environmental Test: -
Marking of product
Minimum pH:
Type of disinfectant used:
If Chlorine - residual Chlorine:
Maximum:
Minimum:
Geometric mean:
Was the sewage treatment plant tested against the environmental conditions specified in section 5.9 of
resolution MEPC.227(64):
Temperature:
Humidity:
Inclination:
Vibration:
Reliability of Electrical and Electronic
Equipment:
Temperature:
Humidity:
Inclination:
Vibration:
Minimum pH:
Type of disinfectant used:
If Chlorine - residual Chlorine:
Maximum:
Minimum:
Geometric mean:
Was the sewage treatment plant tested against the environmental conditions specified in section 5.9 of
resolution MEPC.227(64):
Temperature:
Humidity:
Inclination:
Vibration:
Reliability of Electrical and Electronic
Equipment:
Temperature:
Humidity:
Inclination:
Vibration: