Professional Documents
Culture Documents
Features
BIRDIES
Birdies are frequencies your scanner uses when it operates. These
operating frequencies might interfere with broadcasts on the same
frequencies. If you program one of these frequencies, you hear noise on
that frequency.
If the interference is not severe, you might be able to turn SQUELCH
clockwise to cut out the birdie. The most common birdies to watch for are
listed below.
Birdie Frequencies
31.050 MHz
32.400
36.225
41.400
46.575
51.750
MHz
MHz
MHz
MHz
MHz
RECEPTION NOTES
Reception of the frequencies covered by your scanner is mainly "line of
sight." That means you usually cannot hear stations that are beyond the
horizon.
During the summer months, you might be able to hear stations in the 30-50
MHz range located several hundred or even thousands of miles away. This
is because of summer atmospheric condition. This type of reception is
unpredictable but often very interesting!
GUIDE TO THE ACTION BANDS
With a little investigation, you can find the active frequencies in your
community. We can give you some general pointers on finding these
frequencies and you can take it from there. Please use caution and common
sense when you hear an emergency call. Never go to the scene of an
emergency. It could be very dangerous.
Find out if there is a local club that monitors your community's
frequencies. Perhaps a local electronics repair shop that works on
equipment similar to your scanner can give you frequencies used by local
services. A volunteer police department or fire department employee can
also be a good source for this information.
As a general rule on VHF, most activity concentrates between 153.785 and
155.98 MHz and between 153.73 and 159.45 MHz. Here you find local
government, police, fire, and most other emergency services. If you are
near major railroad tracks, listen between 160.0 and 161.9 for signals.
In some larger cities, there has been a move to the UHF bands for
emergency services. Here, most of the activity is between 453.025 and
453.95 MHz and between 456.025 and 459.95 MHz.
In the UHF band, mobile units operate between 456.025 and 459.95 MHz and
between 465.025 and 469.975 MHz. A repeater picks up the mobile units'
transmissions on one frequency, then rebroadcasts (or repeats) the
transmission 5 MHz lower, but at a higher power level, than the mobile
units (that is 451.025-454.95 MHz and 460.025-464.975 MHz). This means
that if you find an active frequency inside one of the mobile unit's
frequency spreads, you can look 5 MHz lower to find the repeater
frequency.
A system called trunked radio lets several services use the same set of
frequencies in the 800 MHz band without interference. Several frequencies
are allocated to two or more services (like fire, police, and water
departments). As each service transmits, a separate control signal
activates other radios in the same service, so that only that service
hears the transmission. The frequency is selected as soon as the unit
begins to transmit, and could be any one of the allocated frequencies.
One very useful service is the National Weather Service's continuous
35.02-35.18..................Bus.
35.22-35.66......Mob. Tel. & Page
35.70-35.72..................Bus.
35.74-35.98.......Sp. Ind. & Bus.
36.00-37.00.................Govt.
37.02-37.44.......P.D. & L. Govt.
37.46-37.86.................Power
37.90-37.98......Hwy. & Sp. Emer.
38.00-39.00.................Govt.
39.02-39.98.......P.D. & L. Govt.
40.00-42.00.................Govt.
42.02-42.94..............St. P.D.
42.96-43.18.......Sp. Ind. & Bus.
43.22-43.68........Mob. Tel. Page
43.70-44.60..........Trucks. Bus.
44.62-45.06...St. P.D. For. Cons.
45.08-45.66..................P.D.
45.68-46.04...P.D. Hwy.,Sp. Emer.
46.06-46.50..................F.D.
46.52-46.58..............L. Govt.
46.60-47.00.................Govt.
47.02-47.40..............St. Hwy.
47.42...................Red Cross
47.44-47.68....Sp. Ind. Sp. Emer.
47.70-48.54.................Power
48.56-49.58.......For. Prod.,Pet.
49.60-50.00.................Govt.
50.00-54.00.......6 Meter Amateur
(Ham) Band
108-136.975 MHz BAND
108.000-118.000....Air Navagation
118.000-136.975..........Aircraft
137-174 MHz BAND
137.000-144.000.............Govt.
144.000-148.000...............HAM
148.010......................MARS
148.150.......................CAP
148.155-148.250...............MIL
148.290-150.750...............USN
150.815-150.995..............Bus.
151.010-151.130...............HWY
151.145-151.475.......Fors. Cons.
151.505-151.595..........Sp. Ind.
32.00-33.00....................Govt.
33.02-33.16....Hwy., Sp. Emer., Bus.
33.18-33.38.....................Pet.
33.42-33.98.....................F.D.
34.00-35.00....................Govt.
151.625-151.955..............Bus.
151.985-152.240...Mob. Tel. (RCC)
152.270-152.450..............Taxi
152.480-152.840....Mob. Tel. Page
152.870-153.020...Sp.Ind. Mot. P.
451.775-451.975.........Spec. Ind.
452.000-452.500.........Taxi, Mot.
Carrier, R.R.
452.525-452.600..........Auto Club
452.625-452.975..L.Govt.,P.D.,F.D.
454.000-454.975..........Mob. Tel.
455.000-455.975.........Remote Br.
456.000-458.975....P.D.,F.D.,Ind.,
Lan. Tr.
459.000-459.975....Domestic Public
460.000-460.625.........P.D., F.D.
460.650-462.175...............Bus.
462.200-462.450...............Taxi
462.750-462.975...............Bus.
463.000-463.175............Medical
463.200-464.975...............Bus.
465.000-467.500...P.D., F.D.,Ind.,
Land Tr.
467.750-467.925...............Bus.
467.7375-469.975.Pub. Safety, Ind.
Land Tr.
474.8125-475.3375................Bus.
475.3625-475.4375................Taxi
475.4625-475.7875........R.R., Motor
Carrier, Auto Emer.
475.8125-475.9876...Pet., For. Prod.,
Mfg.
806-947 MHz BAND
806.000-816.000.......Domestic Public
(Mobile)
816.000-821.000.......Mobile Trunking
851.000-861.000.......Domestic Public
(Base)
861.000-866.000.........Base Trunking
902.000-928.000.Industrial Scientific
These frequencies are subject to change and might vary some from area to
area. For a more complete listing, refer to the Police Call Radio Guide
Including Fire and Emergency Services at your local Radio Shack store.
You might discover one of your regular stations on a frequency that is not
listed. This could be what is known as an "image." For example, if you
find a station on 453.2750 that you also hear on 474.8750, do a little
math to see if it is an image. Take the intermediate frequency of 10.8
MHz and double it (21.6 MHz). Then subtract 21.6 MHz from the "new"
frequency. If the answer is the normal frequency, you have tuned to an
image. Occasionally, you might get interference on a weak or distant
channel from a strong broadcast 21.6 MHz (2 x 10.8 MHz) below the tuned
frequency. this is rare, and the image signal is usually cleared whenever
a broadcast on the actual frequency is in progress.
(ALL-11/08/94)
-------------------------------------------------------------------------------PRO-Series Direct Entry Programmable Scanners
General Guide To Scanning
Birdies
Birdies are frequencies your scanner uses when it operates. These
operating frequencies might interfere with broadcasts on the same
frequencies. If you program one of these frequencies, you hear only noise
on that frequency.
If the interference is not severe, you might be able to turn SQUELCH
clockwise to cut out the birdie. The most common birdies to watch for are
listed below.
Birdie Frequencies:
31.05 MHz
41.40 MHz
51.75 MHz
113.85 MHz
124.20
134.55
144.90
155.25
MHz
MHz
MHz
MHz
Reception Notes
Reception of the frequencies covered by your scanner is mainly "line of
sight". That means you usually cannot hear stations that are beyond the
horizon. During the summer months you may be able to hear stations in the
30-50 MHz range located several hundred or even thousand of miles away.
This is because of summer atmospheric conditions. This type of reception
is unpredictable but often very interesting!
One very useful service is the National Weather Service's continuous
weather broadcast. These broadcasts contain weather forecasts and data
for the areas around the station, plus bulletins on any threatening
weather conditions. These stations use three frequencies - 162.40,
162.475 or 162.55 MHz. In most areas of the country, you can receive one
of these frequencies.
A Guide To The Action Bands
With the right frequencies programmed into your PRO-Series Scanner, you
can monitor exciting events. With a little investigation, you can find
active frequencies in your community. We can give you some general
pointers, and you can take it from there. Please use caution and common
sense when you hear an emergency call. Never go to the scene of an
emergency. It could be very dangerous.
Find out if there is a local club that monitors your community's
frequencies. Perhaps a local electronics repair shop that works on
equipment similar to your scanner can give you frequencies used by local
radio services.
A volunteer police department or fire department can also be a good source
for this information.
As a general rule on VHF, most activity is concentrated between 153.785
and 155.98 MHz and then again from 158.73 to 159.46 MHz. Here you find
local government, police, fire and most such emergency services. If you
are near a railroad yard or major railroad tracks, look around 160.0 to
161.9 MHz for signals.
In some larger cities, there has been a move to the UHF bands for
emergency service. Here, most of the activity is between 453.025 and
453.95 MHz and between 456.025 and 467.925 MHz.
In the UHF band, frequencies between 456.025 and 459.95 MHz and between
465.025 and 469.975 MHz are used by mobile units and control stations
associated with base and repeater units that operate 5 MHz lower (that is,
451.025 to 454.950 and 460.025 to 464.975 MHz). This means that if you
find an active frequency inside one of these spreads, you can look 5 MHz
lower (or higher) to find the base station/repeater for that service.
Typical Band Usage
The following is a brief listing of the typical services that use the
bands you scanner can receive. This listing helps you decide which ranges
you would like to scan.
These frequencies are subject to change, and might vary from area to area.
For a more complete listing refer to the Police Call Radio Guide available
at you local RadioShack store.
Abbreviations:
Affiliate Radio System: ............................................. Mars
161.650
161.775
162.400
162.425
5)
6)
7)
8)
162.440
162.450
162.475
162.500
9) 162.525
10) 162.550
11) 163.275
Frequency
(MHz)
28.000-29.700
50.000-54.000
144.000-148.000
70-cm
420.000-450.000
The following are the channels and frequencies of the Citizens Band:
1)
2)
3)
4)
5)
6)
7)
8)
9)
10)
11)
12)
13)
14)
15)
16)
17)
18)
19)
20)
26.965
26.975
26.985
27.005
27.015
27.025
27.035
27.055
27.065
27.075
27.085
27.105
27.115
27.125
27.135
27.155
27.165
27.175
27.185
27.205
21)
22)
23)
24)
25)
26)
27)
28)
29)
30)
31)
32)
33)
34)
35)
36)
37)
38)
39)
40)
27.215
27.225
27.255
27.235
27.245
27.265
27.275
27.285
27.295
27.305
27.315
27.325
27.335
27.345
27.355
27.365
27.375
27.385
27.395
27.405
Allocation
MHz
MHz
MHz
MHz
MHz
MHz
MHz
MHz
MHz
MHz
MHz
311.00
406.00
420.00
450.00
470.00
851.00
856.00
861.00
866.00
869.00
935.00
940.00
384.00
470.00
450.00
470.00
806.00
856.00
861.00
866.00
869.00
894.00
940.00
941.00
MHz
MHz
MHz
MHz
MHz
MHz
MHz
MHz
MHz
MHz
MHz
MHz
Primary Usage:
As a general rule, most of the radio activity is concentrated on the
following frequencies:
VHF Band:
2-Meter Amateur Band: ..............................
Government, police, and Fire: ......................
Emergency Services: ................................
Railroad: ..........................................
144.000
153.785
158.730
160.000
148.000
155.980
159.460
161.900
MHz
MHz
MHz
MHz
440.000
450.000
451.025
456.025
460.025
465.025
450.000
470.000
454.950
459.950
464.975
469.975
MHz
MHz
MHz
MHz
MHz
MHz
UHF Band:
.6 cm Amateur Band FM Repeaters: ...................
Land Mobile "Paired" Frequencies: ..................
Base Stations: .....................................
Mobile Units: ......................................
Repeater Units: ....................................
Control Stations: ..................................
NOTE: UHF remote control stations and mobile units typically operate at 5
MHz higher than their associated base and relay repeater units.
Specified Intervals
Frequencies in different bands are accessible only at specific intervals.
For Example:
VHF, HAM, and Government: .................................. 5.0 kHz steps
All Others: ............................................... 12.5 kHz steps
Aircraft: ................................................. 25.0 kHz steps
Note: Your scanner rounds the entered frequency to the nearest valid
frequency. For example, if you try to enter 151.473, the scanner
might accept this as 151.470.
Band Allocation
To help you decide which frequency ranges to search, use the following
listing of the typical services that use the frequencies your scanner
receives. These frequencies are subject to change, and might vary from
area to area. For a more complete listing, refer to the "Police-Call Radio
Guide including Fire and Emergency Services", as well as "Beyond Police
Call", "Aeronautical Directory", "Nautical Directory" and "Now you're
Talking" texts available at your local RadioShack store.
Abbreviations
AIR: ............................................................ Aircraft
BIFC: .................................. Boise (ID) Interagency Fire Cache
BUS: ............................................................ Business
CAP: .................................................... Civil Air Patrol
CB: ........................................................ Citizens Band
CCA: ...................................................... Common Carrier
CSB: ................................................ Conventional Systems
CTSB: ....................................... Conventional/Trunked Systems
FIRE: .................................................... Fire Department
HAM: ................................................. Amateur (HAM) Radio
GOVT: ................................................. Federal Government
GMR: ................................................ General Mobile Radio
GTR: ..................................................... General Trunked
IND: ................................................. Industrial Services
MARI: ............................................. Maritime Limited Coast
MARS: .................................... Military Affiliate Radio System
MED: .......................................... Emergency/Medical Services
MIL: ....................................................... U.S. Military
MOV: ....................................... Motion Picture/Video Industry
NEW: ................................................... New Mobile Narrow
NEWS: ........................................................ Relay Press
OIL: .............................................. Oil/Petroleum Industry
POL: ................................................... Police Department
PUB: ..................................................... Public Services
PSB: ....................................................... Public Safety
PTR: ..................................................... Private Trunked
ROAD: ......................................... Road & Highway Maintenance
RTV: .................................... Radio/TV Remote Broadcast Pickup
TAXI: ...................................................... Taxi Services
TELBL: .................................................. Mobile Telephone
TELC: ................................................ Cordless Telephones
TELM: .............................................. Telephone Maintenance
TOW: .......................................................... Tow Trucks
TRAN: ............................................ Transportation Services
TSB: ..................................................... Trunked Systems
TVn: ............................................... FM-TV Audio Broadcast
USXX: .............................................. Government Classified
UTIL: ............................................ Power & Water Utilities
WTHR: ............................................................ Weather
High Frequency (HF)-(3 - 30 MHz):
High Band - (25.00 - 27.36 MHz):
25.020
25.870
26.62:
26.966
27.430
............................................................. TV7
............................................................. TV8
............................................................. TV9
............................................................ TV10
............................................................ TV11
............................................................ TV12
............................................................ TV13
......................................................
......................................................
......................................................
......................................................
Channel
Channel
Channel
Channel
14
15
16
69
Note: Some cities use the 470-512 MHz band for land/mobile service.
Conventional Systems Band - Locally Assigned
851.0125 - 855.9875: ................................................. CSB
Conventional/Trunked Systems Band - Locally Assigned
856.0125 - 860.9875: ................................................ CTSB
Trunked Systems Band - Locally Assigned
861.0125 - 865.9875: ................................................. TSB
Public Safety Band - Locally Assigned
866.0125 - 868.9875: ................................................. PSB
Common Carrier
869.010 - 894.000: ................................................... CCA
Private Trunked
935.0125 - 939.9875: ................................................. PTR
General Trunked
940.0125 - 940.9875: ................................................. GTR
Frequency Conversion
The tuning of a station can be expressed in frequency (kHz or MHz) or in
wavelength (meters). The following information can help you make the
necessary conversions.
Operation
CAUTION: This procedure clears all the information you have programmed
into the scanner. Use this procedure only when you are sure
your scanner is not working properly.
1. Turn off the scanner.
2. While you press and hold down 2 and 9, turn on the scanner.
SETTING THE VOLUME AND SQUELCH
Use SQUELCH to decrease the scanner's sensitivity to weak signals. This
allows the scanner to receive only the strongest transmissions.
1. Turn SQUELCH and VOLUME fully counterclockwise.
2. Turn VOLUME clockwise until you hear a hissing sound.
3. Slowly turn SQUELCH clockwise until the hissing stops.
If you want to listen to a weak or distant station, turn SQUELCH
counterclockwise. You might hear hissing between transmissions.
STORING FREQUENCIES INTO CHANNELS
A good reference for active frequencies is Radio Shack's Police Call
Directing Including Fire and Emergency Services. We update this directory
yearly, so be sure to get a current one. Also, refer to "Reception
Notes," "Searching For Active Frequencies," and "Using the Band Search
Keys" in this manual.
1. Turn VOLUME clockwise to turn on the scanner.
2. Press MANUAL, enter the channel number you want to program, and press
PROG. PGM appears on the display and shows that your scanner is in
the programming mode.
3. Use the keypad to enter a frequency.
4. Press ENTER to store the frequency. If you made a mistake in Step 3,
ERROR appears on the display and the scanner sounds three beeps. To
clear the display, press CLEAR. Then, proceed again from Step 3.
Your scanner automatically rounds the entered frequency to the nearest
valid frequency. For example, if you try to enter a frequency of
151.473, your scanner accepts it as 151.475.
5. If you want your scanner to pause after each transmission before
scanning to the next channel, press ./DELAY until DLY appears on the
display. See "Using the Delay Feature."
6. To program more channels, repeat Steps 2 through 5. If you want to
program the next channel in sequence, simply press PROG and repeat
Steps 3 through 5.
SEARCHING FOR ACTIVE FREQUENCIES
Use the following procedure to search for a transmission. This procedure
is helpful if you do not have a reference to frequencies in your area.
Also see "Guide to the Action Bands."
1. Press MANUAL, the channel number you want to store the monitor
frequency in, and PROG.
2. Press MONITOR.
3. Press ENTER. The scanner stores the frequency in the selected
channel.
4. If you want to return to a frequency search after this procedure,
press LIMIT, followed by either /\ or \/.
SCANNING THE CHANNELS
To begin scanning the channels, press SCAN. Your
all the channels (except the ones you have locked
in the banks you have turned on. Be sure to read
to get the full benefit from the special features
You can set the scanner to skip over complete banks of channels.
To turn banks on and off, first press SCAN.
To turn on a bank, press the number key that corresponds to that bank
until the bank indicator (a small bar) appears under the bank number.
The scanner can scan all the channels within that bank (except the ones
that you have locked out).
To turn off a bank, press the number key that corresponds to that bank
until the bank indicator disappears from under the bank number.
The scanner can not scan any of the channels within that bank. You can
manually select any channel in that bank.
NOTE: You can turn off all but one bank.
USING THE PRIORITY FEATURE
The scanner automatically checks for a transmission every 2 seconds on the
channel you designate as the priority channel, even if you are listening
to another channel or scanning. To program a priority channel, press
PROG,, the desired channel number, and then PRIORITY.
The priority indicator P appears on the display to show that you set the
scanner to the priority channel.
You can only program one channel as the priority channel. When you
program a new channel as the priority channel, you clear the previous
channel you chose.
NOTE: Channel 1 is automatically designated as the priority channel the
first time you turn on the scanner.
MANUALLY SELECTING A CHANNEL
You can continuously listen to a single channel without scanning. This is
useful if you hear an emergency broadcast on a channel and do not want
to miss any of the details -- even though there might be periods of
silence -- or if you want to monitor a channel that you have locked out.
To select a channel to listen to, press MANUAL, enter the channel number,
and then press MANUAL again. Or, if your scanner is scanning and has
stopped at the desired channel, press MANUAL one time. Pressing MANUAL
additional times causes your scanner to step through the channels one at a
time.
(ALL-11/08/94)
-------------------------------------------------------------------------------PRO-2026 (200-0148)
Preparation
that the scanner is located so that the passengers have enough leg room.
1. Choose a mounting location. Then, use the mounting bracket as a
template to mark the position for the mounting screw holes.
2. In the marked positions, drill holes slightly smaller than the
supplied screws. Take care not to drill into or damage objects behind
the mounting surface.
3. Attach the bracket using the supplied self-tapping screws and lock
washers.
4. Attach the scanner to the bracket using the mounting knobs.
CONNECTING THE ANTENNA
Purchase the magnet-mount mobile all-band antenna (Cat. No. 20-012) and
Motorola-to-BNC plug adaptor (Cat. No. 278-117). Follow the instructions
provided with the antenna for installation.
For best results, mount the antenna:
As high as possible on the vehicle
In a vertical position
After you mount the antenna, route the antenna's cable to the scanner and
connect the cable to the scanner's ANT jack.
CAUTIONS: Do not run the cable over sharp edges or moving parts that
could damage the cable.
Do not run the cable next to power cables or other antenna
cables.
Do not run the cable through areas in the engine compartment
that produce extreme heat.
CONNECTING TO POWER
We designed your scanner to connection to 12-volt power systems. The red,
orange, and black wires extending from the back of your scanner are for
power connections.
1. Connect the red wire to a terminal that provides power only when you
turn the ignition to ON or ACC.
2. Connect the orange wire to a continuous 12-volt source (either
directly to the battery's positive terminal or to a fuse terminal that
the ignition key does not switch.) This wire provides continuous
power for the memory when the ignition is turned off.
3. Connect the black wire to a metal part of the vehicle's frame (chassis
ground).
NOTE: Modern vehicles have many non-metallic parts. If you connect the
black wire to a nonmetallic part, or if a nonmetallic part
insulates the wire from the vehicle's chassis, the scanner does not
work.
(ALL-11/08/94)
-------------------------------------------------------------------------------PRO 2026
(200-0148)
Specifications
Unit
Limit
microV
0.5
2.0
0.7
3.0
UHF Band
0.7
4.0
Aircraft
1.6
8.0
0.8
5.0
30~50.0 MHz
Nominal
0.4/25 1.0/20
0.5/25 1.2/20
UHF Band
0.4/25 1.8/20
Aircraft
0.4/15 2.0/l0
0.9/25 3.0/20
at 40.0 MHz dB
50
35
at 155.0 MHz dB
45
30
UHF Band
at 460.0 MHz dB
35
25
Aircraft
at 127.0 MHz dB
45
30
at 860.0 MHz dB
33
25
Low Hz
250
150-350
High Hz
2200
1500-3500
Signal to Noise
mW
1100
500
mW
970
400
1.5
kHz
+/-12
+/-5
kHz
+/-11
+/-15
kHz
+/-15
+/-20
dB
60
50
mV
0.2
Scan Rate
CH/Sec.
14
12
Scan Delay
Sec.
1~3
-50 dB
Current Drain
(at full output)
(squelched)
(keep alive)
mA DC
mA DC
microA DC
420
230
3
300~500
300
50
Note: Nominal specs represent the design specs. All units should be able
to approximate these - some will exceed and some may drop slightly
below these specs. Limit specs represent the absolute worst
condition that still might be considered acceptable; in no case
should a unit fail to meet limit specs.
(br/all-8/9/94)
-------------------------------------------------------------------------------PRO-2026 (200-0148)
CT006
CT001 CT002 CT003
CT004
L016
L012
L027
L028
L014
L018
L002 L021
L008
L004 L009
L023
10511707
10511798
10511798
11411691
11411691
10512176
10512176
10513174
10513174
10516136
10516136
10516458
10516458
11334232
10555951
10555969
11287612
10560258
10560258
10561660
10562320
10562338
10562346
11272275
11390481
10563088
11441375
L026
L022
L003 L201
L013
L029
L025
FT001
C032
10563948
10567824
10569929
11561214
11561214
10575645
10575645
10575645
10575660
10575660
10575678
10575678
C027
C012
C063
C004
C079
C003
C022
C046
C071
C087
C099
C142
C187
C023
C077
C039
C202
C006
C026
C053
C078
C091
C134
C149
C028 C031
C057
C203
C016
C033
C054
C082
C093
C137
C161
C064
C205
C018
C038
C066
C084
C098
C138
C174
10575751
10575751
10575793
10575793
10575793
10575793
10575793
10575793
10575793
10575793
1TD0127
XSTR 2SC3121 BIPOLAR MICR 1TD0144
1TD0144
XSTR 2SD1676
1TD0209
REPLACED BY 2TR1573
1TD0209
XSTR 2SC3121-T5L
1TD0211
SOT-23
1TD0211
XSTR SC DTA114YK
1TD0452
1TD0452
XSTR 2SA1162-Y SI LOW PWR 1TD0760
1TD0760
XSTR 2SC2712-Y SI LOW PWR 1TD0793
1TD0793
2SD1676
STOCK 20-012
A0000X
CAP,TRIMMER CT-064 20PF
C2012
CAP,TRIMMER 35PF
C2013
CAP,TRIMMER CT-065 50PF
C2014
COIL,LB704 CAN TYPE
CA0059
COIL,LE-293 D6.96 1/2T
CA1548
COIL,LB539 CAN TYPE
CA1752
CA1752
COIL,LF-149
CA2686
COIL,LB607 CAN TYPE
CA3064
COIL,LB-799 CAN TYPE
CA3065
COIL,LE-127 D2.5 2 1/2TRN CA3069
COIL,LE-353 D6.35 1/2TURN CA3070
COIL,LF207 SMALL CAN TYPE CA3071
COIL,CAN TYPE LB-568
CA3136
8 PIN DIP
CA3140A
COIL,INDUCTOR .56UH
CA3484
COIL LB-644
CA3778
COIL
CA3799
INDUCTOR,MOLDED
CA3801
COIL,INDUCTOR MOLDED
CA3802
COIL,BEADS LD087
CA8742
FILTER,CRYSTAL FL-177
CB0550
CAP CER 50V 1PF +-.25PF
CDA010CJBC
CASE OF 0805 PKG OF 5
CDA010CJBC
CAP CER 50V 3PF +-.25PF
CDA030CJBC
CASE 0805 PKG OF 5
CDA030CJBC
CDA030CJBC
CAP CER 50V 4PF +-.25PF
CDA040CJBC
CASE 0805 PKG OF 5
CDA040CJBC
CAP CER 50V 5PF +-.25PF
CDA050CJBC
CASE 0805 PKG OF 5
CDA050CJBC
8PF
+-.25PF 50V CER CDA080CJBC
CASE 0805 PKG OF 5
CDA080CJBC
CAP CER 50V 10PF +-.5PF
CDA100DJBC
CASE 0805 PKG OF 5
CDA100DJBC
CAP CER 50V 100PF +-5
CDA101JJBC
CASE 0805 PKG OF 5
CDA101JJBC
CAP CER 1000PF +-10 50V
CDA102KJBC
CASE 0805 PKG OF 5
CDA102KJBC
CDA102KJBC
CDA102KJBC
CDA102KJBC
CDA102KJBC
CDA102KJBC
CDA102KJBC
C002
C094
C167
C047
10575835
10575835
10575835
10575892
10575892
C109
C040 C092
C162
C029
C141
C117 C123 C181
C111 C132 C136
C081 C089 C116 C062
C007 C017 C069 C083
C139
C096
C072 C147
C144
C097 C155
C146 C076
C101 C106 C107
C036 C108 C122 C133
C048 C049 C118 C119
C121 C126 C128
C061
C042
C001
10575983
10575983
10576049
10576049
10576056
10576056
11561297
11561297
10576130
10576130
10576205
10576205
10576239
10576239
10576288
10576288
10576304
10576304
10576320
10576320
11561321
11561321
11561339
11561339
10576379
10576379
10576403
10576403
10576411
10576411
10576429
10576429
10576528
10576528
11561354
11561354
10577351
10577351
C013
X001
Y201
D001
D016
D024
D034
D008
D017
D018
D003
D019
D027
D038
D009
D026
D031
D006
D022
D028
D039
D011
D033
D032
D014
D023
D029
D041
D013
D037
D002 D004
D021 D043 D044 D046
10592418
10596138
10617280
10617280
10617280
10617280
10617546
10617546
10617587
10617587
10623312
10623312
10624450
.01UF +-10
25V
CASE 0805 PKG OF 5
CER CDA103KFBC
CDA103KFBC
CDA103KFBC
.1UF
+80-20 25V CER CDA104ZFBC
CASE 0805 PKG OF 5
CDA104ZFBC
1200PF +-10
50V CER CDA122KJBC
CASE 0805 PKG OF 5
CDA122KJBC
15PF
+-5
50V CER CDA150JJBC
CASE 0805 PKG OF 5
CDA150JJBC
.015UF +-10
50V CER CDA153KJBC
CASE 0805 PKG OF 5
CDA153KJBC
CAP CERAMIC 50V 18PF +-5 CDA180JJBC
CASE 0805 PKG OF 5
CDA180JJBC
CAP CER 50V 1.5PF +-.25PF CDA1X5CJBC
CASE 0805 PKG OF 5
CDA1X5CJBC
CAP CERAMIC 50V 220PF +-5 CDA221JJBC
CASE 0805 PKG OF 5
CDA221JJBC
CAP CER 50V .022UF +-10
CDA223KJBC
CASE 0805 PKG OF 5
CDA223KJBC
CAP CER 27PF +-5 50V
CDA270JJBC
CASE 0805 PKG OF 5
CDA270JJBC
33PF
+-5
50V CER CDA330JJBC
CASE 0805 PKG OF 5
CDA330JJBC
330PF +-5
50V CER CDA331JJBC
CASE 0805 PKG OF 5
CDA331JJBC
3300PF +-10
50V CER CDA332KJBC
CASE 0805 PKG OF 5
CDA332KJBC
CAP CER 50V .033UF +-10
CDA333KJBC
CASE 0805 PKG OF 5
CDA333KJBC
39PF
+-5
50V CER CDA390JJBC
CASE 0805 PKG OF 5
CDA390JJBC
47PF
+-5
50V CER CDA470JJBC
CASE 0805 PKG OF 5
CDA470JJBC
470PF +-5
50V CER CDA471JJBC
CASE 0805 PKG OF 5
CDA471JJBC
CAP CER 50V 4700PF +-10
CDA472KJBC
CASE 0805 PKG OF 5
CDA472KJBC
CAP CER 25V .047UF +-10
CDA473KFBC
CASE 0805 PKG OF 5
CDA473KFBC
CAP CERAMIC 50V 56PF +-5 CDA560JJBC
CASE 0805 PKG OF 5
CDA560JJBC
CAP CERAMIC 50V 68PF +-5 CDA680JJBC
CASE 0805 PKG OF 5
CDA680JJBC
1PF
+-.25 50V CER CDR010CJBC
CASE 1206 PKG OF 5
CDR010CJBC
4PF
+-.25PF 50V CER CDR040CJBC
CASE 1206 PKG OF 5
CDR040CJBC
CRYSTAL,10.35MHZ
CX0590
RESONATOR,CERAMIC YY-1022 CX1197
DIODE HSK110 SI
DD0022
ORANGE GLASS W/BLUE/
DD0022
YELLOW BAND
DD0022
DD0022
DIODE VARACTOR ISV201-4
DD0103
DD0103
DIODE 1SS184-TE85R SI
DD0111
DD0111
DIODE VR 1SV188-9
DX0622
DX0622
DIODE HSK120TR TAPING SI DX1042
D047 D052
D012
D042
D201
33
30
10624450
10625556
10625556
11290574
11290574
12237434
10632198
10632198
11412236
10664530
10694065
10694172
25
34
J501
J001
R070 R125
J002
5
4
B301
Y501
P001
DP201
31 29 32 34
IC008
IC012
IC007
IC013
IC011
IC004
IC001 IC002
IC201
R158
R101
R037
R012 R029 R038 R046
10714954
10722296
10730711
10740025
10773976
10773984
10787885
10787885
10787893
10791416
11390929
10898146
10801470
10801470
10808988
10808988
10822963
10844918
10868628
10868628
10877256
10877256
10880680
10880680
10880698
10889566
10889566
10890101
10890101
10898146
10911592
10911592
10915940
10915940
10915965
10915965
10945780
10945780
10945954
10945954
DIODE 1SS85
DIODE MIXER CHIP HSM88
S0T-23
DIODE SI VR MA366-(TX)
DIODE ZN
FOOT
STAND,ABS BLACK
SCREW,D5X10 TAPPING
SCREW, MOUNTING BRACKET
SCREW,3X8 HANDSET
NUT 3M FLANGE
WASHER,STAR
SCREW TAP RH D5X10 (2)
JACK,9.2 ANTENNA
JACK,EARPHONE 3.5MM
JUMPER,CHIP
CONNECTOR,JACK JK-276
ORDER RB1806
KNOB,SQ ABS BLACK
KNOB,VOL ABS BLACK
KEYBOARD ASSY
W/WIRES ASSEMBLED
KEYBOARD,RUBBER
LAMP,PILOT 8V 0.2A
9 PIN SIP
DISPLAY,LIQUID CRYSTAL
DL-056
BRACKET ASSY,MOUNTING
WASHER STAR
MANUAL SERVICE 20-148
XEROX COPY
IC,LM2904 DIP 8 T OPAMP
8 PIN DIP
IC,L78M05CV REGULATOR
IC,NJM3359D-A LINEAR 18P
IC,S81250HG REGULATOR
IC, IR3M03A 8804V
REPLACED BY LA1600
IC, PLL2002A1
IC,UPC1675G-T1
IC,80 P SMD
1
CASE
10
CASE
39
CASE
10946325 100
5%
1/10W CBF RES
0805 PKG OF 5
5%
1/10W CBF RES
0805 PKG OF 5
5%
1/10W CBF RES
0805 PKG OF 5
5%
1/10W CBF RES
DX1042
DX1462
DX1462
DX1709
DX1709
DX1881
DX3293
DX3293
F0078
HC0817
HD0081
HD1939
HD2057
HD7080
HD8020
HW2000148
J0429
J1545
JD0049
JE0098
K0000X
K3517
K3518
KB0058
KB0058
KB0059
L0200
LA1186N
LA1600
LB0212
LB0212
MC0079
MC0079
MS2000148
MU2000148
MX0062
MX0062
MX1452
MX1452
MX1880
MX1880
MX1881
MX3171
MX3171
MX3257
MX3257
MX4637
MX7622
MX7622
MX8178
MX8178
MX8180
MX8180
NDA0022EDC
NDA0022EDC
NDA0063EDC
NDA0063EDC
NDA0092EDC
NDA0092EDC
NDA0132EDC
R131
R077
R091
R138
R077
R091
R073
R078
R105
R204
R078
R105
R074
R082 R083
R106 R107
R082 R083
R106 R107
R121 R127
R111
R159
R021 R081 R098 R133
R143 R144 R205 R209
R211 R212 R213 R214
R215
R151
R014 R071 R146
R076 R152
NDA0132EDC
NDA0132EDC
NDA0142EDC
NDA0142EDC
NDA0144EDC
NDA0144EDC
NDA0149EDC
NDA0149EDC
NDA0159EDC
NDA0159EDC
NDA0169EDC
NDA0169EDC
NDA0176EDC
NDA0176EDC
NDA0196EDC
NDA0196EDC
NDA0196EDC
NDA0199BDC
NDA0199EDC
NDA0199EDC
NDA0206EDC
NDA0206EDC
NDA0210EDC
NDA0210EDC
NDA0216EDC
NDA0216EDC
NDA0224EDC
NDA0224EDC
NDA0230EDC
NDA0230EDC
NDA0237EDC
NDA0237EDC
NDA0247BDC
NDA0247BDC
NDA0247EDC
NDA0247EDC
NDA0257EDC
NDA0257EDC
NDA0262EDC
NDA0262EDC
NDA0281BDC
NDA0281BDC
NDA0281BDC
NDA0281EDC
NDA0281EDC
NDA0288EDC
NDA0288EDC
NDA0297EDC
NDA0297EDC
NDA0330EDC
NDA0330EDC
NDA0371EDC
NDA0371EDC
NDA0371EDC
NDA0371EDC
NDA0402EDC
NDA0402EDC
NDA0410EDC
NDA0410EDC
NDA0423EDC
R134 R147
R001 R207
R114
VR001
VR002
SP501
T001
WA001
B-201
10948511
10948586
10948586
10948644
10948644
10948685
10948685
10974079
10982387
10982387
11020039
11020047
11083748
11083748
11100617
11393147
NDA0423EDC
NDA0433EDC
NDA0433EDC
NDA0445EDC
NDA0445EDC
NDA0454EDC
NDA0454EDC
P6879
PA0736
PA0736
RB1806
RB1807
SPEAKER (SP-247)
SP0273
3"X3"SQUARE 8 OHMS 3WATTS SP0273
TRANSFORMER
TB0236
8 PIN DIP
TBA820M
273-1652
W0000X
11122165 CORD,DC
WB0223
MAIN PCB NST/MRB
XB0000X
USE XB4916
XB4354
REPLACED BY XB4916
XB4354
11161858 PCB ASSY,CONTROL
XB4916
11184975 W/PLATE DISPLAY
Z2414
11186178 COVER,BOTTOM
Z2602
11186327 COVER,TOP
Z2633