Professional Documents
Culture Documents
Passenger Compartment Air Filter Replacement LHD: Print
Passenger Compartment Air Filter Replacement LHD: Print
http://192.168.1.15:9001/servlets/BlobShtml?ShtmlFile...
1. Remove the left sound insulator panel. Refer to Closeout/Insulator Panel Replacement - Left in Instrument Panel, Gauges and Console. 2. Twist the shift cable grommet and position away from the lter access cover. It may be necessary to cut the tie strap, slice and peel back the foam insulation to position the shift cable grommet out of the way to access the lters.
1 of 4
03/11/2012 01:49 PM
Service Information
http://192.168.1.15:9001/servlets/BlobShtml?ShtmlFile...
3. Remove the lter access cover (1). Push down, then pull out.
4. 5. 6. 7. 8.
tape on the rst lter. rst lter by pulling the lter tab. tape on the second lter. second lter by pulling the lter tab. third lter by pulling the lter tab.
Installation Procedure
Important Lubricate the new lter guides with a spray silicon for ease in installation. Keeping
2 of 4
03/11/2012 01:49 PM
Service Information
http://192.168.1.15:9001/servlets/BlobShtml?ShtmlFile...
1. Install the rst lter into the HVAC module assembly. 2. Use the tab or a long screwdriver to raise the lter, so that the leading edge catches on the holding rib inside of the lter case. 3. Install the second lter in the tab of the rst lter. 4. Slide the second lter into the remaining channels of the rst lter. 5. Raise the lters, so that the leading edge catches on the holding rib inside of the lter case. 6. Install the third lter in the tab of the second lter. 7. Slide the third lter into the remaining channels of the second lter. 8. Fold the second lter tab down and the third lter tab up over the second.
3 of 4
03/11/2012 01:49 PM
Service Information
http://192.168.1.15:9001/servlets/BlobShtml?ShtmlFile...
10. Reposition the shift cable grommet. If the insulation was peeled back, it will be necessary to restrap the foam back into the original position. 11. Install the left sound insulator panel. Refer to Closeout/Insulator Panel Replacement - Left in Instrument Panel, Gauges and Console.
4 of 4
03/11/2012 01:49 PM