Professional Documents
Culture Documents
Problem 2: Holes, Rounds, and Chamfers: Dr. S.A.Shah
Problem 2: Holes, Rounds, and Chamfers: Dr. S.A.Shah
Introduction
The problem will test your knowledge of simple feature creation tools, such as holes, rounds, and chamfers.
Problem Statement 1. 2. 3. 4.
Create the part shown in Figure P2-1 using an extruded protrusion with the dimensions shown. Add an 80 inch diameter hole near the top of it as shown in Figure P2-2. Add a 15 inch round between the two sections of the "L" as shown in Figure 2-3. Add a 10 inch chamfer to the top and bottom edge as shown in Figure 2-4.
[Figure P2-1]
Dr. S.A.Shah
Page 1
[Figure P2-2]
Dr. S.A.Shah
Page 2
[Figure P2-3]
Dr. S.A.Shah
Page 3
[Figure P2-4]
Dr. S.A.Shah
Page 4