Professional Documents
Culture Documents
(2014BEL007)
(2014BEL012)
(2014BEL017)
Introduction
The concern of this project is to create a
Hall Effect Sensor Based Non Contact
Type Tachometer.
The system mainly consist of Hall Effect
Sensor and Microcontroller unit along
with regulated power supply and LCD
display.
This project basically concerns with Hall
Effect i.e., output voltage changes with
change in magnetic field.
Working
This projects concerns with Hall Effect.
When rotor will rotate, Hall Effect sensor will
detect change in magnetic field due to attached
magnets.
Due to which, it will send signal to microcontroller
unit (in the form of change in voltage).
Microcontroller unit will work on the data to
produce output. This output will be shown on LCD
display.
Block Diagram
Circuit Diagram
Regulated Power Supply.
Components &
Specifications
Microcontroller Arduino ATmega48.
Sensor- Hall effect sensor with inbuilt amplifying
circuit.
Transformer- 12V AC/500mA.
Diodes(4) - 1N4007.
Regulators - LM7805 & LM7812.
Capacitors - 1000F & 47F.
Crystal oscillator- 20mHz / 16mHZ
LCD 16 X 2(JHD162A)
Strong Magnets
About Sensor
Exposure
Proposed Work
Selection of specification of components used.
Designing of circuit .
1. Power regulation circuit
2. Sensor o/p amplification circuit
3. LCD interfacing with microcontroller.
4. Clocking microcontroller using crystal oscillator.
. The simulation of circuit using simulating
software.
. After successful simulation , practical building of
circuit .
THANK YOU!!!