Professional Documents
Culture Documents
Compound Die
Compound Die
ASHUTOSH PANCHAL
176040319051
LITRETURE SURVEY
There are different types of componat. Are as below
1. Cutting die
2. Combination die
3. Draw die
4. Inverted draw die
5. Progressive die
My project is COMPOUND DIE
WORKING PRINCIPLE:
A typical die and punch set used for drawing operation. The sheet metal
used for drawing is called blank. The punch which is held in the punch holder is
bolted to the table while die is bolted the ram. During the working stroke press
on press the punch draw the blank, and on the return stroke of the press ram the
blank is lifted with the punch, but is removed from the punch by the stripper
plate and blank removed by sadder.
TERMINOLOGY OF DIE & PRESS MACHINE
Press machine
Shut height
Stroke/minute
Tonnage capacity
Type
1. Mechanical
2. Hydraulic
Type of Drives
1. Crank shaft drive
BILL OF MATERIAL
A FOR RAW MATERIAL
1. SHANK RAW MATERIAL SIZE :- Ø52*70 M.M. LONG M.S. ROUND BAR
2. SHANK PLATE RAW MATERIAL SIZE :- M6*100
3. TOTLALLEN BOLT :- 3 NO’S
4. Ø80*22 M.M. M.S. ROUND BAR FLANGE
5. RAW MATERIAL SIZE:- Ø62*92 M.M. LONG H.C.H.Cr. ROUND BAR
6. RAW MATERIAL SIZE:- Ø22*12 M.M. LONG M.S. ROUND BAR
7. RAW MATWERIAL SIZE:- Ø8*200 M.M. LONG M.S. ROUND BAR
8. RAW MATWERIAL SIZE:- Ø62*22 M.M. ROUND FLANGE
9. RAW MATWERIAL SIZE:- Ø62*22 M.M. ROUND FLANGE
10. RAW MATWERIAL SIZE:- Ø25*90 M.M. LONG H.C.H.Cr. ROUND BAR
11. RAW MATWERIAL SIZE:- Ø80*22 M.M. ROUND FLANGE
B FOR PURCHASE PART
1. SPRING
SPRING SIZE :- OUT SIDE DIAMETER :- Ø12*8
WIRE THICKNESS :- 2.0 M.M.
TOTAL SPRING:- 3 NO’S
2. DOWEL PIN
SIZE :- Ø10*100 M.M. LONG
TOTAL DOWEL PIN:- 3 NO’S
3 ALLEN BOLT
SIZE :- M6*100
TOTAL ALLEN BOLT:- 3NO’S
USED OF MACHINERIES WITH
SPECIFICATION
LATHE MACHINE
Speed: 150 – 1400 rpm
Motor: 1.5 hp
Drilling machine
Speed : 33 – 825 rpm
Motor: 0.75 hp
Hacksaw machine
Grinding machine
Shaping machine
List of equipments
Vernier caliper
Dial gauge
Hand tools
Tap & tap wrench
Remer
Rough file
Consumable
Oil
Coolant
Holding devices
Three jaw chuck
Tool maker vice
Bench vice
Parallel clamp
V block
Magnetic chuck
Swivel machine vice