Professional Documents
Culture Documents
Some other plant owners use three level alarms: advisory, warning,
and critical
Hệ thống báo động (alarm system)
Hệ thống báo động: phát hiện và báo động (bằng còi hụ hoặc đèn
nhấp nháy) khi có một tình huống bất thường xảy ra (ví dụ: một
thông số hoạt động vượt ngưỡng hoặc phát hiện khí bị rò rỉ)
Hệ thống báo động (alarm system)
Phương pháp cổ điển (dựa trên quy tắc kinh nghiệm) để thiết kế
hệ thống SIS đã trở nên lỗi thời. Phương pháp mới, tốt hơn để
thiết kế hệ thống SIS là dựa trên kết quả phân tích các nguy cơ,
các rủi ro có thể xảy ra trong quy trình (và hậu quả xảy ra) để thiết
kế hệ thống SIS để chống lại / ngăn chặn/ giảm thiểu các nguy cơ,
các rủi ro này. Có hai cách tiếp cận:
Định tính (qualitative method): dựa trên kết quả đánh giá
HAZOP (Hazard and Operability Study)
Định lượng (quantitative method): một thao tác vận hành cụ
thể hoặc một thiết bị trong quy trình (a process equipment or
an instrument) sẽ được đánh giá và cho điểm trong thang điểm
SIL (safety integrity level) từ một đến bốn.
Hệ thống SIS
Tốn rất nhiều thời gian để đánh giá SIL cho toàn bộ các thiết bị
trong nhà máy, do đó người ta thường dùng một phương pháp kết
hợp cả hai phương án này:
Đầu tiên, thực hiện HAZOP cho toàn bộ quy trình
Những thiết bị chưa được kết luận về mức độ rủi ro trong
HAZOP sẽ được đánh giá SIL (safety integrity level)
Dựa trên kết quả phân tích về các nguy cơ, các rủi ro (HAZOP
study & SIL evaluation), người ta sẽ tiến hành thiết kế hệ thống
SIS
=> Tham khảo tài liệu 4, 5, 6 để biết thêm chi tiết
Hệ thống SIS
Emergency isolation
Hệ thống SIS
Shutdown
Hệ thống SIS
LSLL=
Level Switch Low Low
LSHH =
Level Switch High High
Hệ thống SIS
When the liquid level in the tank become too high (high-high
level), SIS actions can be one of the followings (or both): i)
shutdown the incoming flow, ii) fully open the outlet valve
Hệ thống SIS
A solenoid block
valve on the pneumatic line of
the control valve
Air-fail-close (AFC)
Hệ thống SIS – Một số ví dụ
Electric motor
operated valve (MV)
On / off valve
Normally open
Air-fail-open (AFO)
Hệ thống SIS – Một số ví dụ
Control scheme for a single-stage once-through liquid-liquid extraction system. Cs denotes the
concentration of the solute; I denotes the interface level; T denotes the total level
Hệ thống SIS – Một số ví dụ
Calculation block
Typical safety system for a fixed bed reactor with an exothermic reaction and two reactants,
both of which are preheated
Van xả áp / Van an toàn –
Pressure Relief Valves / Safety Valves
Pressure relief devices are an essential requirement for the safe use
of pressure vessels. The purpose of the pressure relief device is to
prevent catastrophic failure of the vessel by providing a safe means
of relieving overpressure if the pressure inside the vessel exceeds
the maximum allowable working pressure (MAWP)
Full port