Professional Documents
Culture Documents
March, 2019
www.huawei.com
Availability
Traffic KPI
ERAB Success Rate Downlink Traffic
Uplink Traffic.
Retainability User Number
Service Drop Rate
Mobility KPI
Intra. Frequency HOSR
LTE CSFB Redirection Setup Success rate
Utilization KPI
Uplink Preschedule Resource Block Occupied Rate
Resources Block Utilization
CPU Load
HUAWEI TECHNOLOGIES CO., LTD. Huawei Confidential
LTE KPI
RRC Setup Success Rate.
Based on this request, the eNB sends a RRC Connection Setup message which contains the information of SRB and some basic radio parameters like power control,
SRI & CQI periodicity.
Once, the UE gets the RRC Connection Setup, it makes the changes based on the instructions in the message and then responds with RRC Connection Setup Complete
message. This message also contains the NAS information if the UE intends to send it.
Firstly, lets understand the definition and points where the ERAB KPI is pegged. After the UE sends the RRC Setup Complete message to the eNB, the eNB sends a S1 Initial UE Message to the MME
indicating the purpose of the UE (Attach, TAU, CSFB, Service Request etc) and its credentials. Once the MME receives this message and it decides that a bearer is required, it will send an Initial Context
Setup Request to the eNB. This message is considered as the ERAB Attempt as it contains the bearers to be added along with their QCI values. The eNB receives this message and adds the DRB (Data
Radio Bearer) based on the bearer profile in Initial Context Setup Request. But before the eNB can add bearers, it needs to activate the security for the connection. This is done by the Security Mode
Command which carries the ciphering and integrity protection algorithms. After this the eNB sends a RRC Connection Reconfiguration message to the UE which adds a DRB and it includes the configuration
for the DRB like bearer identity, PDCP & RLC configuration (AM/UM etc). SRB2 is also added at this point with this message. The UE receives these messages and reconfigures the connection. Then the UE
responds with Security Mode complete and RRC Connection Reconfiguration Complete messages. As the eNB receives these messages, it sends an Initial Context Setup Response to MME and this
message is considered as the ERAB Success.
Thank You
WWW.Huawei.com
www.huawei.com