Professional Documents
Culture Documents
Semester: I
SECTION - B
SEMESTER EXAMINATION
WINTER_2012
E1)
Make 3D Wire frame drawing and then surface it from the given 3D model.
15
02
GENERAL INSTRUCTION
1. 2. 3. Attempt all questions. Show all the dimensions. Write down the name of the tool path used for solving the problem given in section C on your Answer Sheet. NOTE: Credit will be given operation sequence, preparation & accuracy of drawing.
SECTION - A
S1) Make 2D drawing from given 3D model & dimension the Views.(Three projected views)
15
01
MSME TOOL ROOM AURANAGABAD Indo-German Tool Room, Aurangabad Training Centre Page 1of 2
TRG: FO: 43 / 01
MSME TOOL ROOM AURANAGABAD Indo-German Tool Room, Aurangabad Training Centre Page 2 of 2
TRG: FO: 43 / 01
E2) Make 3D SOLID MODEL as given below. show all dimensions. 1 x 15 marks
Max. Marks Chap. No.
Total marks
SECTION - C
Total marks 1 x 15 marks
15
03
S2)
Max. Marks
Chap. No.
15
04
MSME TOOL ROOM AURANAGABAD Indo-German Tool Room, Aurangabad Training Centre Page 1of 2
TRG: FO: 43 / 01
MSME TOOL ROOM AURANAGABAD Indo-German Tool Room, Aurangabad Training Centre Page 2 of 2
TRG: FO: 43 / 01
TOPIC 01) 2D MODELLING 02) 3D WIREFRAME MODELLING & SURFACE MODELING 03) SOLID MODELING 04) TOOL PATH GENERATION
SECTION A
SECTION B
SECTION C
MARKS 15
15
25%
15
15
25%
15 15
15 15
25% 25%
MSME TOOL ROOM AURANAGABAD Indo-German Tool Room, Aurangabad Training Centre Page 1of 2
TRG: FO: 43 / 01
MSME TOOL ROOM AURANAGABAD Indo-German Tool Room, Aurangabad Training Centre Page 2 of 2
TRG: FO: 43 / 01