Professional Documents
Culture Documents
Material Comparison Report For Cladding
Material Comparison Report For Cladding
SUMMARY
This report is intended for structural evaluation of two materials for KAFD conference center. SPECIFICATIONS AND R EFERENCES ALUCOBOND Technical Data Sheets. MATERIALS Aluminum 6063-T6 Alucobond 6mm
DESIGN CRITERIA
Dead Loads Self weight of the materials Deflections - Metal faced composite wall panel assemblies shall withstand wind loads with horizontal deflection no greater than 1/175 of the span at the perimeter and 1/60 of the span anywhere in the panel. Load Combinations 1.0DL + 1.0WL+ 1.0DL + 1.0WLWind Load: 1.2 KPa, as positive and negative wind pressure for external items.
ALUMCO KSA
ALUMCO KSA Technical Department
September, 2013
COMPARISON
Both panels are 4 side supported and the same dimension of 1.2m2.19m. Reinforcement of the aluminum sheet is RHS 40x20x2mm thick aluminum, adopted wind load 1.2 KPa for both. CHARACTERISTIC/ ALUMINUM COMPOSITE CAPACITY/ PANEL(ALUCOBOND) 6mm THICK RESULT No. of 0 Reinforcement Deflection Allowable of 1200/60 = 20mm 16.9mm ALUMINUM SHEET 2mm THICK
5 9.1mm
Stress Allowable for aluminum sheet = 160/1.2 = 133.33 MPa For ACP 90/1.2 = 75 MPa
24.25 MPa
106.10 MPa
Yield strength
90 MPa
160 MPa
ALUMCO KSA
ALUMCO KSA Technical Department
September, 2013